Thermoelectric energy harvesting from diurnal heat flow in the upper soil layer

Abstract We built and tested a subterranean thermoelectric power source that converts diurnal heat flow through the upper soil layer into electricity. This paper describes the operation, design, and performance of the device. Key features of the power source include the use of bismuth-telluride thermopiles optimized for small Δ T and aerogel insulation to minimize thermal losses. The device weighs 0.24 kg and was designed with a flat form factor measuring 12 × 12 × 1.7 cm to facilitate modularity, packing, and assembly into larger arrays. One full year of field testing was performed between June 2009 and May 2010 in Albuquerque, New Mexico where the device generated an average power output of 1.1 mW. The season with the highest performance was spring (March–May) while the season of lowest performance was winter (November–January). During May 2010, the device generated an average power of 1.5 mW and a peak power of 9.8 mW at 9.3 V. Ten years of continuous operation at 1.1 mW would yield an energy density and specific energy of 1384 W h/L and 1430 W h/kg respectively, which is competitive with chemical batteries and is orders of magnitude greater than published subterranean and ambient thermoelectric harvesters. Numerical simulations show that performance is sensitive to the thermal properties of the soil and environmental conditions. This class of energy harvester may provide an option for supplemental power, or possibly primary power, for low power remote sensing applications.

[1]  Barry Jones.  A roadmap to truly disposable unattended ground sensor (UGS) systems , 2010, Defense + Commercial Sensing.

[2]  Paul E. Sims.  Solar battery recharge options for unattended ground sensors , 2001, SPIE Defense + Commercial Sensing.

[3]  James W. Stevens.  Optimized Thermal Design of Small ΔT Thermoelectric Generators , 1999 .

[4]  Zhiqiu Gao,et al.  Determination of soil temperature in an arid region , 2007 .

[5]  D. Rowe.  CRC Handbook of Thermoelectrics , 1995 .

[6]  Nelson A. Kelly,et al.  Solar photovoltaic charging of lithium-ion batteries , 2010 .

[7]  S. Bhowmick,et al.  Harvesting energy from asphalt pavements and reducing the heat island effect , 2009 .

[8]  James W. Stevens,et al.  Assessment of near-surface ground temperature profiles for optimal placement of a thermoelectric device , 2009 .

[9]  D. Linden.  Handbook Of Batteries , 2001 .

[10]  Sam Behrens,et al.  Thermal energy harvesting between the air/water interface for powering wireless sensor nodes , 2009, Smart Structures and Materials + Nondestructive Evaluation and Health Monitoring.

[11]  A. Gemant.  The Thermal Conductivity of Soils , 1950 .

[12]  Daniel J. Inman,et al.  Recharging Batteries using Energy Harvested from Thermal Gradients , 2007 .

[13]  James W. Stevens,et al.  Optimal design of small ΔT thermoelectric generation systems , 2001 .

[14]  J. Henderson,et al.  Analysis of a heat exchanger-thermoelectric generator system , 1979 .

[15]  Khalid M. Saqr,et al.  Thermal design of automobile exhaust based thermoelectric generators: Objectives and challenges , 2008 .

[16]  Ralph D. Lorenz,et al.  Subsurface ambient thermoelectric power for moles and penetrators , 2003, 2003 IEEE Aerospace Conference Proceedings (Cat. No.03TH8652).

[17]  David E. Newcomb,et al.  Consideration of Hot Mix Asphalt Thermal Properties During Compaction , 1996 .

[18]  Nelson A. Kelly,et al.  Solar photovoltaic charging of high voltage nickel metal hydride batteries using DC power conversion , 2011 .

[19]  Jincan Chen.  Thermodynamic analysis of a solar‐driven thermoelectric generator , 1996 .

[20]  Frank P. Incropera,et al.  Fundamentals of Heat and Mass Transfer , 1981 .

[21]  Josh Davidson,et al.  Thermal Energy Harvesting for Wireless Sensor Nodes with Case Studies , 2010 .

[22]  L. I. Anatychuk,et al.  Thermal generators using heat flows in soils , 2003, Proceedings ICT'03. 22nd International Conference on Thermoelectrics (IEEE Cat. No.03TH8726).

[23]  G. J. Snyder,et al.  A study of heat sink performance in air and soil for use in a thermoelectric energy harvesting device , 2002, Twenty-First International Conference on Thermoelectrics, 2002. Proceedings ICT '02..

[24]  Xiuji Zhou,et al.  Variation of surface albedo and soil thermal parameters with soil moisture content at a semi-desert site on the western Tibetan Plateau , 2005 .