An Inventory and Engineering Assessment of Flared Gas and Liquid Waste Streams From Hydraulic Fracturing in the USA

Purpose of ReviewIn this study, we compile and curate data from 2012, 2013, and 2014 on flared gas and generated wastewater associated with hydraulic fracturing operations in seven major shale regions of the USA. In the process, we provide an historical perspective of the management practices of flared gas and wastewater prior to the decline in oil prices in 2015. An engineering assessment of the technical potential for repurposing the energy from flared gas for treating hydraulic fracturing wastewater is also considered.Recent FindingsThe seven shale regions were evaluated using mass balances and thermodynamic analysis of the wastewater and flared gas volumes using data compiled from state, federal, and private sources for each region. After curating the publicly available data, we determined that from 2012 through 2014, the Bakken, Marcellus, Utica, and Niobrara flared between 2 and 48 times the amount of natural gas needed to provide energy for treatment of the wastewater produced from the oil and gas industry. The Permian Basin, Eagle Ford, and Haynesville did not have sufficient flared gas to treat the wastewater produced in each respective region and thus would need other energy sources for water and wastewater treatment.SummaryThe findings indicate that novel approaches to managing existing resources and waste streams might have the potential to improve the environmental footprint and economic productivity of select oil and gas sites.

[1]  Kimberly E Carter,et al.  Water usage for natural gas production through hydraulic fracturing in the United States from 2008 to 2014. , 2016, Journal of environmental management.

[2]  Susan J Riha,et al.  Wastewater management and Marcellus Shale gas development: trends, drivers, and planning implications. , 2012, Journal of environmental management.

[3]  Michael E. Webber,et al.  The Energy-Water Nexus: An Analysis and Comparison of Various Configurations Integrating Desalination with Renewable Power , 2015 .

[4]  Yael Rebecca Glazer.  The potential for using energy from flared gas or renewable resources for on-site hydraulic fracturing wastewater treatment , 2014 .

[5]  Michael E. Webber,et al.  Potential for Using Energy from Flared Gas for On-Site Hydraulic Fracturing Wastewater Treatment in Texas , 2014 .

[6]  Bryan D. Coday,et al.  Forward osmosis desalination of oil and gas wastewater: Impacts of membrane selection and operating conditions on process performance , 2015 .

[7]  M. Webber,et al.  Implementation of Brackish Groundwater Desalination Using Wind-Generated Electricity: A Case Study of the Energy-Water Nexus in Texas , 2014 .

[8]  R. Jackson,et al.  A critical review of the risks to water resources from unconventional shale gas development and hydraulic fracturing in the United States. , 2014, Environmental science & technology.

[9]  R. Reedy,et al.  Comparison of water use for hydraulic fracturing for unconventional oil and gas versus conventional oil. , 2014, Environmental science & technology.

[10]  Michael E. Webber,et al.  The Energy-Water Nexus: Spatially-Resolved Analysis of the Potential for Desalinating Brackish Groundwater by Use of Solar Energy , 2015 .

[11]  B. Scanlon,et al.  Water use for Shale-gas production in Texas, U.S. , 2012, Environmental science & technology.

[12]  P. Horner,et al.  Shale Gas Water Treatment Value Chain - A Review of Technologies, including Case Studies , 2011 .

[13]  Richard Broderick,et al.  Key Shale Gas Water Management Strategies: An Economic Assessment , 2012 .

[14]  Hong Sun,et al.  Water-Based Environmentally Preferred Friction Reducer in Ultrahigh-TDS Produced Water for Slickwater Fracturing in Shale Reservoirs , 2014 .