Laboratory Catalytic Reactors: Aspects of Catalyst Testing

The sections in this article are Introduction Reactor Systems Classification Types of Laboratory Reactors Gas–Solid and liquid–Solid Reactions Gas–Liquid–Solid Reactions Design Equations CSTR PFR Summary of Laboratory Systems Mass and Heat Transfer Extraparticle Gradients Intraparticle Gradients Catalyst Bed Gradients Gas–Liquid Mass Transfer Comparison of Criteria Mass Transport Heat Transport Effect of Transport Limitations on Observed Behavior Diagnostic Experimental Tests Extraparticle Concentration Gradients Intraparticle Concentration Gradients Temperature Gradients Proper Catalyst Testing and Kinetic Studies Current Trends in Catalyst Testing Parallelization/High-Throughput Experimentation Miniaturization Keywords: catalytic reactors; testing; solid catalysts; reactor systems

[1]  Jacob A. Moulijn,et al.  Gas−Liquid Mass Transfer in Benchscale Stirred TanksFluid Properties and Critical Impeller Speed for Gas Induction , 2006 .

[2]  J. C. Schouten,et al.  The influence of differences between microchannels on microreactor performance , 2005 .

[3]  C. Snively,et al.  High-throughput heterogeneous catalytic science. , 2005, Chemistry.

[4]  P. Mills,et al.  A novel reactor for high-throughput screening of gas¿solid catalyzed reactions , 2004 .

[5]  M. D. Croon,et al.  Design of a molybdenum high throughput microreactor for high temperature screening of catalytic coatings , 2004 .

[6]  C. Mirodatos,et al.  Selective CO oxidation in the presence of hydrogen: fast parallel screening and mechanistic studies on ceria-based catalysts , 2004 .

[7]  J. Moulijn,et al.  Mass transfer and kinetics of the three-phase hydrogenation of a dinitrile over a Raney-type nickel catalyst , 2004 .

[8]  J. C. Schouten,et al.  A Mechanistic Study of the Fischer–Tropsch Synthesis Using Transient Isotopic Tracing. Part-1: Model Identification and Discrimination , 2003 .

[9]  P. Claus,et al.  High throughput screening in monolith reactors for total oxidation reactions , 2003 .

[10]  F. Kapteijn,et al.  Three-phase hydrogenation of d-glucose over a carbon supported ruthenium catalyst—mass transfer and kinetics , 2003 .

[11]  J. Schouten,et al.  A kinetic study of ammonia oxidation on a Pt catalyst in the explosive region in a microstructured reactor/heat-exchanger , 2003 .

[12]  Application of Multichannel Microreactors for Studying Heterogeneous Catalysed Gas Phase Reactions , 2003 .

[13]  Freek Kapteijn,et al.  High-throughput experimentation in catalyst testing and in kinetic studies for heterogeneous catalysis , 2003 .

[14]  M. D. Croon,et al.  Miniaturization of heterogeneous catalytic reactors : prospects for new developments in catalysis and process engineering , 2002 .

[15]  K. Sotowa,et al.  Fabrication of Parallel Microchannel Reactors for Use in Catalyst Testing , 2002 .

[16]  Klavs F. Jensen,et al.  Microfabricated Differential Reactor for Heterogeneous Gas Phase Catalyst Testing , 2002 .

[17]  F. Kapteijn,et al.  Catalyst performance testing: Radial and axial dispersion related to dilution in fixed-bed laboratory reactors , 2002 .

[18]  Klavs F. Jensen,et al.  Microfabricated cross-flow chemical reactor for catalyst testing , 2002 .

[19]  Klaus Huthmacher,et al.  Catalytic Wall Reactor as a Tool for Isothermal Investigations in the Heterogeneously Catalyzed Oxidation of Propene to Acrolein , 2002 .

[20]  P. Claus,et al.  Miniaturization of screening devices for the combinatorial development of heterogeneous catalysts , 2001 .

[21]  Guy Marin,et al.  Eurokin. Chemical Reaction Kinetics in Practice , 2001 .

[22]  K. Jensen.  Microreaction engineering * is small better? , 2001 .

[23]  M. Baerns,et al.  Parallel synthesis and fast screening of heterogeneous catalysts , 2000 .

[24]  Freek Kapteijn,et al.  The six-flow reactor technology: A review on fast catalyst screening and kinetic studies , 2000 .

[25]  J. Moulijn,et al.  Fluid catalytic cracking (FCC): activity in the (milli)seconds range in an entrained flow reactor , 1999 .

[26]  Klavs F. Jensen,et al.  Microchemical systems: Status, challenges, and opportunities , 1999 .

[27]  J. Joshi,et al.  Hydrodynamics of a Stirred Vessel Equipped with a Gas-Inducing Impeller , 1997 .

[28]  F. Kapteijn,et al.  Carbon Monoxide Oxidation over Platinum Powder: A Comparison of TAP and Step-Response Experiments , 1997 .

[29]  A. Stankiewicz,et al.  Preparation, characterization and testing of nickel on alumina monolithic catalysts , 1997 .

[30]  S. T. Sie.  Miniaturization of hydroprocessing catalyst testing systems: Theory and practice , 1996 .

