Simulation on the effect of non-uniform strain from the passivation layer on AlGaN/GaN HEMT

Abstract High electron mobility transistors (HEMTs) based on the III-nitride material system have attracted interest for high-frequency electronic components operating at high-power levels. Nitride based HEMTs can achieve power, bandwidth and efficiency levels that exceed the performance of Si, GaAs or SiC based devices. At present, a major limitation of nitride HEMTs is their failure to achieve reliability on par with Si-LDMOS or GaAs pHEMT devices. The development of SiN x passivation layers have largely mitigated the gate lag effect, however, this passivation layer introduces an additional strain that forms a non-uniform polarization induced charge. Furthermore, this excess strain can locally relax the film eliminating the piezoelectric induced charge in addition to forming defects that act as electron traps.

[1]  Walter Kruppa,et al.  Trapping effects and microwave power performance in AlGaN/GaN HEMTs , 2001 .

[2]  R. Airey,et al.  Influence of dual-frequency plasma-enhanced chemical-vapor deposition Si3N4 passivation on the electrical characteristics of AlGaN/GaN heterostructure field-effect transistors , 2004 .

[3]  G. G. Stokes.  "J." , 1890, The New Yale Book of Quotations.

[4]  S. M. Hu,et al.  Film‐edge‐induced stress in substrates , 1979 .

[5]  H. Lüth,et al.  Reduction of Misfit Dislocation Density in Finite Lateral Size Sil-xGex Films Grown by Selective Epitaxy , 1993 .

[6]  J. W. Matthews,et al.  Defects in epitaxial multilayers: III. Preparation of almost perfect multilayers , 1976 .

[7]  S. Jain,et al.  Edge‐induced stress and strain in stripe films and substrates: A two‐dimensional finite element calculation , 1995 .

[8]  F. Ren,et al.  Hydride vapor phase epitaxy-grown AlGaN/GaN high electron mobility transistors , 2003 .

[9]  Fischer,et al.  New approach in equilibrium theory for strained layer relaxation. , 1994, Physical review letters.

[10]  R. Dimitrov,et al.  Two dimensional electron gases induced by spontaneous and piezoelectric polarization in undoped and doped AlGaN/GaN heterostructures , 2000 .

[11]  D. Chidambarrao,et al.  DISLOCATION DYNAMICS NEAR FILM EDGES AND CORNERS IN SILICON , 1999 .

[12]  C. Oxley.  Calculation of minimum noise figure using the simple Fukui equation for gallium nitride (GaN) HEMTs , 2001 .

[13]  Simone Orcioni,et al.  High frequency thermal noise modelling of short-channel MOSFET's , 2001 .

[14]  Steven C. Binari,et al.  Investigation of traps producing current collapse in AlGaN/GaN high electron mobility transistors , 2001 .

[15]  Stephen J. Pearton,et al.  Fabrication and performance of GaN electronic devices , 2000 .

[16]  Andrew G. Glen,et al.  APPL , 2001 .

[17]  Jeffrey Y. Tsao,et al.  Relaxation of strained-layer semiconductor structures via plastic flow , 1987 .

[18]  Ephraim Suhir,et al.  New approach to the high quality epitaxial growth of lattice‐mismatched materials , 1986 .

[19]  C. Elissalde,et al.  Reliability of radio frequency dielectric experiments in perovskites , 1995 .

[20]  G. Schappert,et al.  Prepulse damage to targets and alignment verification , 1979 .

[21]  R. J. Shul,et al.  GAN : PROCESSING, DEFECTS, AND DEVICES , 1999 .

[22]  J. A. Roussos,et al.  Current collapse induced in AlGaN/GaN high-electron-mobility transistors by bias stress , 2003 .

[23]  Ephraim Suhir,et al.  Stresses in Multilayered Thin Films on a Thick Substrate , 1987 .

[24]  H. J. Hagger,et al.  Solid State Electronics , 1960, Nature.