Electrical Treeing in Power Cable Insulation under Harmonics Superimposed on Unfiltered HVDC Voltages

Insulation degradation is an irreversible phenomenon that can potentially lead to failure of power cable systems. This paper describes the results of an experimental investigation into the influence of direct current (DC) superimposed with harmonic voltages on both partial discharge (PD) activity and electrical tree (ET) phenomena within polymeric insulations. The test samples were prepared from a high voltage direct current (HVDC) cross linked polyethylene (XLPE) power cable. A double electrode arrangement was employed to produce divergent electric fields within the test samples that could possibly result in formation of electrical trees. The developed ETs were observed via an optical method and, at the same time, the emanating PD pulses were measured using conventional techniques. The results show a tenable relation between ETs, PD activities, and the level of harmonic voltages. An increase in harmonic levels has a marked effect on development of electrical trees as the firing angle increases, which also leads to higher activity of partial discharges. This study of the influencing operational parameters of HVDC converters on power cable insulation is predicted to contribute to enhancements in cable design and progressive advancement in condition monitoring and insulation diagnostic techniques that can lead to more effective asset management in HVDC systems.

[1]  R. Bodega,et al.  The effect of voltage frequency on partial discharge activity , 2002, Annual Report Conference on Electrical Insulation and Dielectric Phenomena.

[2]  W. G. Chadband.  Electrical Degradation and Breakdown in Polymers , 1992 .

[3]  Davide Fabiani,et al.  The effect of voltage distortion on ageing acceleration of insulation systems under partial discharge activity , 2001 .

[4]  Jun Liang,et al.  Hvdc Grids: For Offshore and Supergrid of the Future , 2016 .

[5]  S. Bahadoorsingh,et al.  Modeling of partial discharges in the presence of harmonics , 2009, 2009 IEEE Conference on Electrical Insulation and Dielectric Phenomena.

[6]  Wang Huiming,et al.  Space charges and initiation of electrical trees , 1989 .

[7]  Eugene McMahon,et al.  A Tutorial on Treeing , 1978, IEEE Transactions on Electrical Insulation.

[8]  G. C. Montanari,et al.  Investigation of aging rate in polymer films subjected to surface discharges under distorted voltage , 1997, IEEE 1997 Annual Report Conference on Electrical Insulation and Dielectric Phenomena.

[9]  Pawel Zydron,et al.  Impact of high voltage harmonics on interpretation of partial discharge patterns , 2013, IEEE Transactions on Dielectrics and Electrical Insulation.

[10]  Minnebo Philip,et al.  HVDC Submarine Power Cables in the World: State-of-the-Art Knowledge , 2015 .

[11]  A Cavallini,et al.  Diagnostic of HVDC systems using partial discharges , 2011, IEEE Transactions on Dielectrics and Electrical Insulation.

[12]  Tong Liu,et al.  A new method of estimating the inverse power law ageing parameter of XLPE based on step-stress tests , 2013, 2013 Annual Report Conference on Electrical Insulation and Dielectric Phenomena.

[13]  M. Mammeri,et al.  Dynamics of voltage polarity reversal as the controlling factor in space-charge induced breakdown of insulating polymers , 1997 .

[14]  S M Rowland,et al.  Investigating the impact of harmonics on the breakdown of epoxy resin through electrical tree growth , 2010, IEEE Transactions on Dielectrics and Electrical Insulation.

[15]  Barry W. Williams,et al.  Medium-Voltage 12-Pulse Converter: Output Voltage Harmonic Compensation Using a Series APF , 2014, IEEE Transactions on Industrial Electronics.

[16]  R. Sarathi,et al.  Understanding electrical treeing phenomena in XLPE cable insulation under harmonic AC voltages adopting UHF technique , 2012, IEEE Transactions on Dielectrics and Electrical Insulation.

[17]  L. A. Dissado,et al.  Propagation of electrical tree structures in solid polymeric insulation , 1997 .

[18]  D. M. Hepburn,et al.  Partial discharge behavior under HVDC superimposed with transients , 2016, 2016 51st International Universities Power Engineering Conference (UPEC).

[19]  Roberto Ramirez-Iniguez,et al.  Performance Comparison of a Freeform Lens and a CDTIRO When Combined With an LED , 2017, IEEE Photonics Journal.

[20]  A. Minoda,et al.  DC short-circuit treeing phenomenon and space charge effect in EPR at cryogenic temperature , 1997, Proceedings of 5th International Conference on Properties and Applications of Dielectric Materials.

[21]  Mohamed Emad Farrag,et al.  Electrical Treeing in Cable Insulation under Different HVDC Operational Conditions , 2018, Energies.

[22]  F. Jenau,et al.  Measurement and statistical analysis of Partial Discharges at DC voltage , 2013, 2013 48th International Universities' Power Engineering Conference (UPEC).

[23]  S. Boggs,et al.  Thermal and mechanical properties of EPR and XLPE cable compounds , 2006, IEEE Electrical Insulation Magazine.

[24]  Shengtao Li,et al.  Investigations of electrical trees in the inner layer of XLPE cable insulation using computer-aided image recording monitoring , 2010, IEEE Transactions on Dielectrics and Electrical Insulation.

[25]  P. K. Olsen,et al.  The effect of DC superimposed AC voltage on partial discharges in dielectric bounded cavities , 2014, 2014 ICHVE International Conference on High Voltage Engineering and Application.

[26]  Giovanni Mazzanti,et al.  Extruded Cables For High-Voltage Direct-Current Transmission , 2013 .

[27]  R. Densley,et al.  An Investigation into the Growth of Electrical Trees in XLPE Cable Insulation , 1979, IEEE Transactions on Electrical Insulation.