Melting and crystallization of colloidal hard-sphere suspensions under shear

Shear-induced melting and crystallization were investigated by confocal microscopy in concentrated colloidal suspensions of hard-sphere-like particles. Both silica and polymethylmethacrylate suspensions were sheared with a constant rate in either a countertranslating parallel plate shear cell or a counterrotating cone-plate shear cell. These instruments make it possible to track particles undergoing shear for extended periods of time in a plane of zero velocity. Although on large scales, the flow profile deviated from linearity, the crystal flowed in an aligned sliding layer structure at low shear rates. Higher shear rates caused the crystal to shear melt, but, contrary to expectations, the transition was not sudden. Instead, although the overall order decreased with shear rate, this was due to an increase in the nucleation of localized domains that temporarily lost and regained their ordered structure. Even at shear rates that were considered to have melted the crystal as a whole, ordered regions kept showing up at times, giving rise to very large fluctuations in 2D bond-orientational order parameters. Low shear rates induced initially disordered suspensions to crystallize. This time, the order parameter increased gradually in time without large fluctuations, indicating that shear-induced crystallization of hard spheres does not proceed via a nucleation and growth mechanism. We conclude that the dynamics of melting and crystallization under shear differ dramatically from their counterparts in quiescent suspensions.

[1]  Chen,et al.  Structural changes and orientaional order in a sheared colloidal suspension. , 1992, Physical review letters.

[2]  Jianing Liu,et al.  Heterogeneous nucleation of colloidal melts under the influence of shearing fields , 2004 .

[3]  T. Palberg,et al.  Sheared colloidal crystals in confined geometry: a real space study on stationary structures under shear. , 2003, Faraday discussions.

[4]  SHEAR BANDED FLOWS AND NEMATIC-TO-ISOTROPIC TRANSITION IN ER AND MR FLUIDS , 1999 .

[5]  A. Vrij,et al.  Synthesis and characterization of colloidal dispersions of fluorescent, monodisperse silica spheres , 1992 .

[6]  Tilmann Ruhl,et al.  Colloidal Crystals in Latex Films: Rubbery Opals , 2001 .

[7]  T. Kanai,et al.  Air‐Pulse‐Drive Fabrication of Photonic Crystal Films of Colloids with High Spectral Quality , 2005 .

[8]  J. Vermant.  Large-scale structures in sheared colloidal dispersions , 2001 .

[9]  T. G. M. Ven,et al.  The structure of sheared ordered latices , 1984 .

[10]  J. Vermant,et al.  Structure and rheology during shear-induced crystallization of a latex suspension. , 2002, Physical review. E, Statistical, nonlinear, and soft matter physics.

[11]  I. Cohen,et al.  Shear-induced configurations of confined colloidal suspensions. , 2004, Physical review letters.

[12]  Collective stochastic resonance in shear-induced melting of sliding bilayers. , 2003, Physical review. E, Statistical, nonlinear, and soft matter physics.

[13]  Tilmann Ruhl,et al.  Large Area Monodomain Order in Colloidal Crystals , 2004 .

[14]  H. Lekkerkerker,et al.  Preparation of monodisperse, fluorescent PMMA-latex colloids by dispersion polymerization. , 2002, Journal of colloid and interface science.

[15]  V. Colvin,et al.  Two-dimensional nonclose-packed colloidal crystals formed by spincoating , 2006 .

[16]  T. Ruhl,et al.  Artificial opals prepared by melt compression , 2003 .

[17]  A. Imhof,et al.  A new parallel plate shear cell for in situ real-space measurements of complex fluids under shear flow. , 2007, The Review of scientific instruments.

[18]  J. Vermant,et al.  Flow-induced structure in colloidal suspensions , 2005 .

[19]  Capillary freezing or complete wetting of hard spheres in a planar hard slit? , 2004, Physical review letters.

[20]  P. Harrowell,et al.  The shear induced disordering transition in a colloidal crystal: Nonequilibrium Brownian dynamic simulations , 1995 .

[21]  Bruce J. Ackerson,et al.  Shear induced order and shear processing of model hard sphere suspensions , 1990 .

[22]  Chen,et al.  Discontinuous shear thinning in ordered suspensions. , 1990, Physical review letters.

[23]  Crystallization kinetics of colloidal spheres under stationary shear flow. , 2005, Langmuir : the ACS journal of surfaces and colloids.

[24]  Cates,et al.  Nonlinear rheology of wormlike micelles. , 1993, Physical review letters.

