Waste tyre pyrolysis – A review

This review deals with the state-of-the-art of waste tyre pyrolysis for the first time in literature. Pyrolysis has been addressed as an attractive thermochemical process to tackle the waste tyre disposal problem while allowing energy recovery. Pyrolysis enables the separation of carbon black from tyres and the volatile matter released (condensable and non-condensable compounds) has the potential of renewable energy recovery given the significant proportion of natural rubber present in the tyre. Given this waste-to-energy pathway, a comprehensive review has been carried out in order to show the effects of the main process conditions (heating rate, temperature, pressure, carrier gas flow rate and type, volatiles residence time and pyrolysis time) on the physicochemical properties and distributions of the resulting products (gas, liquid and solid fractions). It has also been reviewed the influence of the size and composition of the feedstock. All reported results have been framed regarding the type of reactor as well as the experimental conditions used to avoid contradictions among the large number of publications on the subject. It is shown that the occurrence of secondary reactions is very sensitive to the interaction of the aforementioned variables. Also, the main properties of the pyrolytic products are pointed out. The liquid and gaseous fractions obtained are a valuable fuel source; while the solid fraction (char) has the recovery potential of low- grade carbon black or as carbon adsorbent after applying an activation step. Special attention has been given to the liquid fraction, highlighting its properties as alternative fuel in compression ignition engines.

[1]  Hideo Hosoda,et al.  Development of fluidized-bed pyrolysis of waste tires , 1979 .

[2]  W. Kaminsky,et al.  Feedstock recycling of synthetic and natural rubber by pyrolysis in a fluidized bed , 2009 .

[3]  Paul T. Williams,et al.  Catalytic Pyrolysis-Gasification of Waste Tire and Tire Elastomers for Hydrogen Production , 2010 .

[4]  D. DeMarini,et al.  Mutagenicity and chemical analysis of emissions from the open burning of scrap rubber tires. , 1994, Environmental science & technology.

[5]  Ramón Murillo,et al.  Emissions from the combustion of gas-phase products at tyre pyrolysis , 2007 .

[6]  S. Murugan,et al.  Assessment of pyrolysis oil as an energy source for diesel engines , 2009 .

[7]  A. Chaala,et al.  Production of coke from scrap tire vacuum pyrolysis oil , 1996 .

[8]  H. Bockhorn,et al.  Description of tire pyrolysis by thermal degradation behaviour of main components , 2006 .

[9]  A. Herlan.  On the formation of polycyclic aromatics: Investigation of fuel oil and emissions by high-resolution mass spectrometry , 1978 .

[10]  Mingming Lu,et al.  Investigation into the removal of sulfur from tire derived fuel by pyrolysis , 2008 .

[11]  G. S. Miguel,et al.  Pyrolysis of tire rubber: Porosity and adsorption characteristics of the pyrolytic chars , 1998 .

[12]  L. W. Collins,et al.  An evaluation of discarded tires as a potential source of fuel , 1974 .

[13]  Maria Stanciulescu,et al.  Characterization and potential applications of pyrolytic char from ablative pyrolysis of used tires , 2001 .

[14]  B. P. Faulkner,et al.  Carbon black production from waste tires , 2001 .

[15]  T. García,et al.  Optimisation of scrap automotive tyres recycling into valuable liquid fuels , 2000 .

[16]  C. Roy,et al.  Development of a gas-cleaning system for a scrap-tire vacuum-pyrolysis plant☆ , 1992 .

[17]  Paul T. Williams,et al.  Combustion of Tyre Pyrolysis Oil , 1998 .

[18]  O. Douzane,et al.  Physico-mechanical properties and water absorption of cement composite containing shredded rubber wastes , 2007 .

[19]  A. M. Mastral,et al.  PAH presence in oils and tars from coal–tyre coprocessing , 2000 .

[20]  T. García,et al.  Fluidized Bed Combustion (FBC) of Fossil and Nonfossil Fuels. A Comparative Study , 2000 .

