Tuning of ZnO 1D nanostructures by atomic layer deposition and electrospinning for optical gas sensor applications

We explored for the first time the ability of a three-dimensional polyacrylonitrile/ZnO material-prepared by a combination of electrospinning and atomic layer deposition (ALD) as a new material with a large surface area-to enhance the performance of optical sensors for volatile organic compound (VOC) detection. The photoluminescence (PL) peak intensity of these one-dimensional nanostructures has been enhanced by a factor of 2000 compared to a flat Si substrate. In addition, a phase transition of the ZnO ALD coating from amorphous to crystalline has been observed due to the properties of a polyacrylonitrile nanofiber template: surface strain, roughness, and an increased number of nucleation sites in comparison with a flat Si substrate. The greatly improved PL performance of these nanostructured surfaces could produce exciting materials for implantation in VOC optical sensor applications.

[1]  Won-Jae Lee,et al.  Effect of O2 plasma pretreatment on structural and optical properties of ZnO films on PES substrate by atomic layer deposition , 2013 .

[2]  J. Lin,et al.  Effects of pre-strain applied at a polyethylene terephthalate substrate before the coating of Al-doped ZnO film on film quality and optical and electrical properties , 2011 .

[3]  P. Déjardin,et al.  Enhanced Ionic Transport Mechanism by Gramicidin A Confined Inside Nanopores Tuned by Atomic Layer Deposition , 2013 .

[4]  Ping Yang,et al.  Fabrication of ZnO nanorod arrays via electrospinning assisted hydrothermal method , 2014 .

[5]  C. Tonon,et al.  Degradation of the optical properties of ZnO-based thermal control coatings in simulated space environment , 2001 .

[6]  R. Viter,et al.  Photoluminescence: A very sensitive tool to detect the presence of anatase in rutile phase electrospun TiO2 nanofibers , 2015 .

[7]  J. Michler,et al.  Urchin-inspired zinc oxide as building blocks for nanostructured solar cells , 2012, 1204.2728.

[8]  C. Li,et al.  Atomic Layer Deposition of ZnO on Multi-walled Carbon Nanotubes and Its Use for Synthesis of CNT–ZnO Heterostructures , 2010, Nanoscale research letters.

[9]  P. Maddalena,et al.  Room-temperature gas sensing based on visible photoluminescence properties of metal oxide nanobelts , 2006 .

[10]  Shoumin Zhang,et al.  ZnO nanorod gas sensor for ethanol detection , 2012 .

[11]  R. Viter,et al.  Evolution of microstructure and related optical properties of ZnO grown by atomic layer deposition , 2013, Beilstein journal of nanotechnology.

[12]  Y. Long,et al.  High performance of nanostructured ZnO film gas sensor at room temperature , 2014 .

[13]  M. Bechelany,et al.  ZnO nanotubes by template-assisted sol–gel route , 2012, Journal of Nanoparticle Research.

[14]  A. Khoury,et al.  Design of CoFe2O4/Co3O4 nanofibers with tunable morphology by Electrospinning , 2015 .

[15]  J. Laserna,et al.  Room temperature pulsed laser deposited ZnO thin films as photoluminiscence gas sensors , 2012 .

[16]  Zhao Wang,et al.  Hollow Urchin‐like ZnO thin Films by Electrochemical Deposition , 2010, Advanced materials.

[17]  Igor V. Adamovich,et al.  Control of electron recombination rate and electron density in optically-pumped non-equilibrium plasmas , 2001 .

[18]  Arunas Ramanavicius,et al.  Tuning Optical Properties of Al2O3/ZnO Nanolaminates Synthesized by Atomic Layer Deposition , 2014 .

[19]  Nicola Pinna,et al.  Atomic Layer Deposition of Nanostructured Materials for Energy and Environmental Applications , 2012, Advanced materials.

[20]  G. Faraji,et al.  A novel approach for preparation of aligned electrospun polyacrylonitrile nanofibers , 2013 .

[21]  Wanjin Zhang,et al.  Synthesis of size-tunable metal nanoparticles based on polyacrylonitrile nanofibers enabled by electrospinning and microwave irradiation , 2008 .

[22]  R. Raghavan,et al.  Nanocrystalline-to-amorphous transition in nanolaminates grown by low temperature atomic layer deposition and related mechanical properties , 2012 .

[23]  M. Bechelany,et al.  ZnO 1D nanostructures designed by combining atomic layer deposition and electrospinning for UV sensor applications , 2014 .

[24]  M. Bechelany,et al.  A highly efficient gold/electrospun PAN fiber material for improved laccase biocathodes for biofuel cell applications , 2014 .

[25]  Miin-Jang Chen,et al.  ZnO-based ultra-violet light emitting diodes and nanostructures fabricated by atomic layer deposition , 2012 .

[26]  F. Henneberger,et al.  Texture and morphology of ZnO grown on nanocrystalline p-sexiphenyl thin films , 2014 .

[27]  J. Michler,et al.  Electrochemical growth of ZnO nanowires on atomic layer deposition coated polystyrene sphere templates , 2013 .

[28]  Matteo Ferroni,et al.  Synthesis and characterization of semiconducting nanowires for gas sensing , 2007 .

[29]  Yulia O. Ogorodniichuk,et al.  Application of Room Temperature Photoluminescence From ZnO Nanorods for Salmonella Detection , 2014, IEEE Sensors Journal.

[30]  Deng-Guang Yu,et al.  Polyacrylonitrile nanofibers coated with silver nanoparticles using a modified coaxial electrospinning process , 2012, International journal of nanomedicine.