Glass transitions in native silk fibres studied by dynamic mechanical thermal analysis.

Silks are a family of semi-crystalline structural materials, spun naturally by insects, spiders and even crustaceans. Compared to the characteristic β-sheet crystalline structure in silks, the non-crystalline structure and its composition deserves more attention as it is equally critical to the filaments' high toughness and strength. Here we further unravel the structure-property relationship in silks using Dynamic Mechanical Thermal Analysis (DMTA). This technique allows us to examine the most important structural relaxation event of the disordered structure the disordered structure, the glass transition (GT), in native silk fibres of the lepidopteran Bombyx mori and Antheraea pernyi and the spider Nephila edulis. The measured glass transition temperature Tg, loss tangent tan δ and dynamic storage modulus are quantitatively modelled based on Group Interaction Modelling (GIM). The "variability" issue in native silks can be conveniently explained by the different degrees of structural disorder as revealed by DMTA. The new insights will facilitate a more comprehensive understanding of the structure-property relations for a wide range of biopolymers.

[1]  Zhiping Xu,et al.  Nanoconfinement Controls Stiffness, Strength and Mechanical Toughness of Β-sheet Crystals in Silk , 2010 .

[2]  Yi Liu,et al.  Relationships between supercontraction and mechanical properties of spider silk , 2005, Nature materials.

[3]  David L. Kaplan,et al.  New Opportunities for an Ancient Material , 2010, Science.

[4]  M. Elices,et al.  Controlled supercontraction tailors the tensile behaviour of spider silk , 2003 .

[5]  G. Plaza,et al.  Thermo‐hygro‐mechanical behavior of spider dragline silk: Glassy and rubbery states , 2006 .

[6]  C. Viney,et al.  Non-periodic lattice crystals in the hierarchical microstructure of spider (major ampullate) silk. , 1997, Biopolymers.

[7]  Lina Zhang,et al.  New evidences of glass transitions and microstructures of soy protein plasticized with glycerol. , 2005, Macromolecular bioscience.

[8]  Fujia Chen,et al.  Structure and physical properties of silkworm cocoons , 2012, Journal of The Royal Society Interface.

[9]  Z. Shao,et al.  Using solvents with different molecular sizes to investigate the structure of Antheraea pernyi silk. , 2013, Biomacromolecules.

[10]  Z. Shao,et al.  Understanding the Mechanical Properties of Antheraea Pernyi Silk—From Primary Structure to Condensed Structure of the Protein , 2011 .

[11]  F Vollrath,et al.  Variability in the mechanical properties of spider silks on three levels: interspecific, intraspecific and intraindividual. , 1999, International journal of biological macromolecules.

[12]  Fritz Vollrath,et al.  Spider silk as archetypal protein elastomer. , 2006, Soft matter.

[13]  Dawn M. Crawford,et al.  Dynamic mechanical analysis of novel polyurethane coating for military applications , 2000 .

[14]  Fritz Vollrath,et al.  Structural disorder in silk proteins reveals the emergence of elastomericity. , 2008, Biomacromolecules.

[15]  T. Lefèvre,et al.  Diversity of molecular transformations involved in the formation of spider silks. , 2011, Journal of molecular biology.

[16]  Chris Holland,et al.  Linking naturally and unnaturally spun silks through the forced reeling of Bombyx mori. , 2015, Acta biomaterialia.

[17]  P. Zhou,et al.  Toughness of Spider Silk at High and Low Temperatures , 2005 .

[18]  D. Porter.  Group Interaction Modelling of Polymer Properties , 1995 .

[19]  Chi-Hang Lam,et al.  Glass Transition Dynamics and Surface Layer Mobility in Unentangled Polystyrene Films , 2010, Science.

[20]  D. Porter,et al.  Water mobility, denaturation and the glass transition in proteins. , 2012, Biochimica et biophysica acta.

[21]  M. Born.  Thermodynamics of Crystals and Melting , 1939 .

[22]  L. Jelinski,et al.  Small-Angle X-ray Scattering of Spider Dragline Silk , 1997 .

[23]  F Vollrath,et al.  Predicting the mechanical properties of spider silk as a model nanostructured polymer , 2005, The European physical journal. E, Soft matter.

[24]  J. Trancik,et al.  Nanostructural features of a spider dragline silk as revealed by electron and X-ray diffraction studies , 2006 .

[25]  D. Porter,et al.  Predictive nonlinear constitutive relations in polymers through loss history , 2009 .

[26]  A. Kisliuk,et al.  A broad glass transition in hydrated proteins. , 2010, Biochimica et biophysica acta.

