Investigation of a hydrocarbon-degrading strain, Rhodococcus ruber Z25, for the potential of microbial enhanced oil recovery

A hydrocarbon-degrading strain. Rhodococcus ruber Z25, was isolated from the formation brine in Daqing Oilfield, China. The strain Z25 was able to grow under facultative anaerobic condition and produce biosurfactant while hydrocarbon was used as sole carbon source. The biosurfactant of R. ruber Z25 showed a perfect emulsification activity and was able to lower the interfacial tension to approximately 1.0 mN/m and achieved a CMC value of 57 mg/L The biodegradation experiments of the crude oil by the strain Z25 under aerobic and anaerobic conditions exhibited positive effects in improving the physical properties of the crude oil, including mobility enhancement, cloud point reduction and wax degradation. Waterflooding experiments were done to investigate the MEOR potential of the strain and varied oil recovery efficiencies from 8.88% to 25.78% were achieved. The main MEOR mechanisms of the strain Z25 included hydrocarbon degradation, improvement of oil mobility, wettability alteration and selective plugging. These results revealed that strain Z25 exhibited a tremendous potential for MEOR application. (C) 2011 Elsevier B.V. All rights reserved.

[1]  L. Rodrigues,et al.  Interference in adhesion of bacteria and yeasts isolated from explanted voice prostheses to silicone rubber by rhamnolipid biosurfactants , 2006, Journal of applied microbiology.

[2]  Asma Etoumi,et al.  Microbial treatment of waxy crude oils for mitigation of wax precipitation , 2007 .

[3]  Murray R. Gray,et al.  Stabilization of Oil-Water Emulsions by Hydrophobic Bacteria , 2004, Applied and Environmental Microbiology.

[4]  N.Ravi,et al.  Development of Microorganisms with Improved Transport and Biosurfactant Activity for Enhanced Oil Recovery , 2003 .

[5]  R. S. Bryant,et al.  Review of microbial technology for improving oil recovery , 1989 .

[6]  R. R. Ibatullin,et al.  Use of Microorganisms in the Biotechnology for the Enhancement of Oil Recovery , 2004, Microbiology.

[7]  A. Nerurkar,et al.  Evaluation of bioemulsifier mediated Microbial Enhanced Oil Recovery using sand pack column. , 2008, Journal of microbiological methods.

[8]  Li Wang,et al.  A Pilot Test Using Microbial Paraffin-Removal Technology in Liaohe Oilfield , 2003 .

[9]  Jian-qiang Lin,et al.  Isolation, identification, and performance studies of a novel paraffin-degrading bacterium of Gordonia amicalis LH3 , 2008 .

[10]  Laboratory Studies of MEOR in the Micromodel as a Fractured System , 2007 .

[11]  Irene Gullapalli,et al.  Laboratory Design and Field Implementation of Microbial Profile Modification Process , 2000 .

[12]  R. R. Ibatullin,et al.  Additional Oil Production During Field Trials in Russia , 1993 .

[13]  Ajay Singh,et al.  Surfactants in microbiology and biotechnology: Part 2. Application aspects. , 2007, Biotechnology advances.

[14]  Cha Dong,et al.  Preparation of konjac glucomannan ester of palmitic acid and its emulsification , 1998 .

[15]  Mutai Bao,et al.  Laboratory study on activating indigenous microorganisms to enhance oil recovery in , 2009 .

[16]  C. Jeon,et al.  Isolation and Characterization of Bacteria Capable of Degrading Phenol and Reducing Nitrate Under Low-Oxygen Conditions , 2003, Current Microbiology.

[17]  N. Youssef,et al.  Importance of 3-Hydroxy Fatty Acid Composition of Lipopeptides for Biosurfactant Activity , 2005, Applied and Environmental Microbiology.

[18]  J. Philp,et al.  Recovery of Rhodococcus biosurfactants using methyl tertiary-butyl ether extraction. , 2001, Journal of microbiological methods.

[19]  R. S. Bryant,et al.  Evaluation of Microbial Systems in Porous Media for EOR , 1988 .

[20]  Zhenyu Yang,et al.  Microbe-Enhanced Oil Recovery Technology Obtains Huge Success in Low-Permeability Reservoirs in Daqing Oilfield , 2006 .

[21]  Dennis Denney.  Paraffin Treatments: Hot Oil/Hot Water vs. Crystal Modifiers , 2001 .

[22]  Yuehui She,et al.  Microbiological investigations of high-temperature horizons of the Kongdian petroleum reservoir in connection with field trial of a biotechnology for enhancement of oil recovery , 2007, Microbiology.

[23]  Lixin Huang,et al.  Study of the biosurfactant-producing profile in a newly isolatedRhodococcus ruber strain , 2009, Annals of Microbiology.

[24]  A. P. Serro,et al.  The influence of proteins on calcium phosphate deposition over titanium implants studied by dynamic contact angle analysis and XPS , 1997 .

[25]  Owen P. Ward,et al.  Recent Advances in Petroleum Microbiology , 2003, Microbiology and Molecular Biology Reviews.

[26]  E. Ron,et al.  High- and low-molecular-mass microbial surfactants , 1999, Applied Microbiology and Biotechnology.

[27]  Jeffrey A Cunningham,et al.  Enhanced anaerobic bioremediation of groundwater contaminated by fuel hydrocarbons at Seal Beach, California , 2004, Biodegradation.

[28]  V. Wray,et al.  Alkanotrophic Rhodococcus ruber as a biosurfactant producer , 2002, Applied Microbiology and Biotechnology.

[29]  A. Bodour,et al.  Biosurfactants: Types, Screening Methods, and Applications , 2003 .

[30]  F. Widdel,et al.  Metabolism of alkylbenzenes, alkanes, and other hydrocarbons in anaerobic bacteria , 2004, Biodegradation.

[31]  D. Kerridge.  FLAGELLAR SYNTHESIS IN SALMONELLA TYPHIMURIUM: THE INCORPORATION OF ISOTOPICALLY-LABELLED AMINO ACIDS INTO FLAGELLIN. , 1963, Journal of general microbiology.

[32]  Ole Torsæter,et al.  Microbial improved oil recovery—bacterial induced wettability and interfacial tension effects on oil production , 2006 .

[33]  M. Kubo,et al.  Biodegradation of long-chain n-paraffins from waste oil of car engine by Acinetobacter sp. , 2001, Journal of bioscience and bioengineering.

[34]  I. Lazar.  Ch. A-1 MEOR Field Trials Carried Out Over the World During the Last 35 Years , 1991 .