Root-Cause Analysis of Peak Power Saturation in Pulse-Pumped 1100 nm Broad Area Single Emitter Diode Lasers

Many physical effects can potentially limit the peak achievable output power of single emitter broad area diode lasers under high current, pulse-pumped operation conditions. Although previous studies have shown reliable operation to high pump levels (240 A, 300 ns, and 1 kHz), power was found to saturate. We present here results of a systematic study to unambiguously determine the sources of this power saturation. A combination of detailed measurements and finite element device simulation were used for the diagnosis. We find that the measured power saturation is dominated by electron leakage caused by band bending at high bias due to the low mobility of the p-type waveguide. However, the power saturation is only fully reproduced when longitudinal spatial hole-burning is included. Higher powers are expected to be achieved if higher energy barriers and lower confinement factors are used to mitigate leakage and longitudinal hole-burning, respectively.

[1]  G. Erbert,et al.  Maximum output power of broad-area laser diodes , 2009, 2009 9th International Conference on Numerical Simulation of Optoelectronic Devices.

[2]  G. Erbert,et al.  Control of optical mode distribution through etched microstructures for improved broad area laser performance , 2008 .

[3]  A. Pietrzak,et al.  Peak power from 60-μm broad area single emitter limited to 50-W by carrier escape , 2008, 2008 Conference on Lasers and Electro-Optics and 2008 Conference on Quantum Electronics and Laser Science.

[4]  U. Zeimer,et al.  Novel passivation process for the mirror facets of Al-free active-region high-power semiconductor diode lasers , 2005, IEEE Photonics Technology Letters.

[5]  H. E. Larsen,et al.  Catastrophic optical mirror damage in diode lasers monitored during single-pulse operation , 2009 .

[6]  Hans Wenzel,et al.  Simulation of single-mode high-power semiconductor lasers , 1996, Photonics West.

[7]  A. Pietrzak,et al.  High-power laser diodes emitting light above 1100 nm with a small vertical divergence angle of 13° , 2008 .

[8]  R. Staske,et al.  High-power diode lasers with small vertical beam divergence emitting at 808 nm , 2001 .

[9]  G. Erbert,et al.  The analysis of factors limiting the maximum output power of broad-area laser diodes , 2009 .

[10]  H. Wenzel,et al.  Calculation of combined lateral and longitudinal spatial hole burning in lambda /4 shifted DFB lasers , 1993 .

[11]  V. A. Kapitonov,et al.  Studying the characteristics of pulse-pumped semiconductor 1060-nm lasers based on asymmetric heterostructures with ultrathick waveguides , 2006 .

[12]  A. Pietrzak,et al.  Assessment of the limits to peak power of 1100nm broad area single emitter diode lasers under short pulse conditions , 2009, LASE.

[13]  Uwe Bandelow,et al.  Fabry-Perot Lasers: Thermodynamics-Based Modeling , 2005 .

[14]  A. Pietrzak,et al.  Theoretical and experimental investigations of the limits to the maximum output power of laser diodes , 2010 .

[16]  R. S. Geels,et al.  Strained Ga/sub x/In/sub 1-x/P/(AlGa)/sub 0.5/In/sub 0.5/P heterostructures and quantum-well laser diodes , 1994 .

[17]  M. Nakatsuka,et al.  Optical Damage Threshold of Large Aperture High Power CO2 Laser Calorimeter , 1976 .

[18]  Dan Botez,et al.  Design considerations and analytical approximations for high continuous-wave power, broad-waveguide diode lasers , 1999 .

[19]  M. Yamada.  Transverse and longitudinal mode control in semiconductor injection lasers , 1983 .

[20]  A. Pietrzak,et al.  Passively Cooled TM Polarized 808-nm Laser Bars With 70% Power Conversion at 80-W and 55-W Peak Power per 100- $\mu$m Stripe Width , 2008, IEEE Photonics Technology Letters.

[21]  P. Gallion,et al.  New design rules and experimental study of slightly flared 1480-nm pump lasers , 2006, IEEE Photonics Technology Letters.

[22]  N. Stelmakh,et al.  External-to-cavity lateral-mode harnessing devices for high-brightness broad-area laser diodes: concept, realizations, and perspectives , 2009, OPTO.

[23]  A. Pietrzak,et al.  55 W peak power from 1100 nm wavelength 60 µm broad-area laser diodes enabled by reduced carrier accumulation in the waveguide , 2009 .

[24]  Hans Opower,et al.  High-Power Diode Lasers for Direct Applications , 2000 .

[25]  K. S. Borschev,et al.  Finite time of carrier energy relaxation as a cause of optical-power limitation in semiconductor lasers , 2006 .

[26]  P. Enders,et al.  Improved theory of the refractive-index change in quantum-well lasers , 1999 .