Warm Plasma Application in Tar Conversion and Syngas Valorization: The Fate of Hydrogen Sulfide

Warm plasma techniques are considered a promising method of tar removal in biomass-derived syngas. The fate of another problematic syngas impurity—hydrogen sulfide—is studied in this work. It is revealed that processing simulated syngas with a microwave plasma results in hydrogen sulfide conversion. For different gas flow rates (20–40 NLPM) and hydrogen sulfide concentrations ranging from 250 ppm to 750 ppm, the conversion rate varies from ca. 26% to 45%. The main sulfur-containing products are carbon disulfide (ca. 30% of total sulfur) and carbonyl sulfide (ca. 8% of total sulfur). Besides them, significantly smaller quantities of sulfates and benzothiophene are also detected. The main components of syngas have a tremendous impact on the fate of hydrogen sulfide. While the presence of carbon monoxide, methane, carbon dioxide, and tar surrogate (toluene) leads to the formation of carbonyl sulfide, carbon disulfide, sulfur dioxide, and benzothiophene, respectively, the abundance of hydrogen results in the recreation of hydrogen sulfide. Consequently, the presence of hydrogen in the simulated syngas is the main factor that determines the low conversion rate of hydrogen sulfide. Conversion of hydrogen sulfide into various sulfur compounds might be problematic in the context of syngas purification and the application of the right technique for sulfur removal.

[1]  X. Tu,et al.  Highly efficient reforming of toluene to syngas in a gliding arc plasma reactor , 2021 .

[2]  M. Wnukowski,et al.  The role of hydrogen in microwave plasma valorization of producer gas , 2021 .

[3]  F. Zimbardi,et al.  Effects of Oxygen and Steam Equivalence Ratios on Updraft Gasification of Biomass , 2021 .

[4]  Kui Zhang,et al.  A comparison of the decomposition of biomass gasification tar compound in CO, CO2, H2 and N2 carrier gases using non-thermal plasma , 2021 .

[5]  M. Zappi,et al.  Catalytic Hot Gas Cleanup of Biomass Gasification Producer Gas via Steam Reforming Using Nickel-Supported Clay Minerals , 2021, Energies.

[6]  Kui Zhang,et al.  Removal of benzene as a tar model compound from a gas mixture using non-thermal plasma dielectric barrier discharge reactor , 2021 .

[7]  Ruiyang Xu,et al.  Plasma Conversion of Toluene, Naphthalene, and Phenol as Model Tar Compounds in Simulated Synthetic Gas , 2021 .

[8]  Riyi Lin,et al.  Hydrodesulfurization of benzothiophene on Ni2P surface , 2020 .

[9]  H. Thielert,et al.  Investigation on the simultaneous removal of COS, CS2 and O2 from coke oven gas by hydrogenation on a Pd/Al2O3 catalyst , 2020 .

[10]  L. Helsen,et al.  Thermal tar cracking enhanced by cold plasma – A study of naphthalene as tar surrogate , 2020 .

[11]  Kui Zhang,et al.  Non-thermal plasma as a promising route for the removal of tar from the product gas of biomass gasification – A critical review , 2020 .

[12]  M. Dors,et al.  Tar Removal by Nanosecond Pulsed Dielectric Barrier Discharge , 2020 .

[13]  Ruiyang Xu,et al.  Simultaneous Removal of Toluene, Naphthalene, and Phenol as Tar Surrogates in a Rotating Gliding Arc Discharge Reactor , 2020 .

[14]  F. Zhu,et al.  Plasma reforming of tar model compound in a rotating gliding arc reactor: Understanding the effects of CO2 and H2O addition , 2020 .

[15]  S. Turn,et al.  Reforming of biogas using a non-thermal, gliding-arc, plasma in reverse vortex flow and fate of hydrogen sulfide contaminants , 2019, Fuel Processing Technology.

[16]  W. Kordylewski,et al.  Sewage Sludge-Derived Producer Gas Valorization with the Use of Atmospheric Microwave Plasma , 2019, Waste and Biomass Valorization.

[17]  L. Helsen,et al.  The role of plasma in syngas tar cracking , 2019, Biomass Conversion and Biorefinery.