[21]  Christian Roy,et al.  The vacuum pyrolysis of used tires , 1995 .

[22]  Eugeniusz Mokrzycki,et al.  Alternative fuels for the cement industry , 2003 .

[23]  Mahyar Arabani,et al.  The effect of waste tire thread mesh on the dynamic behaviour of asphalt mixtures , 2010 .

[24]  M. E. Sánchez,et al.  Pyrolysis of tyres: A comparison of the results from a fixed-bed laboratory reactor and a pilot plant (rotatory reactor) , 2005 .

[25]  Katherine L. Smith,et al.  Chemical composition of fuels and emissions from a coal + tire combustion experiment in a power station , 2006 .

[26]  Michèle Heitz,et al.  Environmental impact of the energy recovery of scrap tires in a cement kiln , 1998 .

[27]  Akbar A. Merchant,et al.  Pyrolysis of scrap tires and conversion of chars to activated carbon , 1993 .

[28]  T. García,et al.  Activation of pyrolytic tire char with CO2: kinetic study , 2004 .

[29]  F. Chen,et al.  Studies of the thermal degradation of waste rubber. , 2003, Waste management.

[30]  W. J. Kaminsky,et al.  Pyrolysis of Plastic Waste and Scrap Tires Using a Fluidized-Bed Process , 1980 .

[31]  C. Roy,et al.  Simultaneous gas chromatographic—Fourier transform infrared spectroscopic—mass spectrometric analysis of synthetic fuel derived from used tire vacuum pyrolysis oil, naphtha fraction , 1994 .

[32]  Falak O. Abas,et al.  Optimization of pyrolysis conditions of scrap tires under inert gas atmosphere , 2004 .

[33]  A. Chaala,et al.  Acid-base method for the demineralization of pyrolytic carbon black , 1996 .

[34]  M. Arabiourrutia,et al.  Kinetic modelling of tyre pyrolysis in a conical spouted bed reactor , 2008 .

[35]  José M. Encinar,et al.  Pyrolysis of automobile tyre waste. Influence of operating variables and kinetics study , 2001 .

[36]  G. Lopez,et al.  Vacuum Pyrolysis of Waste Tires by Continuously Feeding into a Conical Spouted Bed Reactor , 2010 .

[37]  T. García,et al.  Waste Tire Pyrolysis : Comparison between Fixed Bed Reactor and Moving Bed Reactor , 2008 .

[38]  Yiannis A. Levendis,et al.  Comparative study on the combustion and emissions of waste tire crumb and pulverized coal , 1996 .

[39]  Morton A. Barlaz,et al.  Potential To Use Waste Tires as Supplemental Fuel in Pulp and Paper Mill Boilers, Cement Kilns and in Road Pavement , 1993 .

[40]  Blaise Labrecque,et al.  Recycling of scrap tires to oil and carbon black by vacuum pyrolysis , 1990 .

[41]  D. Serrano,et al.  Fuels from Waste Plastics by Thermal and Catalytic Processes: A Review , 2008 .

[42]  A. Buekens.  Introduction to Feedstock Recycling of Plastics , 2006 .

[43]  Tiejun Wang,et al.  Vacuum pyrolysis of waste tires with basic additives. , 2008, Waste management.

[44]  C. Hui,et al.  Optimisation of particle size in waste tyre pyrolysis , 2012 .

[45]  Willard W. Pulkrabek,et al.  Engineering Fundamentals of the Internal Combustion Engine , 1997 .

[46]  Christian Roy,et al.  A new method for DTA measurement of enthalpy change during the pyrolysis of rubbers , 1996 .

[47]  Paul T. Williams,et al.  Catalytic pyrolysis of tyres: influence of catalyst temperature , 2002 .

[48]  G. S. Miguel,et al.  A study of the characteristics of activated carbons produced by steam and carbon dioxide activation of waste tyre rubber , 2003 .

