A model of evaporative cooling in a wetted hide

A theoretical model is presented for the simultaneous transfer of heat and mass in a wet fur that occurs when an animal is cooled by blowing air over its wetted coat. This method for reducing severe heat stress in cows is referred to as forced evaporative cooling. Previously published models for latent heat loss from the body surface of mammals assume that the skin surface is the only site where evaporation occurs, while the rest of the coat remains dry. This assumption is only appropriate for a model to describe sweating, but is not suited to cope with the prevailing conditions during forced evaporative cooling. By allowing for evaporation throughout the entire depth of the coat, the present model enables the evaluation of integrated parameters that characterize the cooling capacity of a wet hide, such as “evaporative effectiveness” or “effective wettedness”. The application of these parameters is demonstrated with experimental data obtained using an excised fur of a dairy cow. Simulation runs showed that these parameters depend on ambient thermal parameters (temperature, humidity and air velocity) and on intrinsic local properties such as water content and distribution within the hide. The results of this study contribute to the development of a rational design of a forced evaporative cooling strategy.

[1]  E. Eyal.  Shorn and unshorn Awassi sheep I. Body temperature , 1963, The Journal of Agricultural Science.

[2]  G. Campbell,et al.  Windspeed dependence of heat and mass transfer through coats and clothing , 1980 .

[3]  Frank Wiersma,et al.  Nonevaporative Convective Heat Transfer from the Surface of a Bovine , 1967 .

[4]  D. Wolfenson,et al.  Cooling dairy cattle by a combination of sprinkling and forced ventilation and its implementation in the shelter system. , 1986, Journal of dairy science.

[5]  A. J. McARTHUR,et al.  3 – THERMAL INSULATION AND HEAT LOSS FROM ANIMALS , 1981 .

[6]  A. Gagge,et al.  Moisture Permeation of Clothing : A Factor Governing Thermal Equilibrium and Comfort , 1973 .

[7]  R. Birkebak,et al.  Convective Energy Transfer in Fur , 1975 .

[8]  Frank Wiersma,et al.  Heat and Mass Transfer Coefficients for Water and Air in Aspen Excelsior Pads , 1977 .

[9]  J. Monteith,et al.  Transfer processes in animal coats. III. Water vapour diffusion , 1975, Proceedings of the Royal Society of London. Series B. Biological Sciences.

[10]  K. G. Gebremedhin,et al.  Quantitative analysis of the heat exchange through the fur layer of holstein calves , 1983 .

[11]  M. D. Shanklin,et al.  Spray cooling effects on milk production, milk, and rectal temperatures of cows during a moderate temperate summer season. , 1985, Journal of dairy science.

[12]  J. Hutchinson,et al.  Moisture, its accumulation and site of evaporation in the coats of sweating cattle , 1970, The Journal of Agricultural Science.

[13]  K Cena,et al.  Thermal insulation of animal coats and human clothing. , 1978, Physics in medicine and biology.

[14]  R. A. Nordstedt,et al.  Sprinkled Water and Fans to Reduce Heat Stress of Beef Cattle , 1989 .

[15]  Hillel Arkin,et al.  HEAT TRANSFER PROPERTIES OF DRY AND WET FURS OF DAIRY COWS , 1991 .

[16]  K Cena,et al.  Heat balance and thermal resistances of sheep's fleece. , 1974, Physics in medicine and biology.

[17]  K Cena,et al.  Transfer processes in animal coats. I. Radiative transfer , 1975, Proceedings of the Royal Society of London. Series B. Biological Sciences.

[18]  E. Eyal.  Shorn and unshorn Awassi sheep IV. Skin temperature and changes in temperature and humidity in the fleece and its surface , 1963, The Journal of Agricultural Science.

[19]  J P Libert,et al.  Human skin wettedness and evaporative efficiency of sweating. , 1979, Journal of applied physiology: respiratory, environmental and exercise physiology.