Frequency-Weighted Model Predictive Control of Trailing Edge Flaps on a Wind Turbine Blade

This paper presents the load reduction achieved with trailing edge flaps during a full-scale test on a Vestas V27 wind turbine. The trailing edge flap controller is a frequency-weighted linear model predictive control (MPC) where the quadratic cost consists of costs on the zero-phase filtered flapwise blade root moment and trailing edge flap deflection. Frequency-weighted MPC is chosen for its ability to handle constraints on the trailing edge flaps deflection, and to target at loads with given frequencies only. The controller is first tested in servo-aeroelastic simulations, before being implemented on a Vestas V27 wind turbine. Consistent load reduction is achieved during the full-scale test. An average of 13.8% flapwise blade root fatigue load reduction is measured.

[1]  Michel Verhaegen,et al.  Feedback–feedforward individual pitch control for wind turbine load reduction , 2009 .

[2]  Gary Kanaby,et al.  Development of the Sweep-Twist Adaptive Rotor (STAR) Blade , 2010 .

[3]  Michel Verhaegen,et al.  Two-Degree-of-Freedom Active Vibration Control of a Prototyped “Smart” Rotor , 2011, IEEE Transactions on Control Systems Technology.

[4]  G. G. Stokes.  "J." , 1890, The New Yale Book of Quotations.

[5]  Michel Verhaegen,et al.  On the proof of concept of a ‘Smart’ wind turbine rotor blade for load alleviation , 2008 .

[6]  Morten Hartvig Hansen.  Aeroelastic modal analysis of backward swept blades using HAWCStab2 , 2011 .

[7]  Christian Bak,et al.  Wind Tunnel Test of a Closed Loop Controller for an Airfoil with Trailing Edge Flaps , 2010 .

[8]  Paul S. Veers,et al.  Increased rotor size through passive load control and weight reduction concepts. , 2009 .

[9]  D.E. Quevedo,et al.  Predictive Current Control Strategy With Imposed Load Current Spectrum , 2008, IEEE Transactions on Power Electronics.

[10]  Niels Kjølstad Poulsen,et al.  Results from the first full scale wind turbine equipped with trailing edge flaps , 2010 .

[11]  Ervin Bossanyi,et al.  Individual Blade Pitch Control for Load Reduction , 2003 .

[12]  Mac Gaunaa,et al.  Load alleviation on wind turbine blades using variable airfoil geometry , 2006 .

[13]  Thomas Buhl,et al.  Model Predictive Control of Trailing Edge Flaps on a wind turbine blade , 2011, Proceedings of the 2011 American Control Conference.

[14]  José R. Rodríguez,et al.  Predictive control based selective harmonic elimination with low switching frequency for multilevel converters , 2009, 2009 IEEE Energy Conversion Congress and Exposition.

[15]  Poul Ejnar Sørensen,et al.  Control design for a pitch-regulated, variable speed wind turbine , 2005 .

[16]  G.A.M. van Kuik,et al.  Review of state of the art in smart rotor control research for wind turbines , 2010 .

[17]  Michel Verhaegen,et al.  Robust and distributed control of a smart blade , 2010 .

[18]  Christian Bak,et al.  Wind tunnel test on airfoil Riso-B1-18 with an Active Trailing Edge Flap , 2010 .

[19]  David G. Wilson,et al.  ACTIVE AERODYNAMIC BLADE CONTROL DESIGN FOR LOAD REDUCTION ON LARGE WIND TURBINES , 2009 .

[20]  Fredrik Gustafsson,et al.  Determining the initial states in forward-backward filtering , 1996, IEEE Trans. Signal Process..

[21]  Matthew A. Lackner,et al.  A comparison of smart rotor control approaches using trailing edge flaps and individual pitch control , 2009 .

[22]  Christian Bak,et al.  A dynamic stall model for airfoils with deformable trailing edges , 2007 .

[23]  David Q. Mayne,et al.  Constrained model predictive control: Stability and optimality , 2000, Autom..

[24]  Ervin Bossanyi,et al.  Wind Energy Handbook , 2001 .

[25]  Martin Otto Laver Hansen,et al.  Aerodynamics of Wind Turbines , 2001 .

[26]  Torben J. Larsen,et al.  Active load reduction using individual pitch, based on local blade flow measurements , 2005 .

[27]  Christian Bak,et al.  Potential load reduction using airfoils with variable trailing edge geometry , 2005 .

[28]  Christian Bak,et al.  Deformable trailing edge flaps for modern megawatt wind turbine controllers using strain gauge sensors , 2010 .

[29]  Christian Bak,et al.  A dynamic stall model for airfoils with deformable trailing edges , 2009 .

[30]  Ervin Bossanyi,et al.  Further load reductions with individual pitch control , 2005 .

[31]  W. Marsden.  I and J , 2012 .

[32]  H. J. Ferreau,et al.  An online active set strategy to overcome the limitations of explicit MPC , 2008 .