In-situ observation of inhomogeneous degradation in large format Li-ion cells by neutron diffraction

This work presents a non-destructive in-situ method for probing degradation mechanisms in large format, operating, commercial lithium-ion batteries by neutron diffraction. A fresh battery (15 Ah capacity) was shown to have a uniform (homogeneous) local state of charge (SOC) at 4.0 V (9 Ah SOC) and 4.2 V (15 Ah SOC), with 1.33 C and 2.67 C charging rates, respectively. This battery was then aggressively cycled until it retained only a 9 Ah capacity, 60% of its original value. Inhomogeneous deterioration in the battery was observed: near the edges, both the graphite anode and the spinel-based cathode showed a significant loss of capacity, while near the central area, both electrodes functioned properly. An SOC mapping measurement of the degraded battery in the fully charged state (4.2 V) indicated that the loss of local capacity of the anode and cathode is coupled.

[1]  John Newman,et al.  Cyclable Lithium and Capacity Loss in Li-Ion Cells , 2005 .

[2]  Wei Zhang,et al.  Visualizing the chemistry and structure dynamics in lithium-ion batteries by in-situ neutron diffraction , 2012, Scientific Reports.

[3]  Jeffrey Thomas Remillard,et al.  Local State‐of‐Charge Mapping of Lithium‐Ion Battery Electrodes , 2011 .

[4]  Ralph E. White,et al.  Capacity Fade Mechanisms and Side Reactions in Lithium‐Ion Batteries , 1998 .

[5]  J. C. Hunter.  Preparation of a new crystal form of manganese dioxide: λ-MnO2 , 1981 .

[6]  Robert Kostecki,et al.  In situ raman microscopy of individual LiNi0.8Co0.15Al0.05O2 particles in a Li-ion battery composite cathode. , 2005, The journal of physical chemistry. B.

[7]  Yuji Kojima,et al.  Degradation analysis of a Ni-based layered positive-electrode active material cycled at elevated tem , 2011 .

[8]  M. Wohlfahrt‐Mehrens,et al.  Ageing mechanisms in lithium-ion batteries , 2005 .

[9]  Yunhong Zhou,et al.  Capacity Fading on Cycling of 4 V Li / LiMn2 O 4 Cells , 1997 .

[10]  H. Berg,et al.  The LiMn2O4 to λ-MnO2 phase transition studied by in situ neutron diffraction , 2001 .

[11]  K. An,et al.  First Results from the VULCAN Diffractometer at the SNS , 2010 .

[12]  C. Delmas,et al.  Reinvestigation of Li2MnO3 Structure: Electron Diffraction and High Resolution TEM , 2009 .

[13]  J. Goodenough.  Challenges for Rechargeable Li Batteries , 2010 .

[14]  Nigel P. Brandon,et al.  Local Tortuosity Inhomogeneities in a Lithium Battery Composite Electrode , 2011 .

[15]  Brian H. Toby,et al.  EXPGUI, a graphical user interface for GSAS , 2001 .

[16]  Seung M. Oh,et al.  Degradation mechanisms in doped spinels of LiM0.05Mn1.95O4 (M=Li, B, Al, Co, and Ni) for Li secondary batteries , 2000 .

[17]  Robert Kostecki,et al.  Reprint of “Studies of local degradation phenomena in composite cathodes for lithium-ion batteries”☆ , 2007 .

[18]  Alexandru Dan Stoica,et al.  First In Situ Lattice Strains Measurements Under Load at VULCAN , 2011 .

[19]  Ralph E. White,et al.  Studies on Capacity Fade of Spinel-Based Li-Ion Batteries , 2002 .

[20]  Masaki Yoshio,et al.  An Investigation of Lithium Ion Insertion into Spinel Structure Li‐Mn‐O Compounds , 1996 .

[21]  U. Kim,et al.  Effect of electrode configuration on the thermal behavior of a lithium-polymer battery , 2008 .

[22]  L. S. Kanevskii,et al.  Degradation of lithium-ion batteries and how to fight it: A review , 2005 .

[23]  Thilo Pirling,et al.  “In-operando” neutron scattering studies on Li-ion batteries , 2012 .

[24]  P. Strobel,et al.  Crystallographic and magnetic structure of Li2MnO3 , 1988 .