Evaluation of various pre-treatments for the dehydration of banana and selection of suitable drying models

The thin-layer drying behaviour of bananas in a beat pump dehumidifier dryer was examined. Four pre-treatments (blanching, chilling, freezing and combined blanching and freezing) were applied to the bananas, which were dried at 50 degreesC with an air velocity of 3.1 m s(-1) and with the relative humidity of the inlet air of 10-35%. Three drying models, the simple model, the two-term exponential model and the Page model were examined. All models were evaluated using three statistical measures, correlation coefficient, root means square error, and mean absolute percent error. Moisture diffusivity was calculated based on the diffusion equation for an infinite cylindrical shape using the slope method. The rate of drying was higher for the pre-treatments involving freezing. The sample which was blanched only did not show any improvement in drying rate. In fact, a longer drying time resulted due to water absorption during blanching. There was no change in the rate for the chilled sample compared with the control. While all models closely fitted the drying data, the simple model showed greatest deviation from the experimental results. The two-term exponential model was found to be the best model for describing the drying curves of bananas because its parameters represent better the physical characteristics of the drying process. Moisture diffusivities of bananas were in the range 4.3-13.2 x 10(-10) m(2)s(-1). (C) 2002 Published by Elsevier Science Ltd.

[1]  R. V. Morey,et al.  Comparison of four EMC/ERH equations , 1989 .

[2]  M. S. Chhinnan.  Evaluation of Selected Mathematical Models for Describing Thin-Layer Drying of In-Shell Pecans , 1984 .

[3]  G. E. Page,et al.  FACTORS INFLUENCING THE MAXIMUM RATES OF AIR DRYING SHELLED CORN IN THIN LAYERS. , 1949 .

[4]  M. Parti,et al.  A THEORETICAL MODEL FOR THIN-LAYER GRAIN DRYING , 1990 .

[5]  Yahya I. Sharaf-Eldeen,et al.  A Model for Ear Corn Drying , 1980 .

[6]  G. M. White,et al.  Drying Soybeans With Heated Air , 1973 .

[7]  Lalit R. Verma,et al.  Generalized Single-Layer Rice Drying Models , 1986 .

[8]  John Crank,et al.  The Mathematics Of Diffusion , 1956 .

[9]  H. Shepherd,et al.  Thin Layer Drying of Pigeon Pea , 1988 .

[10]  W. Horwitz.  Official Methods of Analysis , 1980 .

[11]  W. Horwitz.  The variability of AOAC methods of analysis as used in analytical pharmaceutical chemistry. , 1977, Journal - Association of Official Analytical Chemists.

[12]  K. H. Colson,et al.  Two-component thin-layer drying model for unshelled peanuts. , 1990 .

[13]  C. Sankat,et al.  The air drying behaviour of fresh and osmotically dehydrated banana slices , 1996 .

[14]  Robert H. Driscoll,et al.  The thin-layer drying characteristics of macadamia in-shell nuts and kernels , 1994 .

[15]  H. D. Tolley,et al.  Rough Rice Drying as a Two-Compartment Model , 1982 .

[16]  P. K. Pathak,et al.  THIN-LAYER DRYING MODEL FOR RAPESEED , 1991 .

[17]  J. G. Brennan.  Food dehydration : a dictionary and guide , 1994 .

[18]  Robert H. Driscoll,et al.  The thin-layer drying characteristics of garlic slices , 1996 .