Technical demonstration of the novel Fraunhofer ISE biomass gasification process for the production of a tar-free synthesis gas

Abstract A novel fixed-bed biomass gasification process ( Fraunhofer ISE gasification process) for the production of tar-free synthesis gas was developed and demonstrated in a small-scale 50 kW LHV ( biomass ) pilot plant. The process consists of four zones. Separated by moving grates to control the residence time in every zone. Thermal cracking of all higher hydrocarbons and tars occurs due to temperatures in the cracking zone of up to 1000 °C, ensured via partial combustion of the raw gas. In addition, coke in the cracking zones acts catalytically. In order to increase the heating value of the product gas all remaining carbon is partially oxidized and the produced CO/CO 2 is blended with the product gas. To demonstrate feasibility of the process, a pilot plant was designed, commissioned and tested. The gasifier produced a combustible gas with a lower heating value of 5.8 MJ/Nm 3 and CO, H 2 and CH 4 concentrations of 24, 14 and 2 vol.%, respectively. Tar contents below 50 mg/Nm 3 were achieved in continuous operation. The results suggested a considerable effect of the temperature and the bed height in the tar cracking zone on the reduction of the tar content in the produced gas.

[1]  William A. Peters,et al.  Heterogeneous cracking of wood pyrolysis tars over fresh wood char surfaces , 1989 .

[2]  Samsudin Anis,et al.  Tar reduction in biomass producer gas via mechanical, catalytic and thermal methods: A review , 2011 .

[3]  J. Fjellerup,et al.  Formation, Decomposition and Cracking of Biomass Tars in Gasification , 2005 .

[4]  Danielle Bellmer,et al.  Biomass downdraft gasifier with internal cyclonic combustion chamber: design, construction, and experimental results. , 2011, Bioresource technology.

[5]  J. Ran,et al.  High temperature gasification of woody biomass using regenerative gasifier , 2012 .

[6]  Laurent Van de Steene,et al.  Pyrolysis of Pinus pinaster in a two-stage gasifier: Influence of processing parameters and thermal cracking of tar , 2009 .

[7]  K Maniatis,et al.  Tar Protocols. IEA Bioenergy Gasification Task , 2000 .

[8]  Avdhesh Kr. Sharma,et al.  Experimental study on 75 kWth downdraft (biomass) gasifier system , 2009 .

[9]  Krister Sjöström,et al.  Catalytic tar decomposition of biomass pyrolysis gas with a combination of dolomite and silica , 2002 .

[10]  J Swithenbank,et al.  Tar reduction in pyrolysis vapours from biomass over a hot char bed. , 2009, Bioresource technology.

[11]  Heejoon Kim,et al.  The reduction and control technology of tar during biomass gasification/pyrolysis: An overview , 2008 .

[12]  F. Mermoud,et al.  A new experimental Continuous Fixed Bed Reactor to characterise wood char gasification , 2010 .

[13]  Chunshan Li,et al.  Tar property, analysis, reforming mechanism and model for biomass gasification—An overview , 2009 .

[14]  I. Antonopoulos,et al.  Development of an innovative 3-stage steady-bed gasifier for municipal solid waste and biomass , 2011 .

[15]  J. Vacek,et al.  Biomass waste gasification - can be the two stage process suitable for tar reduction and power generation? , 2012, Waste management.

[16]  Kitipong Jaojaruek,et al.  Experimental study of wood downdraft gasification for an improved producer gas quality through an innovative two-stage air and premixed air/gas supply approach. , 2011, Bioresource technology.

[17]  A. Bridgwater.  The technical and economic feasibility of biomass gasification for power generation , 1995 .

[18]  J. T. Riley,et al.  A novel biomass air gasification process for producing tar-free higher heating value fuel gas , 2006 .

[19]  Electo Eduardo Silva Lora,et al.  Experimental study on biomass gasification in a double air stage downdraft reactor , 2011 .

[20]  Gerrit Brem,et al.  Experimental comparison of biomass chars with other catalysts for tar reduction , 2008 .

[21]  Andrew A. Suby,et al.  Catalytic destruction of tar in biomass derived producer gas , 2004 .

[22]  T. Fransson,et al.  Downdraft gasification of pellets made of wood, palm-oil residues respective bagasse: Experimental study , 2011 .

[23]  Jesper Ahrenfeldt,et al.  The design, construction and operation of a 75kW two-stage gasifier , 2006 .