Challenges in On-Chip Antenna Design and Integration With RF Receiver Front-End Circuitry in Nanoscale CMOS for 5G Communication Systems

This paper investigates design considerations and challenges of integrating on-chip antennas in nanoscale CMOS technology at millimeter-wave (mm-wave) to achieve a compact front-end receiver for 5G communication systems. Solutions to overcome these challenges are offered and realized in digital 28-nm CMOS. A monolithic on-chip antenna is designed and optimized in the presence of rigorous metal density rules and other back-end-of-the-line (BEoL) challenges of the nanoscale technology. The proposed antenna structure further exploits ground metallization on a PCB board acting as a reflector to increase its radiation efficiency and power gain by 37.3% and 9.8 dB, respectively, while decreasing the silicon area up to 30% compared to the previous works. The antenna is directly matched to a two-stage low noise amplifier (LNA) in a synergetic way as to give rise to an active integrated antenna (AIA) in order to avoid additional matching or interconnect losses. The LNA is followed by a double-balanced folded Gilbert cell mixer, which produces a lower intermediate frequency (IF) such that no probing is required for measurements. The measured total gain of the AIA is 14 dBi. Its total core area is 0.83 mm2 while the total chip area, including the pad frame, is $1.55 \times 0.85$ mm2.

[1]  E. Abou-Allam,et al.  Low-voltage 1.9-GHz front-end receiver in 0.5-μm CMOS technology , 2001, IEEE J. Solid State Circuits.

[2]  K.O. Kenneth,et al.  A 15-GHz wireless interconnect implemented in a 0.18-/spl mu/m CMOS technology using integrated transmitters, receivers, and antennas , 2001, 2001 Symposium on VLSI Circuits. Digest of Technical Papers (IEEE Cat. No.01CH37185).

[3]  Arthur van Roermund,et al.  A low-voltage folded-switching mixer in 0.18-μm CMOS , 2005 .

[4]  A. Sugavanam,et al.  On-chip antennas in silicon ICs and their application , 2005, IEEE Transactions on Electron Devices.

[5]  A. Hajimiri,et al.  A 77-GHz Phased-Array Transceiver With On-Chip Antennas in Silicon: Receiver and Antennas , 2006, IEEE Journal of Solid-State Circuits.

[6]  Dong Hun Shin,et al.  A 1.2-V, 5.8-mW, Ultra-Wideband Folded Mixer in 0.13-/spl mu/m CMOS , 2007, 2007 IEEE Radio Frequency Integrated Circuits (RFIC) Symposium.

[7]  P. Schvan,et al.  Algorithmic Design of CMOS LNAs and PAs for 60-GHz Radio , 2007, IEEE Journal of Solid-State Circuits.

[8]  Theodore S. Rappaport,et al.  On-Chip Integrated Antenna Structures in CMOS for 60 GHz WPAN Systems , 2009, GLOBECOM 2009 - 2009 IEEE Global Telecommunications Conference.

[9]  Xiaojun Yuan,et al.  A 60-GHz OOK Receiver With an On-Chip Antenna in 90 nm CMOS , 2010, IEEE Journal of Solid-State Circuits.

[10]  Filippo Capolino,et al.  Design of a CMOS On-Chip Slot Antenna With Extremely Flat Cavity at 140 GHz , 2011, IEEE Antennas and Wireless Propagation Letters.

[11]  Kai Kang,et al.  Integration of SiP-Based 60-GHz 4 $\,\times\,$4 Antenna Array With CMOS OOK Transmitter and LNA , 2011, IEEE Transactions on Microwave Theory and Techniques.

[12]  Kenichi Okada.  A 60GHz 16QAM/8PSK/QPSK/BPSK direct-conversion transceiver , 2011, 2011 9th IEEE International Conference on ASIC.

[13]  Wei Hong,et al.  Low-Cost 60-GHz Smart Antenna Receiver Subsystem Based on Substrate Integrated Waveguide Technology , 2012, IEEE Transactions on Microwave Theory and Techniques.

[14]  Y. Xiong,et al.  60-GHz AMC-Based Circularly Polarized On-Chip Antenna Using Standard 0.18-$\mu$ m CMOS Technology , 2012, IEEE Transactions on Antennas and Propagation.

[15]  M. Wojnowski,et al.  A 77-GHz SiGe single-chip four-channel transceiver module with integrated antennas in embedded wafer-level BGA package , 2012, 2012 IEEE 62nd Electronic Components and Technology Conference.

[16]  K. Yoshida,et al.  Performance optimization of a 60 GHz Antenna-on-Chip over an Artificial Magnetic Conductor , 2012, 2012 Japan-Egypt Conference on Electronics, Communications and Computers.

[17]  Huey-Ru Chuang,et al.  A 60-GHz CMOS Sub-Harmonic RF Receiver With Integrated On-Chip Artificial-Magnetic-Conductor Yagi Antenna and Balun Bandpass Filter for Very-Short-Range Gigabit Communications , 2013, IEEE Transactions on Microwave Theory and Techniques.