[31]  M. P. Helmsing,et al.  Short contact time experiments in a novel benchscale FCC riser reactor , 1996 .

[32]  F. Kapteijn,et al.  Analysis of mass and heat transfer in transient experiments over heterogeneous catalysts , 1995 .

[33]  Guy Marin,et al.  The oxidative coupling of methane over MgO-based catalysts : a steady-state isotope transient kinetic analysis , 1995 .

[34]  F. Kapteijn,et al.  Kinetics of the alkali-carbonate catalysed gasification of carbon: 3. H2O gasification , 1994 .

[35]  Jacob A. Moulijn,et al.  Monoliths in Heterogeneous Catalysis , 1994 .

[36]  K. Westerterp,et al.  A novel reactor for determination of kinetics for solid catalyzed gas reactions , 1994 .

[37]  W.P.M. van Swaaij,et al.  Mass transfer in gas-liquid slurry reactors , 1993 .

[38]  K. Westerterp,et al.  A heterogeneous model for heat transfer in packed beds , 1993 .

[39]  F. Kapteijn,et al.  Kinetics of the selective catalytic reduction of nitrogen oxide (NO) with ammonia over manganese oxide (Mn2O3)-tungsten oxide (WO3)/.gamma.-alumina , 1993 .

[40]  P. Verheijen,et al.  The Analysis of Non-Isothermal Data on the Oxidation of Carbon Monoxide in a Monolithic Reactor , 1993 .

[41]  R. Krishna.  A unified approach to the modelling of intraparticle diffusion in adsorption processes , 1993 .

[42]  J. Jenck,et al.  Raney-nickel catalyzed hydrogenations: Gas-liquid mass transfer in gas-induced stirred slurry reactors , 1992 .

[43]  A. Baiker,et al.  Criteria for gradientless operation of internal recycle reactors , 1992 .

[44]  W. Paterson,et al.  Accuracy of model predictions and reliability of experimental data for heat transfer in packed beds , 1992 .

[45]  J. Moulijn,et al.  General Aspects of Catalyst Testing , 1991 .

[46]  S. T. Sie.  Scale Effects in Laboratory and Pilot-Plant Reactors for Trickle-Flow Processes , 1991 .

[47]  C. Mirodatos.  Use of isotopic transient kinetics in heterogeneous catalysis , 1991 .

[48]  Octave Levenspiel,et al.  A general equation for the heat-transfer coefficient at wall surfaces of gas/solid contactors , 1991 .

[49]  J. Moulijn,et al.  Design and testing of a stirrer for microautoclaves, the swinging capillary , 1990 .

[50]  M. Abashar,et al.  The implication of non-monotonic kinetics on the design of catalytic reactors , 1990 .

[51]  H. Lasa,et al.  Catalytic cracking kinetics in a novel riser simulator , 1990 .

[52]  F. Dautzenberg.  Ten Guidelines for Catalyst Testing , 1989 .

[53]  S. T. Sie,et al.  Diffusion limitations in fischer‐tropsch catalysts , 1989 .

[54]  Ka Ming Ng,et al.  Flow in packed tubes with a small tube to particle diameter ratio , 1989 .

[55]  L. J. Christiansen,et al.  Activity of steam reforming catalysts: Role and assessment , 1988 .

[56]  H. Gierman.  Design of laboratory hydrotreating reactors: Scaling Down of Trickle-flow Reactors , 1988 .

[57]  J. Carberry.  Physico-Chemical Aspects of Mass and Heat Transfer in Heterogeneous Catalysis , 1987 .

[58]  The design and construction of a multichannel microreactor for catalyst evaluation , 1986 .

[59]  J. Berty.  20 Years of recycle reactors in reaction engineering , 1984 .

[60]  F. Kapteijn,et al.  Thermodynamics of the geometrical isomerization of 2-butene and 2-pentene , 1983 .

[61]  J. Villadsen,et al.  Falsification of kinetic parameters by incorrect treatment of recirculation reactor data , 1983 .

[62]  R. Broucek.  Falsification of kinetic parameters by incorrect treatment of recirculation reactor data , 1983 .

[63]  M. Boudart,et al.  Experimental criterion for the absence of artifacts in the measurement of rates of heterogeneous catalytic reactions , 1982 .

[64]  J. Moulijn,et al.  Structure/metathesis-activity relations of silica supported molybdenum and tungsten oxide , 1980 .

[65]  D. Trimm,et al.  The kinetics of gasification of carbon deposited on nickel catalysts , 1979 .

[66]  A. Cybulski,et al.  Gas-particle heat transfer coefficients in packed beds at low Reynolds numbers , 1975 .

[67]  P. Schneider.  Intraparticle Diffusion in Multicomponent Catalytic Reactions , 1975 .

[68]  Vern W. Weekman,et al.  Laboratory reactors and their limitations , 1974 .

[69]  D. G. Tajbl,et al.  LABORATORY CATALYTIC REACTORS , 1974 .

[70]  D. Mears,et al.  The role of axial dispersion in trickle-flow laboratory reactors , 1971 .

[71]  D. Mears,et al.  Diagnostic criteria for heat transport limitations in fixed bed reactors , 1971 .

[72]  E. Nowak,et al.  A diagnostic test of the kinetic regime in a packed bed reactor , 1967 .