[49]  Bill Brown,et al.  Carbon black: why quality matters , 2010 .

[50]  M. Rood,et al.  Reprocessing and reuse of waste tire rubber to solve air-quality related problems , 1998 .

[51]  Gilles Flamant,et al.  Co-production of hydrogen and carbon black from solar thermal methane splitting in a tubular reactor prototype , 2011 .

[52]  H. Haniu,et al.  Liquid fuels and chemicals from pyrolysis of motorcycle tire waste: Product yields, compositions and related properties , 2008 .

[53]  Nicholas Cheremisinoff,et al.  Gasification Technologies: A Primer for Engineers and Scientists , 2005 .

[54]  Yu-Min Chang,et al.  On pyrolysis of waste tire: Degradation rate and product yields , 1996 .

[55]  J. Scheirs,et al.  Feedstock recycling and pyrolysis of waste plastics : converting waste plastics into diesel and other fuels , 2006 .

[56]  A. Bridgwater,et al.  Fast pyrolysis processes for biomass , 2000 .

[57]  Rafael Font,et al.  Organic and inorganic pollutants from cement kiln stack feeding alternative fuels. , 2008, Journal of hazardous materials.

[58]  D. Mohan,et al.  Pyrolysis of Wood/Biomass for Bio-oil: A Critical Review , 2006 .

[59]  J. Scheirs.  Overview of Commercial Pyrolysis Processes for Waste Plastics , 2006 .

[60]  G. Nagarajan,et al.  Performance, emission and combustion studies of a DI diesel engine using Distilled Tyre pyrolysis oil-diesel blends , 2008 .

[61]  Ramón Murillo,et al.  Process for the Separation of Gas Products from Waste Tire Pyrolysis , 2006 .

[62]  W. Kaminsky,et al.  Thermal recycling of polymers , 1985 .

[63]  T. García,et al.  Production and Application of Activated Carbons Made from Waste Tire , 2005 .

[64]  U. Henriksen,et al.  Devolatilization characteristics of large particles of tyre rubber under combustion conditions , 2006 .

[65]  G. Cornacchia,et al.  Disposal of waste tyres for energy recovery and safe environment , 2000 .

[66]  Sylvain Coulombe,et al.  Formation of dl-limonene in used tire vacuum pyrolysis oils , 1991 .

[67]  Daniel A. Vallero,et al.  Waste : a handbook for management , 2011 .

[68]  Daren E. Daugaard,et al.  Enthalpy for Pyrolysis for Several Types of Biomass , 2003 .

[69]  C. Roy,et al.  Characterization of pyrolytic light naphtha from vacuum pyrolysis of used tyres comparison with petroleum naphtha , 1995 .

[70]  R. Alvarez,et al.  Slagging in Fluidized Bed Combustion of Rubber Tire. Inorganic Component Evolution , 2004 .

[71]  P. Williams,et al.  Characterization of Oils, Gases, and Char in Relation to the Pyrolysis of Different Brands of Scrap Automotive Tires , 2005 .

[72]  Giuseppe Maschio,et al.  Semi-active carbon and aromatics produced by pyrolysis of scrap tires , 1983 .

[73]  Dexter Russell,et al.  Scrap Tire Technology and Markets , 1993 .

[74]  S. Besler,et al.  The pyrolysis of automotive tyre waste , 1995 .

[75]  Lan Liang.  Recovery and evaluation of the solid products produced by thermocatalytic decomposition of tire rubber compounds , 2007 .

[76]  E. Kwon,et al.  Investigation of mechanisms of polycyclic aromatic hydrocarbons (PAHs) initiated from the thermal degradation of styrene butadiene rubber (SBR) in N2 atmosphere. , 2008, Environmental science & technology.

[77]  Tim C. Keener,et al.  Carbon Distribution from the Pyrolysis of Tire-Derived Fuels , 2006 .

