The crystal facet-dependent gas sensing properties of ZnO nanosheets: Experimental and computational study

Abstract Herein, we focused on the effects of exposed crystal planes on the gas sensing property of ZnO. For this purpose, we designed and synthesized two porous ZnO nanosheets with different exposed crystal facets (0001) and (10 1 ¯ 0) by a facile hydrothermal routes. The characterization results show that both the porous nanosheets have a near specific surface area about 7.5 m2/g, thickness about 100 nm, diameter about 5 μm and pore size of tens of nanometers. However, their dominating exposed crystal facets are (0001) and (10 1 ¯ 0), respectively. When employed them as sensing materials in gas sensors, porous ZnO nanosheets with dominating exposed (0001) facet exhibit a superior sensitivity than the (10 1 ¯ 0) one. The enhanced gas response is attributed to a large amount of oxygen vacancy defects and unsaturated dangling bonds existing in the ZnO nanosheets with exposed crystal facet (0001), which is favorable for the adsorption of gas molecular on the sensor surface and result in improvement of the gas response. Finally, the calculation of the chemisorption energy of oxygen on ZnO crystal facets also proves the reactive-facet-enhanced gas sensitivity.

[1]  Pietro Siciliano,et al.  The Role of Surface Oxygen Vacancies in the NO2 Sensing Properties of SnO2 Nanocrystals , 2008 .

[2]  J. Zemel.  Theoretical description of gas-film interaction on SnOx☆ , 1988 .

[3]  Chongwu Zhou,et al.  2,4,6‐Trinitrotoluene (TNT) Chemical Sensing Based on Aligned Single‐Walled Carbon Nanotubes and ZnO Nanowires , 2010, Advanced materials.

[4]  Changhui Zhao,et al.  Doping effect of In2O3 on structural and ethanol-sensing characteristics of ZnO nanotubes fabricated by electrospinning , 2015 .

[5]  Lei Huo,et al.  Highly enhanced acetone sensing performances of porous and single crystalline ZnO nanosheets: high percentage of exposed (100) facets working together with surface modification with Pd nanoparticles. , 2012, ACS applied materials & interfaces.

[6]  Wei-Min Ren,et al.  Microstructure analysis of a CO2 copolymer from styrene oxide at the diad level. , 2013, Chemistry, an Asian journal.

[7]  Seppo Leppävuori,et al.  Effect of water vapour on the CO response behaviour of tin dioxide sensors in constant temperature and temperature-pulsed modes of operation , 1990 .

[8]  M. Willander,et al.  Identification of oxygen and zinc vacancy optical signals in ZnO , 2006 .

[9]  X. Q. Wei,et al.  Comparative study on structural and optical properties of ZnO thin films prepared by PLD using ZnO powder target and ceramic target , 2009 .

[10]  Matt Probert,et al.  First principles methods using CASTEP , 2005 .

[11]  P. Espitia,et al.  Zinc Oxide Nanoparticles: Synthesis, Antimicrobial Activity and Food Packaging Applications , 2012, Food and Bioprocess Technology.

[12]  Henry Windischmann,et al.  A Model for the Operation of a Thin‐Film SnO x Conductance‐Modulation Carbon Monoxide Sensor , 1979 .

[13]  W. Cheng,et al.  Study on synthesis and blue emission mechanism of ZnO tetrapodlike nanostructures , 2006 .

[14]  Caofeng Pan,et al.  Enhanced emission intensity of vertical aligned flexible ZnO nanowire/p-polymer hybridized LED array by piezo-phototronic effect , 2015 .

[15]  Yuan Zhang,et al.  Studies on alcohol sensing mechanism of ZnO based gas sensors , 2008 .

[16]  Jong Heun Lee,et al.  Highly selective and sensitive xylene sensors using Ni-doped branched ZnO nanowire networks , 2015 .

[17]  J. R. Botha,et al.  Influence of metal organic chemical vapor deposition growth parameters on the luminescent properties of ZnO thin films deposited on glass substrates , 2008 .

[18]  Nan Qin,et al.  A biomimetic nest-like ZnO: Controllable synthesis and enhanced ethanol response , 2014 .

[19]  Hao Wu,et al.  Interlaced nanoflake-assembled flower-like hierarchical ZnO microspheres prepared by bisolvents and their sensing properties to ethanol , 2015 .

[20]  Lih-Juann Chen,et al.  Electron field emission enhancement of vertically aligned ultrananocrystalline diamond-coated ZnO core-shell heterostructured nanorods. , 2014, Small.

[21]  Jian Song,et al.  NiO@ZnO heterostructured nanotubes: coelectrospinning fabrication, characterization, and highly enhanced gas sensing properties. , 2012, Inorganic chemistry.

[22]  Ning Han,et al.  MOF-derived hierarchical hollow ZnO nanocages with enhanced low-concentration VOCs gas-sensing performance , 2016 .

[23]  Tao Xu,et al.  Controlling Morphologies and Tuning the Related Properties of Nano/Microstructured ZnO Crystallites , 2009 .

[24]  Hwai-Fu Tu,et al.  Ultraviolet emission blueshift of ZnO related to Zn , 2007 .

[25]  Cheng Yang,et al.  Blue luminescent centers and microstructural evaluation by XPS and Raman in ZnO thin films annealed in vacuum, N2 and O2 , 2007 .

