Devices, Materials, and Processes for Nanoelectronics: Characterization with Advanced X‐Ray Techniques Using Lab‐Based and Synchrotron Radiation Sources

Future nanoelectronics manufacturing at extraordinary length scales, new device structures, and advanced materials will provide challenges to process development and engineering but also to process control and physical failure analysis. Advanced X‐ray techniques, using lab systems and synchrotron radiation sources, will play a key role for the characterization of thin films, nanostructures, surfaces, and interfaces. The development of advanced X‐ray techniques and tools will reduce risk and time for the introduction of new technologies. Eventually, time‐to‐market for new products will be reduced by the timely implementation of the best techniques for process development and process control. The development and use of advanced methods at synchrotron radiation sources will be increasingly important, particularly for research and development in the field of advanced processes and new materials but also for the development of new X‐ray components and procedures. The application of advanced X‐ray techniques, in‐line, in out‐of‐fab analytical labs and at synchrotron radiation sources, for research, development, and manufacturing in the nanoelectronics industry is reviewed. The focus of this paper is on the study of nanoscale device and on‐chip interconnect materials, and materials for 3D IC integration as well.

[1]  L. G. Parratt.  Surface Studies of Solids by Total Reflection of X-Rays , 1954 .

[2]  I. Lindau,et al.  Atomic subshell photoionization cross sections and asymmetry parameters: 1 ⩽ Z ⩽ 103 , 1985 .

[3]  F. J. Himpsel,et al.  Microscopic structure of the SiO 2 /Si interface , 1988 .

[4]  Barbara Greenebaum,et al.  Stress in metal lines under passivation; comparison of experiment with finite element calculations , 1991 .

[5]  M. D. Thouless,et al.  Stress development and relaxation in copper films during thermal cycling , 1993 .

[6]  Piero Pianetta,et al.  Total reflection x‐ray fluorescence spectroscopy using synchrotron radiation for wafer surface trace impurity analysis (invited) , 1995 .

[7]  Vinzenz Brendler,et al.  ROBL – a CRG beamline for radiochemistry and materials research at the ESRF , 1999 .

[8]  Oliver G. Schmidt,et al.  Self-assembled carbon-induced germanium quantum dots studied by grazing-incidence small-angle x-ray scattering , 1999 .

[9]  Piero Pianetta,et al.  Application of synchrotron radiation to TXRF analysis of metal contamination on silicon wafer surfaces , 2000 .

[10]  Olivier Proux,et al.  Structural and morphological studies of Co/SiO2 discontinuous multilayers , 2000 .

[11]  Ehrenfried Zschech,et al.  Microstructural characterization of inlaid copper interconnect lines , 2001 .

[12]  Olivier Renault,et al.  HfO2/SiO2 interface chemistry studied by synchrotron radiation x-ray photoelectron spectroscopy , 2002 .

[13]  E. Zschech,et al.  In situ SEM observation of electromigration phenomena in fully embedded copper interconnect structures , 2002 .

[14]  Conal E. Murray,et al.  Finite-size effects in thin-film composites , 2002 .

[15]  Erik H. Anderson,et al.  Dynamical x-ray microscopy investigation of electromigration in passivated inlaid Cu interconnect structures , 2002 .

[16]  Z. Suo,et al.  8.08 – Reliability of Metal Interconnects , 2003 .

[17]  Paul S. Ho,et al.  Thermal stress characteristics of Cu/oxide and Cu/low-k submicron interconnect structures , 2003 .

[18]  W. Ludwig,et al.  X-ray microscopy in Zernike phase contrast mode at 4 keV photon energy with 60 nm resolution , 2003 .

[19]  D. Delille,et al.  In-line monitoring of advanced microelectronic processes using combined X-ray techniques , 2004 .

[20]  M. Bidaud,et al.  Anticipation of nitrided oxides electrical thickness based on XPS measurement , 2004 .

[21]  Conal E. Murray,et al.  Finite size effects in stress analysis of interconnect structures , 2004 .

[22]  D. Schmeißer,et al.  Electronic Properties of the Interface Formed by Pr 2 O 3 Growth on Si(001), Si(111) and SiC(0001) Surfaces , 2005 .

[23]  Zhigang Suo,et al.  Saturated voids in interconnect lines due to thermal strains and electromigration , 2005 .

[24]  Young-Chang Joo,et al.  Effect of dielectric materials on stress-induced damage modes in damascene Cu lines , 2005 .

[25]  Ehrenfried Zschech,et al.  Electron Backscatter Diffraction: Application to Cu Interconnects in Top-View and Cross Section , 2005 .

[26]  Valeriy Sukharev,et al.  Microstructure effect on EM-induced copper interconnect degradation: Experiment and simulation , 2005 .

[27]  Ehrenfried Zschech,et al.  Materials for Information Technology , 2010 .

[28]  Ehrenfried Zschech,et al.  Texture and Stress Study of Sub-Micron Copper Interconnect Lines Using X-ray Microdiffraction , 2005 .

[29]  Gerd Schneider,et al.  X-ray Microscopy Studies of Electromigration in Advanced Copper Interconnects , 2006 .