[78]  I. Marco,et al.  Characterization of the liquid products obtained in tyre pyrolysis , 2004 .

[79]  C. Roy,et al.  Characterization of used tire vacuum pyrolysis oil: Nitrogenous compounds from the naphtha fraction , 1992 .

[80]  Christian Roy,et al.  Production of dl-limonene by vacuum pyrolysis of used tires , 2001 .

[81]  Paul T. Williams,et al.  Influence of Process Conditions on the Rate of Activation of Chars Derived from Pyrolysis of Used Tires , 1999 .

[82]  G Cornacchia,et al.  Pyrolysis process for the treatment of scrap tyres: preliminary experimental results. , 2002, Waste management.

[83]  P. García-Bacaicoa,et al.  Pyrolysis of waste tyres in an atmospheric static-bed batch reactor : Analysis of the gases obtained , 2005 .

[84]  D. Leung,et al.  Pyrolysis of tire powder: influence of operation variables on the composition and yields of gaseous product , 2002 .

[85]  Kefa Cen,et al.  Low-temperature gasification of waste tire in a fluidized bed , 2008 .

[86]  J. M. Bouvier,et al.  Gas-solid pyrolysis of tire wastes: kinetics and material balances of batch pyrolysis of used tires , 1987 .

[87]  D. Laird,et al.  Review of the pyrolysis platform for coproducing bio‐oil and biochar , 2009 .

[88]  W. Kaminsky,et al.  Pyrolysis of plastic waste and scrap tyres in a fluid bed reactor , 1980 .

[89]  Yukio Nakajima,et al.  Utilization of waste tires as fuel for cement production , 1981 .

[90]  Gordon McKay,et al.  Preparation and characterisation of demineralised tyre derived activated carbon , 2011 .

[91]  T. Wampler.  Applied pyrolysis handbook , 2006 .

[92]  Thomas Malkow,et al.  Novel and innovative pyrolysis and gasification technologies for energy efficient and environmentally sound MSW disposal. , 2004, Waste management.

[93]  A. G. Buekens,et al.  European experience in the pyrolysis and gasification of solid wastes , 1986 .

[94]  M. Arabiourrutia,et al.  Kinetics of scrap tyre pyrolysis under fast heating conditions , 2005 .

[95]  J. A. Conesa,et al.  Complete study of the pyrolysis and gasification of scrap tires in a pilot plant reactor. , 2004, Environmental science & technology.

[96]  Qiang Yao,et al.  Pilot-Scale Pyrolysis of Scrap Tires in a Continuous Rotary Kiln Reactor , 2004 .

[97]  Chi Wai Hui,et al.  Operation strategy for multi-stage pyrolysis , 2011 .

[98]  Xiu-li Yin,et al.  Pyrolysis of waste tires in a circulating fluidized-bed reactor , 2001 .

[99]  V. Cozzani,et al.  Influence of Secondary Reactions on the Heat of Pyrolysis of Biomass , 2009 .

[100]  L. F. Calvo,et al.  Pyrolysis of tyres. Influence of the final temperature of the process on emissions and the calorific value of the products recovered. , 2004, Waste management.

[101]  Paul T. Williams,et al.  Pyrolysis-thermogravimetric analysis of tyres and tyre components , 1995 .

[102]  T. García,et al.  Combustion of High Calorific Value Waste Material: Organic Atmospheric Pollution , 1999 .

[103]  William Y. Svrcek,et al.  Ultrapyrolysis of n-hexadecane in a novel micro-reactor , 1990 .

[104]  D. Serrano,et al.  Catalytic Upgrading of Plastic Wastes , 2006 .

[105]  Ji Won Jang,et al.  Discarded tire recycling practices in the United States, Japan and Korea , 1998 .

[106]  Dennis Y.C. Leung,et al.  Fluidized-bed gasification of waste tire powders , 2003 .

