Upflow biological aerated filters for the treatment of flushed swine manure

Abstract A pilot plant with capacity to treat up to 8 m 3 /day of supernate from settled flushed swine wastes was monitored for 12 months. The main system is composed of two upflow aerated biofilters connected in series. The aerated biofilters, operated under warm weather conditions (average temperature of 27°C), were able to remove about 88% of biochemical oxygen demand (BOD), 75% of chemical oxygen demand (COD), and 82% of total suspended solids (SS) with loading of 5.7 kg COD/m 3 /day of biofilter media. The total Kjeldahl nitrogen (TKN), total ammonia nitrogen (NH 3 -N), and total nitrogen (Total-N) reductions averaged 84%, 94% and 61%, respectively, during warm weather, with a significant portion of the NH 3 -N being converted to nitrite plus nitrate nitrogen (NO 2 +NO 3 -N). At higher organic loading (over 9 kg COD/m 3 /day) during September, the biofilters had only slightly lower percentage removal rates. Operation at lower temperatures (average of 10°C) resulted in lower performances. The COD, TKN, NH 3 -N, and Total-N removal averaged 56%, 49%, 52%, and 29%, respectively, in December through March. The COD mass removal rate was linear with loading rate over the range of approximately 2–12 kg COD/m 3 /day of filter. A mass balance average for the 12 months indicated that about 30% of the influent volume, 35% of Total-N and 60% of total phosphorus (Total-P) are removed with the biofilter backwash. Management and utilization of the backwash are important factors in implementing this type of system on farms. The unaccounted-for nitrogen was about 24% and could have been lost as ammonia volatilization or possibly through denitrification within the biofilm.

[1]  M. R. Evans,et al.  The effects of low dissolved oxygen tension during the aerobic treatment of piggery slurry in completely mixed reactors. , 1982, The Journal of applied bacteriology.

[2]  F. Rogalla,et al.  Biological phosphorus uptake in submerged biofilters with nitrogen removal , 1994 .

[4]  J. Germon,et al.  Nitrification and denitrification of liquid lagoon piggery waste in a biofilm infiltration-percolation aerated system (BIPAS) reactor , 1996 .

[5]  Philip W. Westerman,et al.  Aeration of livestock manure slurry and lagoon liquid for odor control: a review , 1997 .

[6]  Aerated lagoon treatment of piggery wastes: Kinetics of carbon removal , 1986 .

[7]  Paul L. Bishop,et al.  Competition for substrate and space in biofilms , 1995 .

[8]  G. Bortone,et al.  Nitrification, Denitrification and Biological Phosphate Removal in Sequencing Batch Reactors Treating Piggery Wastewater , 1992 .

[9]  J J Heijnen,et al.  Control of heterotrophic layer formation on nitrifying biofilms in a biofilm airlift suspension reactor. , 1997, Biotechnology and bioengineering.

[10]  C. Liao,et al.  Nitrification/denitrification in an intermittent aeration process for swine wastewater , 1994 .

[11]  M. V. van Loosdrecht,et al.  Formation and growth of heterotrophic aerobic biofilms on small suspended particles in airlift reactors , 1994, Biotechnology and bioengineering.

[12]  M. R. Evans,et al.  Nitrogen and aerobic treatment of slurry , 1986 .

[13]  I. Svoboda,et al.  Intermittent aeration of pig slurry – farm scale experiments for carbon and nitrogen removal , 1995 .

[14]  H. D. Stensel,et al.  Design and retrofit of wastewater treatment plants for biological nutrient removal , 1992 .

[15]  Takashi Osada,et al.  Removal of nitrogen and phosphorus from swine wastewater by the activated sludge units with the intermittent aeration process , 1991 .

[16]  H. D. Stensel,et al.  Biological Aerated Filter Evaluation , 1988 .

[17]  R. W. Sneath,et al.  Continuous farm scale aeration plant for reducing offensive odours from piggery slurry : control and optimization of the process , 1995 .

[18]  M. R. Evans,et al.  Aerobic treatment of piggery waste , 1973 .

[19]  C. Burton.  A review of the strategies in the aerobic treatment of pig slurry: Purpose, theory and method , 1992 .

[20]  G. Gadd,et al.  Microbial Control of Pollution , 1992 .

[21]  F. Rogalla,et al.  The Treatment Trilogy of Floating Filters: From Pilot to Prototype to Plant , 1994 .

[22]  A. E. Greenberg,et al.  Standard methods for the examination of water and wastewater : supplement to the sixteenth edition , 1988 .

[23]  J. Heijnen,et al.  Nitrogen Removal in Intermittently Aerated Biofilm Airlift Reactor , 1998 .

[24]  Philip W. Westerman,et al.  Nitrification in three-stage and single-stage floating bead biofilters in a laboratory-scale recirculating aquaculture system , 1996 .

[25]  K. Sørensen,et al.  Biofilm reactors configuration for advanced nutrient removal , 1994 .

[26]  J. Jones,et al.  Practical experiences with aerobic biofilters in tmp (thermomechanical pulping), sulfite and fine paper mills in Canada , 1997 .