[18]  M. Wnukowski,et al.  Microwave plasma treatment of simulated biomass syngas: interactions between the permanent syngas compounds and their influence on the model tar compound conversion. , 2018 .

[19]  Dino Musmarra,et al.  Biofuels Production by Biomass Gasification: A Review , 2018 .

[20]  W. Kordylewski,et al.  Microwave plasma application in decomposition and steam reforming of model tar compounds , 2018 .

[21]  Xiqiang Zhao,et al.  Reduction of SO2 to elemental sulfur with H2 and mixed H2/CO gas in an activated carbon bed , 2017 .

[22]  T. Nunoura,et al.  Fate of sulphur during simultaneous gasification of lignin-slurry and removal of hydrogen sulphide over calcium aluminate supported nickel oxide catalyst , 2017 .

[23]  Francisco,et al.  Mechanism of sulfur poisoning by H2S and SO2 of nickel and cobalt based catalysts for dry reforming of methane. , 2016 .

[24]  M. Graswinckel,et al.  Taming microwave plasma to beat thermodynamics in CO2 dissociation. , 2015, Faraday discussions.

[25]  L. Mazzei,et al.  Reforming of tars and organic sulphur compounds in a plasma-assisted process for waste gasification , 2015 .

[26]  S. Pang,et al.  Co-gasification of blended lignite and wood pellets in a dual fluidized bed steam gasifier: The influence of lignite to fuel ratio on NH3 and H2S concentrations in the producer gas , 2015 .

[27]  Paola Lettieri,et al.  Tar evolution in a two stage fluid bed-plasma gasification process for waste valorization , 2014 .

[28]  P. V. Aravind,et al.  The fate of tars under solid oxide fuel cell conditions: A review , 2014 .

[29]  Thomas Nunnally,et al.  Gliding arc plasma oxidative steam reforming of a simulated syngas containing naphthalene and toluene , 2014 .

[30]  T. Schildhauer,et al.  Sulfur containing organic compounds in the raw producer gas of wood and grass gasification , 2014 .

[31]  Paul Chen,et al.  Fast microwave-assisted catalytic gasification of biomass for syngas production and tar removal. , 2014, Bioresource technology.

[32]  Maoqian Miao,et al.  Desulfurization behavior of zinc oxide based sorbent modified by the combination of Al2O3 and K2CO3 , 2013 .

[33]  H. Maciel,et al.  Tar Reforming under a Microwave Plasma Torch , 2013 .

[34]  Nunzio Russo,et al.  MSW landfill biogas desulfurization , 2011 .

[35]  Jianglong Yu,et al.  Correlation of H2S and COS in the hot coal gas stream and its importance for high temperature desulfurization , 2011 .

[36]  Xiangmei Meng,et al.  In bed and downstream hot gas desulphurization during solid fuel gasification: A review , 2010 .

[37]  Riguang Zhang,et al.  Theoretical studies on reaction mechanism of H2 with COS , 2010, Journal of molecular modeling.

[38]  D. Carpenter,et al.  Review of Mid- to High-Temperature Sulfur Sorbents for Desulfurization of Biomass- and Coal-derived Syngas , 2009 .

[39]  L. Behie,et al.  CS2 Formation in the Claus Reaction Furnace: A Kinetic Study of Methane−Sulfur and Methane−Hydrogen Sulfide Reactions , 2004 .

[40]  H. Uil,et al.  Gas Cleaning for Integrated Biomass Gasification ( BG ) and Fischer-Tropsch ( FT ) Systems Experimental demonstration of two BG-FT systems ( “ Proof-of-Principle ” ) , 2004 .

[41]  A. Drinkenburg,et al.  Pulsed Corona Discharges for Tar Removal from Biomass Derived Fuel Gas , 2003 .

[42]  J. V. Doorn,et al.  Ten residual biomass fuels for circulating fluidized-bed gasification , 2001 .

[43]  Colin Rhodes,et al.  The low-temperature hydrolysis of carbonyl sulfide and carbon disulfide: a review , 2000 .

[44]  C. H. Bartholomew,et al.  Sulfur Poisoning of Metals , 1982 .

[45]  P. Farago.  Success Stories , 1971, Nature.