Obstacle surpassing and posture control of a stair-climbing robotic mechanism

Abstract In this study, we propose a new kinematic control for a robotic stair-climbing mechanism which allows successful obstacle surpassing when faced with typical architectural barriers such as curbs, ramps or staircases while maintaining the passenger's comfort and the seat's inclination within security margins. The scheme also takes into account perturbations in the system due to the fact that the environment is not perfectly known. The actuated degrees of freedom in charge of the locomotion device and the posture device are controlled in a different way. The locomotion control is achieved with a feedforward term and a standard proportional derivative (PD) control position. The posture control is obtained with a novel variant of multilevel feedback controller design via a suitable combination of a Lyapunov feedback controller design along with a multilevel generalization of the sliding mode based Sigma–Delta ( Σ – Δ ) modulator coupled with an adequate selection of the trajectory of the center of mass. The main features of this novel kinematic control algorithm are: maintenance of the passenger comfort, high degree of perturbation rejection regarding modeling error, independence of the designed control law on the environment parameters, computational efficiency and minimal sensor requirements. Numerical simulations illustrate the performance of the proposed method when the prototype is to surpass an obstacle with different heights with the value of the height obstacle being unknown. Finally, experimental results validate the behavior of the prototype for, both, obstacle surpassing and posture control when the wheelchair prototype ascends a curb of 180 mm.

[1]  H. Sira-Ramirez,et al.  On the GPI-sliding mode control of switched fractional order systems , 2006, International Workshop on Variable Structure Systems, 2006. VSS'06..

[2]  Eiji Nakano,et al.  Motion control technique for practical use of a leg-wheel robot on unknown outdoor rough terrains , 2004, 2004 IEEE/RSJ International Conference on Intelligent Robots and Systems (IROS) (IEEE Cat. No.04CH37566).

[3]  Nikolaos G. Bourbakis.  Kydonas-an autonomous hybrid robot: walking and climbing , 1998, IEEE Robotics Autom. Mag..

[4]  J. Pons,et al.  A robotic vehicle for disabled children , 2005, IEEE Engineering in Medicine and Biology Magazine.

[5]  Vadim I. Utkin,et al.  Sliding Modes and their Application in Variable Structure Systems , 1978 .

[6]  Vicente Feliú Batlle,et al.  Environment adaptation of a new staircase-climbing wheelchair , 2007, Auton. Robots.

[7]  Chun-Ta Chen,et al.  Design and realization of a mobile wheelchair robot for all terrains , 2003, Adv. Robotics.

[8]  Hebertt Sira-Ramírez,et al.  Sliding Mode ∑‐Δ Modulation Control of the Boost Converter , 2008 .

[9]  Weiping Li,et al.  Applied Nonlinear Control , 1991 .

[10]  Vicente Feliú Batlle,et al.  Coordinated motion of a new staircase climbing wheelchair with increased passenger comfort , 2006, Proceedings 2006 IEEE International Conference on Robotics and Automation, 2006. ICRA 2006..

[11]  Shigeo Hirose,et al.  Design of a quadruped walking vehicle for dynamic walking and stair climbing , 1994, Adv. Robotics.

[12]  Vijay R. Kumar,et al.  Design of a wheelchair with legs for people with motor disabilities , 1995 .

[13]  R.A. Cooper,et al.  Electric powered wheelchairs , 2005, IEEE Control Systems.

[14]  R. Schreier,et al.  Delta-sigma data converters : theory, design, and simulation , 1997 .

[15]  Hebertt Sira-Ramírez,et al.  Control Design Techniques in Power Electronics Devices , 2006 .

[16]  Sunil Kumar Agrawal,et al.  Babies driving robots: self-generated mobility in very young infants , 2008, Intell. Serv. Robotics.

[17]  J. Dansereau,et al.  Kinematic modeling for the assessment of wheelchair user's stability , 2001, IEEE Transactions on Neural Systems and Rehabilitation Engineering.

[18]  Vicente Feliú Batlle,et al.  Kinematic Model of a New Staircase Climbing Wheelchair and its Experimental Validation , 2006, Int. J. Robotics Res..

[19]  H. Sira-Ramírez.  Differential geometric methods in variable-structure control , 1988 .

[20]  S B Skaar,et al.  Initial results in the development of a guidance system for a powered wheelchair. , 1996, IEEE transactions on rehabilitation engineering : a publication of the IEEE Engineering in Medicine and Biology Society.

[21]  Vicente Feliú Batlle,et al.  Optimized obstacle avoidance trajectory generation for a reconfigurable staircase climbing wheelchair , 2010, Robotics Auton. Syst..

[22]  Vicente Feliú Batlle,et al.  Improving the mechanical design of new staircase wheelchair , 2007, Ind. Robot.

[23]  M.J. Lawn,et al.  Modeling of a stair-climbing wheelchair mechanism with high single-step capability , 2003, IEEE Transactions on Neural Systems and Rehabilitation Engineering.

[24]  R. Steele,et al.  Delta Modulation Systems , 1975 .