CFD simulation of bubble column

Abstract Three-dimensional simulations of gas–liquid flow in the bubble column using the Euler–Euler approach is presented. The attempt is made to assess the performance and applicability of different turbulence models namely, k – ɛ , k – ɛ RNG, k – ω , Reynolds stress model (RSM) and large eddy simulation (LES) using a commercial code (ANSYS-CFX). For this purpose, the predictions are compared against the experimental data of Kulkarni et al. (2007) . Performance of the turbulence models is assessed on basis of comparison of axial liquid velocity, fractional gas hold-up, turbulent kinetic energy and turbulent eddy dissipation rate. All the non-drag (turbulent dispersion, virtual mass and lift force) and drag force were incorporated in the model. The low-Reynolds number treatment of the k – ω yields a better qualitative prediction than the k – ɛ model. The RSM predictions are comparable with LES results and seemed to give better prediction near the sparger, where the flow is more anisotropic and gives a clue why RANS approaches fails to predict the flow in this region. However, the large eddy simulations showed good agreement with the experimental data, but requires higher computational time than RSM.

[1]  Milorad P. Dudukovic,et al.  Dynamic simulation of bubbly flow in bubble columns , 1999 .

[2]  Knut Bech,et al.  Dynamic simulation of a 2D bubble column , 2005 .

[3]  V. Ranade,et al.  Eulerian-Lagrangian simulations of unsteady gas-liquid flows in bubble columns , 2006 .

[4]  Brian L. Smith,et al.  Large eddy simulation of a bubble column using dynamic sub-grid scale model , 2008 .

[5]  Rajamani Krishna,et al.  Scaling up Bubble Column Reactors with the Aid of CFD , 2001 .

[6]  G. M. Cartland Glover,et al.  The modelling of buoyancy driven flow in bubble columns , 2004 .

[7]  Santiago Laín,et al.  Modelling hydrodynamics and turbulence in a bubble column using the Euler-Lagrange procedure , 2002 .

[8]  Jyeshtharaj B. Joshi,et al.  CFD simulations of bubble column reactors: 1D, 2D and 3D approach , 2005 .

[9]  Tron Solberg,et al.  Large eddy simulation of the Gas-Liquid flow in a square cross-sectioned bubble column , 2001 .

[10]  Milorad P. Dudukovic,et al.  Numerical investigation of gas‐driven flow in 2‐D bubble columns , 2000 .

[11]  Gerhart Eigenberger,et al.  Applicability of the standard k–ε turbulence model to the dynamic simulation of bubble columns. Part II:: Comparison of detailed experiments and flow simulations , 1999 .

[12]  Jyeshtharaj B. Joshi,et al.  Two-Dimensional CFD Model for the Prediction of Flow Pattern, Pressure Drop and Heat Transfer Coefficient in Bubble Column Reactors , 2004 .

[13]  Jyeshtharaj B. Joshi,et al.  CFD Simulation of Residence Time Distribution and Mixing in Bubble Column Reactors , 2008 .

[14]  Mandar Tabib,et al.  CFD simulation of bubble column—An analysis of interphase forces and turbulence models , 2008 .

[15]  R. Lahey,et al.  Turbulent bubbly two-phase flow data in a triangular duct , 1994 .

[16]  H. Wagner,et al.  Hydrodynamic simulations of laboratory scale bubble columns fundamental studies of the Eulerian–Eulerian modelling approach , 1999 .

[17]  E. Lorenzini,et al.  A simplified method proposal for practical determination of aperiodic two-phase flow instability , 1981 .

[18]  V. Ranade,et al.  Characterization of dynamics of gas-liquid flows in rectangular bubble columns , 2004 .

[19]  Shantanu Roy,et al.  Numerical simulation of gas}liquid dynamics in cylindrical bubble column reactors , 1999 .

[20]  Vivek V. Ranade,et al.  Modelling of fluid dynamics and mixing in shallow bubble column reactors: Influence of sparger design , 2001 .

[21]  Gerhart Eigenberger,et al.  Gas—liquid flow in bubble columns and loop reactors: Part II. Comparison of detailed experiments and flow simulations , 1994 .

[22]  G. Eigenberger,et al.  Simulation of Buoyancy Driven Bubbly Flow: Established Simplifications and Open Questions (Journal Review) , 2004 .

[23]  Hidesada Tamai,et al.  Transverse migration of single bubbles in simple shear flows , 2002 .

[24]  Santiago Laín,et al.  Experimental and numerical studies of the hydrodynamics in a bubble column , 1999 .

[25]  Jyeshtharaj B. Joshi,et al.  On the development of flow pattern in a bubble column reactor : Experiments and CFD , 2007 .

[26]  Jam Hans Kuipers,et al.  Numerical simulation of the dynamic flow behavior in a bubble column : A study of closures for turbulence and interface forces , 2006 .

[27]  J. Joshi,et al.  CFD Simulation of Mixing and Dispersion in Bubble Columns , 2003 .

[28]  M. Milelli A numerical analysis of confined turbulent bubble plumes , 2002 .

[29]  N. Zuber,et al.  Drag coefficient and relative velocity in bubbly, droplet or particulate flows , 1979 .

[30]  Y. Sato,et al.  Liquid velocity distribution in two-phase bubble flow , 1975 .

[31]  J. Flaherty,et al.  Analysis of phase distribution in fully developed laminar bubbly two-phase flow , 1991 .

[32]  Brian L. Smith,et al.  Large-eddy simulation (LES) of the large scale bubble plume , 2009 .

[33]  Jyeshtharaj B. Joshi,et al.  Computational flow modelling and design of bubble column reactors , 2001 .