[26]  Jianfeng Chen,et al.  In situ hydrothermal growth of hierarchical ZnO nanourchin for high-efficiency dye-sensitized solar cells , 2014 .

[27]  Yuan Zhang,et al.  Brush-Like Hierarchical ZnO Nanostructures: Synthesis, Photoluminescence and Gas Sensor Properties , 2009 .

[28]  B. Liu,et al.  Direct growth of ZnO nanodisk networks with an exposed (0001) facet on Au comb-shaped interdigitating electrodes and the enhanced gas-sensing property of polar {0001} surfaces , 2014 .

[29]  Aleksandra B. Djurišić,et al.  Green, yellow, and orange defect emission from ZnO nanostructures : Influence of excitation wavelength , 2006 .

[30]  C. Liu,et al.  Quantum-sized ZnO nanoparticles synthesized in aqueous medium for toxic gases detection , 2012 .

[31]  M. Houng,et al.  Surface modification of ZnO film by hydrogen peroxide solution , 2008 .

[32]  S. Fardindoost,et al.  Sensitive and selective room temperature H2S gas sensor based on Au sensitized vertical ZnO nanorods with flower-like structures , 2015 .

[33]  E. G. Bylander.  Surface effects on the low‐energy cathodoluminescence of zinc oxide , 1978 .

[34]  C. Lokhande,et al.  Gas sensing properties of hydrothermally grown ZnO nanorods with different aspect ratios , 2014 .

[35]  Junsin Yi,et al.  Improving the ethanol sensing of ZnO nano-particle thin films—The correlation between the grain size and the sensing mechanism , 2011 .

[36]  S. R. Silva,et al.  From 1D and 2D ZnO nanostructures to 3D hierarchical structures with enhanced gas sensing properties. , 2014, Nanoscale.

[37]  Xuchuan Jiang,et al.  Controllable Synthesis of ZnO Nanoflakes with Exposed (101̅0) for Enhanced Gas Sensing Performance , 2013 .

[38]  A. Janotti,et al.  Native point defects in ZnO , 2007 .

[39]  Changsheng Xie,et al.  Solution-Processed Gas Sensors Based on ZnO Nanorods Array with an Exposed (0001) Facet for Enhanced Gas-Sensing Properties , 2012 .

[40]  W. Geng,et al.  Influence of Interface Structure on the Properties of ZnO/Graphene Composites: A Theoretical Study by Density Functional Theory Calculations , 2013 .

[41]  David R. Clarke,et al.  On the optical band gap of zinc oxide , 1998 .

[42]  C. Liu,et al.  Quantum-sized ZnO nanoparticles: Synthesis, characterization and sensing properties for NO2 , 2011 .

[43]  W. Guo,et al.  Hydrothermal synthesis of ultrathin ZnO nanosheets and their gas-sensing properties , 2013, Journal of Materials Science: Materials in Electronics.

[44]  Christof Wöll,et al.  The chemistry and physics of zinc oxide surfaces , 2007 .

[45]  S. Jokela,et al.  Defects in ZnO , 2009 .

[46]  Shikuan Yang,et al.  Blue Luminescence of ZnO Nanoparticles Based on Non‐Equilibrium Processes: Defect Origins and Emission Controls , 2010 .

[47]  Guoxiu Wang,et al.  ZnO nanocrystals with a high percentage of exposed {4 2̄ 2̄ 3̄} reactive facets for enhanced gas sensing performance , 2013 .

[48]  Jun Liu,et al.  Secondary nucleation and growth of ZnO. , 2007, Journal of the American Chemical Society.

[49]  S. Studenikin,et al.  Fabrication of green and orange photoluminescent, undoped ZnO films using spray pyrolysis , 1998 .

[50]  D. Look,et al.  Residual Native Shallow Donor in ZnO , 1999 .

[51]  Dianqing Li,et al.  Facile synthesis and gas sensing properties of tubular hierarchical ZnO self-assembled by porous nanosheets , 2015 .

[52]  Jun Liu,et al.  Self-assembly of [100] grown ZnO nanowhiskers with exposed reactive (0001) facets on hollow spheres and their enhanced gas sensitivity , 2011 .

[53]  Shui-Tong Lee,et al.  Influence of Doping Effect on Zinc Oxide by First-Principles Studies , 2011 .

[54]  Mei Chen,et al.  Porous ZnO Polygonal Nanoflakes: Synthesis, Use in High-Sensitivity NO2 Gas Sensor, and Proposed Mechanism of Gas Sensing , 2011 .

[55]  P. P. Sahay,et al.  Alcohol-sensing characteristics of spray deposited ZnO nano-particle thin films , 2011 .

[56]  Zhipeng Li,et al.  Morphology-dependent gas-sensing properties of ZnO nanostructures for chlorophenol. , 2010, Chemistry, an Asian journal.

[57]  Yucheng Ding,et al.  Multi-junction joints network self-assembled with converging ZnO nanowires as multi-barrier gas sensor , 2013 .

[58]  Yeon-Tae Yu,et al.  Synthesis of flower-like ZnO microstructures for gas sensor applications , 2013 .

[59]  Jun Wang,et al.  Self-assembly of ZnO nanoparticles into hollow microspheres via a facile solvothermal route and their application as gas sensor , 2013 .

[60]  Q. Jiang,et al.  Influence of preparation methods on photoluminescence properties of ZnO films on quartz glass , 2008 .