Arsenic removal from alkaline leaching solution using Fe (III) precipitation

ABSTRACT The alkaline leaching solution from arsenic-containing gold concentrate contains a large amount of arsenate ions, which should be removed because it is harmful to the production process and to the environment. In this study, conventional Fe (III) precipitation was used to remove arsenic from the leaching solution. The precipitation reaction was carried out at the normal temperature, and the effects of pH value and Fe/As ratio on the arsenic removal were investigated. The results show that the removal rate of arsenic is distinctive at different pH values, and the effect is best within the pH range of 5.25–5.96. The removal rate can be further increased by increasing the ratio of Fe/As. When the pH = 5.25–5.96 and Fe/As > 1.8, the arsenic in the solution can be reduced to below 5 mg/L. However, the crystallinity of ferric arsenate is poor, and the particle size is small, most of which is about 1 μm. The leaching toxicity test shows the leaching toxicity of precipitates gradually decreased by the increase of Fe/As. The precipitates can be stored safely as the ratio of Fe/As exceeded 2.5.

[1]  I. González,et al.  Arsenic removal from water by hybrid electro-regenerated anion exchange resin/electrodialysis process , 2017 .

[2]  T. Kaartinen,et al.  Arsenic Removal from Mine Waters with Sorption Techniques , 2017, Mine Water and the Environment.

[3]  Hua Zhang,et al.  Mechanism research on arsenic removal from arsenopyrite ore during a sintering process , 2017, International Journal of Minerals, Metallurgy, and Materials.

[4]  F. Suja,et al.  Removal of arsenic and iron removal from drinking water using coagulation and biological treatment. , 2016, Journal of water and health.

[5]  G. Demopoulos,et al.  Stability of continuously produced Fe(II)/Fe(III)/As(V) co-precipitates under periodic exposure to reducing agents. , 2015, Chemosphere.

[6]  Lin Liu,et al.  Removal and stabilization of arsenic from anode slime by forming crystal scorodite , 2015 .

[7]  A. Figoli,et al.  Arsenic Removal by Liquid Membranes , 2015, Membranes.

[8]  Xin-yuan Nan,et al.  Pretreatment Process on Refractory Gold Ores with As , 2014 .

[9]  Shigeru Suzuki,et al.  Environmental leaching characteristics of scorodite synthesized with Fe(II) ions , 2012 .

[10]  L. Twidwell,et al.  Removing arsenic from aqueous solution and long-term product storage , 2011 .

[11]  K. Müller,et al.  A comparative study of As(III) and As(V) in aqueous solutions and adsorbed on iron oxy-hydroxides by Raman spectroscopy. , 2010, Water research.

[12]  G. Demopoulos.  Aqueous Precipitation and Crystallization for the Production of Particulate Solids with Desired Properties , 2010 .

[13]  Pía C. Hernández,et al.  Equilibria of Aqueous System Phases Containing Arsenic + Iron and Arsenic + Calcium at (323.15 and 343.15) K , 2009 .

[14]  R. Autenrieth,et al.  Arsenic stabilization on water treatment residuals by calcium addition. , 2009, Journal of hazardous materials.

[15]  G. Demopoulos,et al.  Characterization of Poorly-Crystalline Ferric Arsenate Precipitated from Equimolar Fe(III)-As(V) Solutions in the pH Range 2 to 8 , 2007 .

[16]  G. Demopoulos,et al.  The incongruent dissolution of scorodite — Solubility, kinetics and mechanism , 2007 .

[17]  Binbing Han,et al.  Arsenic removal by coagulation and filtration: comparison of groundwaters from the United States and Bangladesh , 2004 .

[18]  V. Ciminelli,et al.  Adsorption and desorption of arsenic on an oxisol and its constituents. , 2004, Water research.

[19]  Juan D. Gomez,et al.  Arsenic removal from drinking water using the coagulation/microfiltratin process , 2004 .

[20]  A. Zouboulis,et al.  REMOVAL OF ARSENATES FROM CONTAMINATED WATER BY COAGULATION–DIRECT FILTRATION , 2002 .

[21]  Kazuo T. Suzuki,et al.  Arsenic round the world: a review. , 2002, Talanta.

[22]  P. A. Riveros,et al.  Arsenic Disposal Practices in the Metallurgical Industry , 2001 .

[23]  A. J. Monhemius,et al.  Removing and stabilizing as from copper refining circuits by hydrothermal processing , 1999 .

[24]  J. E. Dutrizac,et al.  Occurrence and Constitution of Natural and Synthetic Ferrihydrite, a Widespread Iron Oxyhydroxide , 1999 .

[25]  G. Waychunas,et al.  Experimental and theoretical vibrational spectroscopic evaluation of arsenate coordination in aqueous solutions, solids, and at mineral-water interfaces , 1998 .

[26]  G. Demopoulos,et al.  Precipitation of crystalline scorodite (FeAsO4 · 2H2O) from chloride solutions , 1995 .

[27]  J. Hiskey,et al.  Electrochemical behavior of arsenopyrite in alkaline media , 1991 .

[28]  V. Ettel,et al.  Solubilities and stabilities of ferric arsenate compounds , 1989 .

[29]  V. Ettel,et al.  Solubility and stability of scorodite, FeAsO4•2H2O: new data and further discussion , 1988 .

[30]  J. Jambor,et al.  The synthesis of crystalline scorodite, FeAsO4 · 2H2O , 1988 .