Enhancing the overall efficiency of a lignite-fired oxyfuel power plant with CFB boiler and membrane-based air separation unit

The power plant analyzed in this paper consists of the following systems: a steam turbine, a supercritical OXY-type circulating fluidized bed boiler fed with lignite characterized by a high moisture content (42.5%), and an air separation unit based on a 3-end type high temperature membrane and CO2 compression installation. The steam turbine gross power is equal to 600 MW, and both the live and reheated steam parameters are equal to 600 °C/29 MPa and 620 °C/5 MPa, respectively. With the assumed constant gross power of the analyzed plant, the thermal efficiency of the boiler and the power requirements of the equipment used in the above mentioned installations were calculated. These values and also the net efficiency of the analyzed plant were determined as a function of the oxygen recovery rate in the membrane (R). The net efficiency is lower by 7.26 percentage points in comparison with the reference system. The basic method to reduce the loss of net efficiency is to introduce an integrated system, both with a boiler and an ASU installation lignite drying system. This allowed for the reduction of the loss of net efficiency of up to 3.9 percentage points for the lignite dried to w = 20% and 3.3 percentage points at w = 10%. Increase in the intensity of the drying of the lignite not only causes an increase in the maximum system efficiency but also reduces the required membrane surface. A further reduction in the loss of efficiency is sought in the thermal integration of all installations with a steam turbine. This procedure which may improve efficiency by approximately 0.4 percentage point is intended to allow the closure of extractions in the steam turbine and an increase in turbine power.

[1]  Behdad Moghtaderi,et al.  An overview on oxyfuel coal combustion—State of the art research and technology development , 2009 .

[2]  M. J. Mcintosh,et al.  Pressurised flash drying of Yallourn lignite , 2005 .

[3]  Michael Modigell,et al.  Simulation of a membrane unit for oxyfuel power plants under consideration of realistic BSCF membrane properties , 2010 .

[4]  Alfons Kather,et al.  Comparative thermodynamic analysis and integration issues of CCS steam power plants based on oxy-combustion with cryogenic or membrane based air separation , 2009 .

[5]  RajenderKumar Gupta,et al.  Oxy-fuel combustion technology for coal-fired power generation , 2005 .

[6]  Yasuki Kansha,et al.  Self-heat recuperative fluidized bed drying of brown coal , 2011 .

[7]  Kirsten Foy.  Comparison of Ion Transport Membranes , 2005 .

[8]  Renzo Castillo,et al.  Thermodynamic evaluation of membrane based oxyfuel power plants with 700 ° C technology , 2011 .

[9]  Haiqing Lin,et al.  Power plant post-combustion carbon dioxide capture: An opportunity for membranes , 2010 .

[10]  H. Verweij,et al.  Homogeneous porous perovskite supports for thin dense oxygen separation membranes , 2000 .

[11]  Michalis Agraniotis,et al.  Investigation of technical and economic aspects of pre-dried lignite utilisation in a modern lignite power plant towards zero CO2 emissions , 2012 .

[12]  P. A. Jensen,et al.  Oxy-fuel combustion of solid fuels , 2010 .

[13]  Rached Ben-Mansour,et al.  Modeling of ion transport reactor for oxy‐fuel combustion , 2013 .

[14]  Anna Skorek-Osikowska,et al.  Comparison of the Energy Intensity of the Selected CO2-Capture Methods Applied in the Ultra-supercritical Coal Power Plants , 2012 .

[15]  Ahmed F. Ghoniem,et al.  Numerical simulation of ion transport membrane reactors: Oxygen permeation and transport and fuel conversion , 2012 .

[16]  Alexander Mitsos,et al.  Ion transport membrane reactors for oxy-combustion – Part I: intermediate-fidelity modeling , 2011 .

[17]  A. Doukelis,et al.  Economic implications of oxyfuel application in a lignite-fired power plant , 2007 .

[18]  Janusz Kotowicz,et al.  Validation of a program for supercritical power plant calculations , 2011 .

[19]  A. Doukelis,et al.  Simulation of a Greenfield oxyfuel lignite-fired power plant , 2007 .

[20]  Chao Fu,et al.  Techno-economic analysis of CO2 conditioning processes in a coal based oxy-combustion power plant , 2012 .

[21]  Alexander Mitsos,et al.  Ion transport membrane reactors for oxy-combustionPart II: Analysis and comparison of alternatives , 2011 .

[22]  Sujit Karmakar,et al.  Thermodynamic analysis of high‐ash coal‐fired power plant with carbon dioxide capture , 2013 .

[23]  R. Castillo,et al.  Thermodynamic analysis of a hard coal oxyfuel power plant with high temperature three-end membrane for air separation , 2011 .

[24]  M. Nemitallah,et al.  Investigations of oxy-fuel combustion and oxygen permeation in an ITM reactor using a two-step oxy-combustion reaction kinetics model , 2013 .

[25]  John Davison,et al.  Performance and costs of power plants with capture and storage of CO2 , 2007 .

[26]  Łukasz Bartela,et al.  Optimisation of the connection of membrane CCS installation with a supercritical coal-fired power plant , 2012 .

[27]  Ming Liu,et al.  Thermodynamic analysis of pre-drying methods for pre-dried lignite-fired power plant , 2013 .

[28]  Alexander Mitsos,et al.  A review of recent developments in carbon capture utilizing oxy‐fuel combustion in conventional and ion transport membrane systems , 2011 .

[29]  Janusz Kotowicz,et al.  The influence of membrane CO2 separation on the efficiency of a coal-fired power plant , 2010 .

[30]  Rodney John Allam,et al.  Improved oxygen production technologies , 2009 .

[31]  Marco Gambini,et al.  Oxygen Transport Membranes for Ultra-Supercritical (USC) Power Plants With Very Low CO2 Emissions , 2012 .

[32]  E. Yantovski,et al.  Zero-emission fuel-fired power plants with ion transport membrane , 2004 .

[33]  H. Pawlak-Kruczek.  Efficiency of brown coal dryer depending on drying method , 2011 .

[34]  Michael Modigell,et al.  Oxyfuel coal combustion by efficient integration of oxygen transport membranes , 2011 .

[35]  Jean-Pierre Tranier,et al.  Air separation, flue gas compression and purification units for oxy-coal combustion systems , 2009 .

[36]  Michael Modigell,et al.  MEM-BRAIN gas separation membranes for zero-emission fossil power plants , 2009 .