[18]  Theodore S. Rappaport,et al.  Millimeter Wave Mobile Communications for 5G Cellular: It Will Work! , 2013, IEEE Access.

[19]  Keiji Yoshida,et al.  Compact size high gain AoC using rectangular AMC in CMOS for 60 GHz millimeter wave applications , 2013, 2013 IEEE MTT-S International Microwave Symposium Digest (MTT).

[20]  A. Shamim,et al.  The last barrier: on-chip antennas , 2013, IEEE Microwave Magazine.

[21]  Fu-Lung Hsueh,et al.  A 12mW all-digital PLL based on class-F DCO for 4G phones in 28nm CMOS , 2014, 2014 Symposium on VLSI Circuits Digest of Technical Papers.

[22]  Xiaodai Dong,et al.  A wideband Artificial Magnetic Conductor Yagi antenna for 60-GHz standard 0.13-µm CMOS applications , 2014, 2014 12th IEEE International Conference on Solid-State and Integrated Circuit Technology (ICSICT).

[23]  Shuai Yuan,et al.  56 GHz bandwidth FMCW radar sensor with on-chip antennas in SiGe BiCMOS , 2014, 2014 IEEE MTT-S International Microwave Symposium (IMS2014).

[24]  Vincent Fusco,et al.  Low Noise Amplifier With Integrated Balanced Antenna for 60 GHz Wireless Communications , 2014, IEEE Transactions on Antennas and Propagation.

[25]  Dong Gang,et al.  Wideband 60-GHz on-chip triangular monopole antenna in CMOS technology , 2014, Proceedings of 2014 3rd Asia-Pacific Conference on Antennas and Propagation.

[26]  Roberto G. Rojas,et al.  V-band integrated on-chip antenna implemented with a partially reflective surface in standard 0.13-µm BiCMOS technology , 2015, 2015 IEEE International Symposium on Antennas and Propagation & USNC/URSI National Radio Science Meeting.

[27]  K. O. Kenneth,et al.  0.65–0.73THz quintupler with an on-chip antenna in 65-nm CMOS , 2015, 2015 Symposium on VLSI Circuits (VLSI Circuits).

[28]  Domenico Zito,et al.  32 dB Gain 28 nm Bulk CMOS W-Band LNA , 2015, IEEE Microwave and Wireless Components Letters.

[29]  Patrick Reynaert,et al.  A THz signal source with integrated antenna for non-destructive testing in 28nm bulk CMOS , 2015, 2015 IEEE Asian Solid-State Circuits Conference (A-SSCC).

[30]  Hui Chu,et al.  60-GHz broadband CMOS on-chip antenna with an artificial magnetic conductor , 2016, 2016 IEEE MTT-S International Microwave Workshop Series on Advanced Materials and Processes for RF and THz Applications (IMWS-AMP).

[31]  Max J. Ammann,et al.  A 38 GHz on-chip antenna in 28-nm CMOS using artificial magnetic conductor for 5G wireless systems , 2016, 2016 Fourth International Conference on Millimeter-Wave and Terahertz Technologies (MMWaTT).

[32]  Seizo Onoe.  1.3 Evolution of 5G mobile technology toward 1 2020 and beyond , 2016, 2016 IEEE International Solid-State Circuits Conference (ISSCC).

[33]  Aydin Babakhani,et al.  3-D Radar Imaging Based on a Synthetic Array of 30-GHz Impulse Radiators With On-Chip Antennas in 130-nm SiGe BiCMOS , 2017, IEEE Transactions on Microwave Theory and Techniques.

[34]  Seong-Sik Song,et al.  A 28GHz CMOS direct conversion transceiver with packaged antenna arrays for 5G cellular system , 2017, 2017 IEEE Radio Frequency Integrated Circuits Symposium (RFIC).

[35]  Xiaohong Tang,et al.  An On-Chip Frequency-Reconfigurable Antenna For Q-Band Broadband Applications , 2017, IEEE Antennas and Wireless Propagation Letters.

[36]  Aurangozeb,et al.  A quad channel 11-bit 1 GS/s 40 mW Collaborative ADC based enabling digital beamforming for 5G wireless , 2017, 2017 IEEE Radio Frequency Integrated Circuits Symposium (RFIC).

[37]  Gabriel M. Rebeiz,et al.  A Low-Cost Scalable 32-Element 28-GHz Phased Array Transceiver for 5G Communication Links Based on a $2\times 2$ Beamformer Flip-Chip Unit Cell , 2018, IEEE Journal of Solid-State Circuits.

[38]  Abdolali Abdipour,et al.  A 33-GHz LNA for 5G Wireless Systems in 28-nm Bulk CMOS , 2018, IEEE Transactions on Circuits and Systems II: Express Briefs.

[39]  Xiaodong Yang,et al.  On Chip Antenna Measurement: A Survey of Challenges and Recent Trends , 2018, IEEE Access.