Indirect adaptive robust dynamic surface control in separate meter-in and separate meter-out control system

With the demand for energy efficiency in electrohydraulic servo systems (EHSS), the separate meter-in and separate meter-out (SMISMO) control system draws massive attention. In this paper, the SMISMO control system is decoupled completely into two subsystems by the proposed indirect adaptive robust dynamic surface control (IARDSC) method. Indirect adaptive robust control (IARC) is proposed to address the internal parameter uncertainties and external disturbances. Dynamic surface control (DSC) is utilized in the design procedure of IARC to deal with the inherent ‘explosion of terms’ problem. The proposed IARDSC simplifies the design procedure and decreases the computational cost of the controller. Besides, a faster parameter estimation scheme is proposed to adapt to the parameter change for a better estimation performance. Finally, experimental results show that the proposed IARDSC can achieve a good parameter estimation and trajectory tracking performance. Meanwhile, two energy saving techniques are discussed.

[1]  George E. Totten,et al.  Handbook of Hydraulic Fluid Technology , 2011 .

[2]  Robust adaptive position control of automotive electronic throttle valve using PID-type sliding mode technique , 2016, CCC 2016.

[3]  Jan-Ove Palmberg,et al.  Separate Controls of Meter-in and Meter-out Orifices in Mobile Hyraulic Systems , 1990 .

[4]  Miroslav Krstic,et al.  Nonlinear and adaptive control de-sign , 1995 .

[5]  George T.-C. Chiu,et al.  Adaptive robust motion control of single-rod hydraulic actuators: theory and experiments , 2000 .

[6]  Hansheng Wu,et al.  Adaptive robust backstepping control for a class of uncertain dynamical systems using neural networks , 2015 .

[7]  Li Xu,et al.  Adaptive robust precision motion control of linear motors with negligible electrical dynamics: theory and experiments , 2001 .

[8]  L. Berkovitz.  Convexity and Optimization in Rn , 2001 .

[9]  Dan Wang,et al.  Adaptive dynamic surface control for cooperative path following of marine surface vehicles with input saturation , 2014 .

[10]  Bing Xu,et al.  Simulation of Separate Meter In and Separate Meter Out Valve Arrangement used for synchronized control of two cylinders , 2009, 2009 IEEE/ASME International Conference on Advanced Intelligent Mechatronics.

[11]  Song Liu,et al.  Coordinate Control of Energy Saving Programmable Valves , 2008, IEEE Transactions on Control Systems Technology.

[12]  Wang,et al.  Application of a new adaptive robust controller design method to electro-hydraulic servo system , 2016 .

[13]  Swaroop Darbha,et al.  Dynamic surface control for a class of nonlinear systems , 2000, IEEE Trans. Autom. Control..

[14]  Carroll E. Goering,et al.  Programmable Electrohydraulic Valve , 1999 .

[15]  Junzheng Wang,et al.  Observer-Based Robust Control of 6-DOF Parallel Electrical Manipulator With Fast Friction Estimation , 2016, IEEE Transactions on Automation Science and Engineering.

[16]  Tao Zhang,et al.  Robust dynamic surface control of nonlinear systems with prescribed performance , 2014 .

[17]  Bin Yao,et al.  INDIRECT ADAPTIVE ROBUST CONTROL OF SISO NONLINEAR SYSTEMS IN SEMI-STRICT FEEDBACK FORMS , 2002 .

[18]  Song Liu,et al.  Automated onboard modeling of cartridge valve flow mapping , 2006, IEEE/ASME Transactions on Mechatronics.

[19]  Masayoshi Tomizuka,et al.  Adaptive robust control of SISO nonlinear systems in a semi-strict feedback form , 1997, Autom..

[20]  Robert H. Breeden.  Development of a High Pressure Load Sensing Mobile Valve , 1981 .

[21]  Junzheng Wang,et al.  Observer-based and energy saving control of single-rod electro-hydraulic servo system driven by servo motor , 2015, 2015 American Control Conference (ACC).

[22]  Song Liu,et al.  Energy-Saving Control of Single-Rod Hydraulic Cylinders with Programmable Valves and Improved Working Mode Selection , 2002 .

[23]  Hongxin Cao,et al.  Fruit-per-plant model for protected tomato , 2013 .

[24]  C. L. Philip Chen,et al.  Adaptive fuzzy dynamic surface control for a class of nonlinear systems with fuzzy dead zone and dynamic uncertainties , 2014, Nonlinear Dynamics.

[25]  Indra Narayan Kar,et al.  Adaptive robust tracking control of a class of nonlinear systems with input delay , 2015, Nonlinear Dynamics.

[26]  Jie Chen,et al.  Adaptive robust dynamic surface control of DC torque motors with true parameter estimates , 2010, Proceedings of the 2010 American Control Conference.