[107]  Walter Kaminsky,et al.  Processing of Plastic Waste and Scrap Tires into Chemical Raw Materials, Especially by Pyrolysis , 1976 .

[108]  J. A. Conesa,et al.  Gas from the pyrolysis of scrap tires in a fluidized bed reactor , 1996 .

[109]  Paul T. Williams,et al.  Sulfur-polycyclic aromatic hydrocarbons in tyre pyrolysis oil , 1995 .

[110]  B. Caballero,et al.  Pyrolysis of scrap tyres , 2001 .

[111]  Suneerat Pipatmanomai,et al.  Gasification of high moisture rubber woodchip with rubber waste in a bubbling fluidized bed , 2011 .

[112]  Javier Bilbao,et al.  Influence of Tire Formulation on the Products of Continuous Pyrolysis in a Conical Spouted Bed Reactor , 2009 .

[113]  Dennis Y.C. Leung,et al.  Kinetic study of scrap tyre pyrolysis and combustion , 1998 .

[114]  A. Buekens.  Some observations on the recycling of plastics and rubber , 1977 .

[115]  R. Siddique,et al.  Properties of concrete containing scrap-tire rubber--an overview. , 2004, Waste management.

[116]  L. T. Fan,et al.  Gasification of waste tires in a fluid bed reactor , 1981 .

[117]  L. Tang,et al.  Pyrolysis treatment of waste tire powder in a capacitively coupled RF plasma reactor , 2009 .

[118]  R. A. Fletcher,et al.  The role of pyrolysis in the disposal of waste tyres , 1981 .

[119]  M. Navarro,et al.  Assessment of tire devolatilization kinetics , 2005 .

[120]  R. Murillo,et al.  Coal Hydrocoprocessing with Tires and Tire Components , 1996 .

[121]  D. Meier,et al.  State of the art of applied fast pyrolysis of lignocellulosic materials - a review , 1999 .

[122]  F. Martínez-Boza,et al.  Novel recycled polyethylene/ground tire rubber/bitumen blends for use in roofing applications: Thermo-mechanical properties , 2010 .

[123]  T. Midgley,et al.  Natural and Synthetic Rubber. I. Products of the Destructive Distillation of Natural Rubber , 1929 .

[124]  Paul T. Williams,et al.  The pyrolysis of scrap automotive tyres , 1990 .

[125]  Gordon McKay,et al.  Production of active carbons from waste tyres––a review , 2004 .

[126]  Piero Salatino,et al.  A fast heating-rate thermogravimetric study of the pyrolysis of scrap tyres , 1999 .

[127]  Eilhann Kwon,et al.  Fundamental understanding of the thermal degradation mechanisms of waste tires and their air pollutant generation in a N2 atmosphere. , 2009, Environmental science & technology.

[128]  Bülent Özdalyan,et al.  The effect of tire derived fuel/diesel fuel blends utilization on diesel engine performance and emissions , 2012 .

[129]  Ramón Murillo,et al.  The application of thermal processes to valorise waste tyre , 2006 .

[130]  Y. Kar.  Catalytic pyrolysis of car tire waste using expanded perlite. , 2011, Waste management.

[131]  Cumali İlkılıç,et al.  Fuel production from waste vehicle tires by catalytic pyrolysis and its application in a diesel engi , 2011 .

[132]  Anastasia Zabaniotou,et al.  Pyrolysis of used automobile tires and residual char utilization , 2003 .

[133]  P. Pipilikaki,et al.  Use of tire derived fuel in clinker burning , 2005 .

[134]  T. García,et al.  Influence of Process Variables on Oils from Tire Pyrolysis and Hydropyrolysis in a Swept Fixed Bed Reactor , 2000 .

[135]  H. Haniu,et al.  Preliminary Investigation for Engine Performance by Using Tire-Derived Pyrolysis Oil-Diesel Blended Fuels , 2008 .

[136]  A. Zadgaonkar.  Process and Equipment for Conversions of Waste Plastics into Fuels , 2006 .

