Stable p-type conductivity and enhanced photoconductivity from nitrogen-doped annealed ZnO thin film

Abstract We report on the growth of p-type ZnO thin films with improved stability on various substrates and study the photoconductive property of the p-type ZnO films. The nitrogen doped ZnO (N:ZnO) thin films were grown on Si, quartz and alumina substrates by radio frequency magnetron sputtering followed by thermal annealing. Structural studies show that the N:ZnO films possess high crystallinity with c-axis orientation. The as-grown films possess higher lattice constants compared to the undoped films. Besides the high crystallinity, the Raman spectra show clear evidence of nitrogen incorporation in the doped ZnO lattice. A strong UV photoluminescence emission at ~ 380 nm is observed from all the N:ZnO thin films. Prior to post-deposition annealing, p-type conductivity was found to be unstable at room temperature. Post-growth annealing of N:ZnO film on Si substrate shows a relatively stable p-type ZnO with room temperature resistivity of 0.2 Ω cm, Hall mobility of 58 cm2/V s and hole concentration of 1.95 × 1017 cm− 3. A homo-junction p–n diode fabricated on the annealed p-type ZnO layer showed rectification behavior in the current–voltage characteristics demonstrating the p-type conduction of the doped layer. Doped ZnO films (annealed) show more than two orders of magnitude enhancement in the photoconductivity as compared to that of the undoped film. The transient photoconductivity measurement with UV light illumination on the doped ZnO film shows a slow photoresponse with bi-exponential growth and bi-exponential decay behaviors. Mechanism of improved photoconductivity and slow photoresponse is discussed based on high mobility of carriers and photodesorption of oxygen molecules in the N:ZnO film, respectively.

[1]  S. Jokela,et al.  Defects in ZnO , 2009 .

[2]  H. Ohno,et al.  Repeated temperature modulation epitaxy for p-type doping and light-emitting diode based on ZnO , 2004 .

[3]  Dilip K. Singh,et al.  Correlation between microstructure and optical properties of ZnO nanoparticles synthesized by ball milling , 2007 .

[4]  Anderson Janotti,et al.  Why nitrogen cannot lead to $p$-type conductivity in ZnO , 2009 .

[5]  J. Jie,et al.  Synthesis and Characterization of ZnO:In Nanowires with Superlattice Structure , 2004 .

[6]  Martin Strassburg,et al.  Nitrogen-related local vibrational modes in ZnO:N , 2002 .

[7]  D. C. Reynolds,et al.  Electrical properties of bulk ZnO , 1998 .

[8]  Ji-Yong Park,et al.  Enhanced photoconduction of free-standing ZnO nanowire films by L-lysine treatment , 2010, Nanotechnology.

[9]  A. Thean,et al.  Strain Effect in Large Silicon Nanocrystal Quantum Dots , 2001, Physical Models for Quantum Dots.

[10]  Masashi Kawasaki,et al.  Room-temperature ultraviolet laser emission from self-assembled ZnO microcrystallite thin films , 1998 .

[11]  H. Matsui,et al.  N doping using N2O and NO sources: From the viewpoint of ZnO , 2004 .

[12]  R. M. Mehra,et al.  p-type conduction in codoped ZnO thin films , 2003 .

[13]  A. Janotti,et al.  Native point defects in ZnO , 2007 .

[14]  Remo Guidieri.  Res , 1995, RES: Anthropology and Aesthetics.

[15]  Fang Qian,et al.  Nitrogen-doped ZnO nanowire arrays for photoelectrochemical water splitting. , 2009, Nano letters.

[16]  D. Schroder.  Semiconductor Material and Device Characterization , 1990 .

[17]  N. Ohashi,et al.  Positive Hall coefficients obtained from contact misplacement on evident n-type ZnO films and crystals , 2008 .

[18]  E. Fortunato,et al.  Influence of the reactive N2 gas flow on the properties of rf-sputtered ZnO thin films , 2007 .

[19]  N. Fujimura,et al.  Effect of Ce doping on the growth of ZnO thin films , 1997 .

[20]  Hyun-Sik Kim,et al.  Realization of p-type ZnO thin films via phosphorus doping and thermal activation of the dopant , 2003 .

[21]  C. H. Bhosale,et al.  Optoelectronic properties of sprayed transparent and conducting indium doped zinc oxide thin films , 2008 .

[22]  B. Yao,et al.  P-type conductivity and stability of nitrogen-doped zinc oxide prepared by magnetron sputtering , 2007 .

[23]  Bixia Lin,et al.  Green luminescent center in undoped zinc oxide films deposited on silicon substrates , 2001 .

[24]  Bruce E. Gnade,et al.  Mechanisms behind green photoluminescence in ZnO phosphor powders , 1996 .

[25]  James S. Speck,et al.  Causes of incorrect carrier-type identification in van der Pauw–Hall measurements , 2008 .

[26]  Shengbai Zhang,et al.  Impurity effects in ZnO and nitrogen-doped ZnO thin films fabricated by MOCVD , 2006 .

[27]  Hyoun-woo Kim,et al.  Growth of p-type ZnO thin films by using an atomic layer epitaxy technique and NH3 as a doping source , 2007 .

[28]  J. Nause,et al.  ZnO based light emitting diodes growth and fabrication , 2006, SPIE OPTO.

[29]  T. Ghosh,et al.  Highly enhanced ultraviolet photoresponse property in Cu-doped and Cu–Li co-doped ZnO films , 2009 .

[30]  B. Meyer,et al.  The Oxygen Vacancy as the Origin of a Green Emission in Undoped ZnO , 2001 .

[31]  David C. Look,et al.  Electrical and optical properties of p-type ZnO , 2005 .

[32]  Yujia Zeng,et al.  Investigation on ultraviolet photoconductivity in p-type ZnO thin films , 2007 .

[33]  F. Zhuge,et al.  p-type conduction in N–Al co-doped ZnO thin films , 2004 .

[34]  Byung-Teak Lee,et al.  Preparation of As-doped p-type ZnO films using a Zn3As2∕ZnO target with pulsed laser deposition , 2005 .

[35]  T. Tansley,et al.  Adsorption, desorption and conductivity of sputtered zinc oxide thin films , 1984 .

[36]  G. G. Stokes.  "J." , 1890, The New Yale Book of Quotations.

[37]  Cesare Soci,et al.  Rational synthesis of p-type zinc oxide nanowire arrays using simple chemical vapor deposition. , 2007, Nano letters.

[38]  D. C. Reynolds,et al.  Characterization of homoepitaxial p-type ZnO grown by molecular beam epitaxy , 2002 .

[39]  C. Wolden,et al.  On the formation and stability of p-type conductivity in nitrogen-doped zinc oxide , 2005 .

[40]  D. Basak,et al.  ZnO/polyaniline based inorganic/organic hybrid structure: Electrical and photoconductivity properties , 2008 .

[41]  Shui-Tong Lee,et al.  Tunable n‐Type Conductivity and Transport Properties of Ga‐doped ZnO Nanowire Arrays , 2008 .

[42]  Andrew G. Glen,et al.  APPL , 2001 .

[43]  Weidong Yu,et al.  Structural and electrical properties of nitrogen and aluminum codoped p-type ZnO films , 2004 .

[44]  J. Muth,et al.  Enhanced photoconductivity of ZnO films Co-doped with nitrogen and tellurium , 2005 .

[45]  R. Keezer.  Effect of Chemisorbed Oxygen on Photovoltaic and Photoconductive Processes in Rutile , 1964 .

[46]  E. Fortunato,et al.  Effect of different dopant elements on the properties of ZnO thin films , 2002 .