[27]  David L. Kaplan,et al.  Mechanical and thermal properties of dragline silk from the spider Nephila clavipes , 1994 .

[28]  G. Plaza,et al.  The effect of spinning forces on spider silk properties , 2005, Journal of Experimental Biology.

[29]  P. Royall,et al.  The development of DMA for the detection of amorphous content in pharmaceutical powdered materials. , 2005, International journal of pharmaceutics.

[30]  A. Percot,et al.  Water dependent structural changes of silk from Bombyx mori gland to fibre as evidenced by Raman and IR spectroscopies , 2014 .

[31]  Bernd Markert,et al.  Mechanical response of silk crystalline units from force-distribution analysis. , 2009, Biophysical journal.

[32]  D. Porter,et al.  Two mechanisms for supercontraction in Nephila spider dragline silk. , 2011, Biomacromolecules.

[33]  Z. Shao,et al.  Moisture Effects on Antheraea pernyi Silk's Mechanical Property , 2009 .

[34]  M. Auger,et al.  Evidence by infrared spectroscopy of the presence of two types of β-sheets in major ampullate spider silk and silkworm silk , 2013 .

[35]  F. Grosse,et al.  Composition and Hierarchical Organisation of a Spider Silk , 2007, PloS one.

[36]  F. Gräter,et al.  Viscous Friction between Crystalline and Amorphous Phase of Dragline Silk , 2014, PloS one.

[37]  T. Asakura,et al.  Silk structure studied with nuclear magnetic resonance. , 2013, Progress in nuclear magnetic resonance spectroscopy.

[38]  M. Williamson,et al.  Analysis of the Structure of Bombyx mori Silk Fibroin by NMR , 2015 .

[39]  W. Doster.  The dynamical transition of proteins, concepts and misconceptions , 2008, European Biophysics Journal.

[40]  G. Szamel,et al.  Fundamental differences between glassy dynamics in two and three dimensions , 2015, Nature Communications.

[41]  M. Osterhold,et al.  Dynamic mechanical analysis in coatings industry , 2004 .

[42]  T. Yamane,et al.  Heterogeneous structure of silk fibers from Bombyx mori resolved by 13C solid-state NMR spectroscopy. , 2002, Journal of the American Chemical Society.

[43]  Shigeo Nakamura,et al.  Physical properties and structure of silk. III. The glass transition and conformational changes of tussah silk fibroin , 1977 .

[44]  T. Lefèvre,et al.  Attenuated Total Reflection Infrared Spectroscopy: An Efficient Technique to Quantitatively Determine the Orientation and Conformation of Proteins in Single Silk Fibers , 2008, Applied spectroscopy.

[45]  Thierry Lefèvre,et al.  Protein secondary structure and orientation in silk as revealed by Raman spectromicroscopy. , 2007, Biophysical journal.

[46]  David R. Reichman,et al.  Soft colloids make strong glasses , 2009, Nature.

[47]  M. Elices,et al.  Reproducibility of the tensile properties of spider (Argiope trifasciata) silk obtained by forced silking. , 2005, Journal of experimental zoology. Part A, Comparative experimental biology.

[48]  R. Mccullough,et al.  The influence of particle size and distortions upon the X-ray diffraction patterns of polymers , 1963 .

[49]  B. Meier,et al.  The molecular structure of spider dragline silk: Folding and orientation of the protein backbone , 2002, Proceedings of the National Academy of Sciences of the United States of America.

[50]  Gangqin Xu,et al.  What makes spider silk fibers so strong? From molecular-crystallite network to hierarchical network structures. , 2013, Soft matter.

[51]  Fritz Vollrath,et al.  Thermally induced changes in dynamic mechanical properties of native silks. , 2013, Biomacromolecules.

[52]  P. Colomban,et al.  Nanomechanics of single silkworm and spider fibres: a Raman and micro-mechanical in situ study of the conformation change with stress , 2008 .

[53]  C. Craig,et al.  Evolution of arthropod silks. , 1997, Annual review of entomology.

[54]  Z. Shao,et al.  Understanding the variability of properties in Antheraea pernyi silk fibres. , 2014, Soft matter.

[55]  A. Percot,et al.  Origin of the variability of the mechanical properties of silk fibers: 4. Order/crystallinity along silkworm and spider fibers , 2014 .

[56]  Fritz Vollrath,et al.  There are many more lessons still to be learned from spider silks , 2011 .

[57]  Jinrong Yao,et al.  Correlation between structural and dynamic mechanical transitions of regenerated silk fibroin , 2010 .

[58]  P. Colomban,et al.  Micro-Raman study of the fatigue and fracture behaviour of single PA66 fibres: Comparison with single PET and PP fibres , 2006 .