[30]  Ehrenfried Zschech,et al.  Characterization of Chemical Bonding in Low-K Dielectric Materials for Interconnect Isolation: A XAS and EELS Study , 2006 .

[31]  Bryan Tracy,et al.  Advanced MOSFET Gate Dielectrics for High-Performance Microprocessors: Materials Selection and Analytical Challenges , 2006 .

[32]  Nancy Heylen,et al.  In-line Small-Spot X-Ray Fluorescence Assessment of Electroplating and Chemical Mechanical Polishing , 2006 .

[33]  Conal E. Murray,et al.  Effects of BEOL Stack on Thermal Mechanical Stress of Cu Lines , 2006 .

[34]  Gerd Schneider,et al.  Non-destructive high-resolution X-ray imaging of ULSI micro-electronics using keV X-ray microscopy in Zernike phase contrast , 2006 .

[35]  W. Yun,et al.  30 nm resolution x-ray imaging at 8 keV using third order diffraction of a zone plate lens objective in a transmission microscope , 2006 .

[36]  T. Marangon,et al.  Impact of narrow trench geometries on copper film crystallography , 2006 .

[37]  James P. Doyle,et al.  Thermal stress evolution in embedded Cu/low-k dielectric composite features , 2006 .

[38]  Olivier Renault,et al.  High-resolution photoelectron spectroscopy of Ge-based HfO2 gate stacks , 2007 .

[39]  Luciana Capello,et al.  Quantitative study of hydrogen-implantation-induced cavities in silicon by grazing incidence small angle x-ray scattering , 2007 .

[40]  A. Peled,et al.  Ultra Low‐κ Metrology Using X‐Ray Reflectivity And Small‐Angle X‐Ray Scattering Techniques , 2007 .

[41]  Aaron Thean,et al.  Metrology Of Silicide Contacts For Future CMOS , 2007 .

[42]  Ehrenfried Zschech,et al.  Nano-Scale Analysis Using Synchrotron-Radiation: Applications in the Semiconductor Industry , 2008 .

[43]  M. Burghammer,et al.  Scanning x-ray diffraction with 200nm spatial resolution , 2008 .

[44]  M. Frank,et al.  The relationship between local order, long range order, and sub-band-gap defects in hafnium oxide and hafnium silicate films , 2008 .

[45]  A. Toriumi,et al.  Experimental evidence for the flatband voltage shift of high-k metal-oxide-semiconductor devices due to the dipole formation at the high-k∕SiO2 interface , 2008 .

[46]  J. Gelb,et al.  High resolution hard x-ray microscope on a second generation synchrotron source. , 2008, The Review of scientific instruments.

[47]  Q. Shen,et al.  Hard x-ray microscopy with Fresnel zone plates reaches 40 nm Rayleigh resolution. , 2008 .

[48]  Konstantin Karavaev,et al.  The initial atomic layer deposition of HfO2∕Si(001) as followed in situ by synchrotron radiation photoelectron spectroscopy , 2008 .

[49]  Marc Juhel,et al.  Post electrochemical Cu deposition anneal impact on stress-voiding in individual vias , 2008 .

[50]  Ehrenfried Zschech,et al.  High-resolution X-ray imaging—a powerful nondestructive technique for applications in semiconductor industry , 2008 .

[51]  Weilun Chao,et al.  Demonstration of 12 nm resolution Fresnel zone plate lens based soft x-ray microscopy. , 2009, Optics express.

[52]  Mireille Maret,et al.  Grazing incidence small angle x-ray scattering study of the structure of nanoporous ultralow-k dielectrics prepared by plasma enhanced chemical vapor deposition , 2009 .

[53]  Jörg Raabe,et al.  Advanced thin film technology for ultrahigh resolution X-ray microscopy. , 2009, Ultramicroscopy.

[54]  S. Rehbein,et al.  Ultrahigh-resolution soft-x-ray microscopy with zone plates in high orders of diffraction. , 2009, Physical review letters.

[55]  Olivier Renault,et al.  X-ray photoelectron spectroscopy and ultraviolet photoelectron spectroscopy investigation of Al-related dipole at the HfO2/Si interface , 2009 .

[56]  Wen-li Wu,et al.  Small angle X-ray scattering measurements of spatial dependent linewidth in dense nanoline gratings ☆ , 2009 .

[57]  A. V. Vairagar,et al.  Geometry and Microstructure Effect on EM-Induced Copper Interconnect Degradation , 2009, IEEE Transactions on Device and Materials Reliability.

[58]  Peter Cloetens,et al.  A hard x-ray nanoprobe for scanning and projection nanotomography. , 2009, The Review of scientific instruments.

[59]  Oliver Aubel,et al.  Stress-induced phenomena in nanosized copper interconnect structures studied by x-ray and electron microscopy , 2009 .

[60]  Olivier Renault,et al.  Applications of high lateral and energy resolution imaging XPS with a double hemispherical analyser based spectromicroscope , 2010 .

[61]  C. Wyon,et al.  X-ray metrology for advanced microelectronics , 2010 .

[62]  T. Ishikawa,et al.  Breaking the 10 nm barrier in hard-X-ray focusing , 2010 .