[137]  T. García,et al.  Kinetic Model Comparison for Waste Tire Char Reaction with CO2 , 2004 .

[138]  Peter R. Solomon,et al.  Reprocessing of used tires into activated carbon and other products , 1995 .

[139]  M. Arabiourrutia,et al.  Product distribution obtained in the pyrolysis of tyres in a conical spouted bed reactor , 2007 .

[140]  Didier Lecomte,et al.  Scrap tyre pyrolysis: Are the effluents valuable products? , 1997 .

[141]  Noriaki Wakao,et al.  Preparation of activated carbon by thermal decomposition of used automotive tires , 1987 .

[142]  Christian Roy,et al.  Characterization of naphtha and carbon black obtained by vacuum pyrolysis of polyisoprene rubber , 1997 .

[143]  M. Blazsó,et al.  Natural rubber pyrolysis: Study of temperature-and thickness-dependence indicates dimer formation mechanism , 1991 .

[144]  John B. Heywood,et al.  Internal combustion engine fundamentals , 1988 .

[145]  T. García,et al.  Valorisation of waste tyre by pyrolysis in a moving bed reactor. , 2010, Waste management.

[146]  Paul T. Williams,et al.  Aromatization of tyre pyrolysis oil to yield polycyclic aromatic hydrocarbons , 1993 .

[147]  S Murugan,et al.  The use of tyre pyrolysis oil in diesel engines. , 2008, Waste management.

[148]  Umberto Ghezzi,et al.  Experimental Evaluation of Waste Tires Utilization in Cement Kilns. , 1999, Journal of the Air & Waste Management Association.

[149]  Paul T. Williams,et al.  Composition of oils derived from the batch pyrolysis of tyres , 1998 .

[150]  J. R. Kim,et al.  Pyrolysis of waste tires with partial oxidation in a fluidized-bed reactor , 1995 .

[151]  Hongyu Huang,et al.  An investigation of sulfur distribution during thermal plasma pyrolysis of used tires , 2004 .

[152]  Juan Daniel Martínez,et al.  Production of activated carbon by waste tire thermochemical degradation with CO2. , 2009, Journal of hazardous materials.

[153]  Ramon Alvarez,et al.  Pyrolysis of a waste from the grinding of scrap tyres. , 2012, Journal of hazardous materials.

[154]  S. Wongkasemjit,et al.  Light olefins and light oil production from catalytic pyrolysis of waste tire , 2009 .

[155]  P. Salatino,et al.  Fluidized bed combustion of tyre derived fuel , 2003 .

[156]  Jale Yanik,et al.  Evaluation of two different scrap tires as hydrocarbon source by pyrolysis , 2005 .

[157]  R. Alvarez,et al.  Characterization of chars from coal-tire copyrolysis , 1999 .

[158]  Félix A López,et al.  Distillation of granulated scrap tires in a pilot plant. , 2011, Journal of hazardous materials.

[159]  J. M. Bouvier,et al.  Pyrolysis of rubber wastes in heavy oils and use of the products , 1986 .

[160]  Walter Kaminsky,et al.  Recycling of plastics , 1976 .

[161]  Javier Bilbao,et al.  Continuous pyrolysis of waste tyres in a conical spouted bed reactor , 2010 .

[162]  Olivier Beaumont,et al.  Influence of physical and chemical parameters on wood pyrolysis , 1984 .

[163]  T. García,et al.  Application of coal conversion technology to tire processing , 1999 .

[164]  Eugeniusz Mokrzycki,et al.  Use of alternative fuels in the Polish cement industry , 2003 .

[165]  Paul T. Williams,et al.  Waste tyre rubber as a secondary fuel for power plants , 2009 .

[166]  T. Sakai,et al.  Pyrolysis process for scrap tires , 1979 .

[167]  I. Marco,et al.  Chromatographic analysis of the gases obtained in tyre pyrolysis , 2000 .