[25]  B. Ackerson,et al.  Shear-induced order in suspensions of hard spheres. , 1988, Physical review letters.

[26]  T. Okubo,et al.  Kinetic analyses of colloidal crystallization in shear flow , 2004 .

[27]  D. Derks,et al.  Dynamics of colloidal crystals in shear flow , 2009 .

[28]  D. Derks,et al.  Confocal microscopy of colloidal dispersions in shear flow using a counter-rotating cone-plate shear cell , 2004 .

[29]  J. Vermant,et al.  Dynamic transitions and oscillatory melting of a two-dimensional crystal subjected to shear flow , 2004 .

[30]  T. Palberg,et al.  Multiphase Coexistence and Non-linear Rheology of Colloidal. Dispersions as Observed in a Model Capillary Viscosimeter , 1996 .

[31]  Michael J McFarland,et al.  Large-scale fabrication of wafer-size colloidal crystals, macroporous polymers and nanocomposites by spin-coating. , 2004, Journal of the American Chemical Society.

[32]  C. Zukoski,et al.  Rheological consequences of microstructural transitions in colloidal crystals , 1994 .

[33]  Jeffrey J. Gray,et al.  Rheology and dynamics of sheared arrays of colloidal particles , 1998 .

[34]  N. Clark,et al.  Neutron scattering from charge stabilized suspensions undergoing shear , 1986 .

[35]  Melting-freezing cycles in a relatively sheared pair of crystalline monolayers , 2002, cond-mat/0205030.

[36]  Velocity profiles in shear-banding wormlike micelles. , 2002, Physical review letters.

[37]  S. Brueck,et al.  A Facile Approach to Directed Assembly of Patterns of Nanoparticles Using Interference Lithography and Spin Coating , 2004 .

[38]  Hao Wang,et al.  Shear-banding and microstructure of colloids in shear flow. , 2003, Faraday discussions.

[39]  P. Callaghan,et al.  Observation of shear banding in worm-like micelles by NMR velocity imaging , 1996 .

[40]  Harrowell,et al.  Kinetics of crystallization in a shearing colloidal suspension. , 1995, Physical review. E, Statistical physics, plasmas, fluids, and related interdisciplinary topics.

[41]  J. Dhont,et al.  Shear Melting of Colloidal Crystals of Charged Spheres Studied with Rheology and Polarizing Microscopy , 1994 .

[42]  D. Frenkel,et al.  Crystal nucleation of colloidal suspensions under shear. , 2004, Physical review letters.

[43]  N. Clark,et al.  Shear-Induced Melting , 1981 .

[44]  R. Hoffman.  Discontinuous and dilatant viscosity behavior in concentrated suspensions. II. Theory and experimental tests , 1974 .

[45]  I. Cohen,et al.  Slip, yield, and bands in colloidal crystals under oscillatory shear. , 2006, Physical review letters.

[46]  James W. Goodwin,et al.  The preparation of poly(methyl methacrylate) latices in non-aqueous media , 1986 .

[47]  J. Vermant,et al.  Structure and dynamics of particle monolayers at a liquid-liquid interface subjected to shear flow. , 2003, Faraday discussions.

[48]  P. Pusey,et al.  Direct observation of oscillatory-shear-induced order in colloidal suspensions , 1998 .

[49]  Robbins,et al.  Simulations of shear-induced melting and ordering. , 1993, Physical review. E, Statistical physics, plasmas, fluids, and related interdisciplinary topics.

[50]  B. Ackerson.  Shear induced order of hard sphere suspensions , 1990 .

[51]  R. Hoffman.  Discontinuous and Dilatant Viscosity Behavior in Concentrated Suspensions. I. Observation of a Flow Instability , 1972 .

[52]  T. Palberg,et al.  Modes of motion in a confined colloidal suspension under shear , 2004 .

[53]  A. Mihi,et al.  Oriented Colloidal‐Crystal Thin Films by Spin‐Coating Microspheres Dispersed in Volatile Media , 2006 .

[54]  P. Callaghan,et al.  Two-Phase Shear Band Structures at Uniform Stress , 1997 .

[55]  C. Zukoski,et al.  Rheological and microstructural transitions in colloidal crystals , 1994 .

[56]  D. Grier,et al.  Methods of Digital Video Microscopy for Colloidal Studies , 1996 .

[57]  Robbins,et al.  Shear melting of colloids: A nonequilibrium phase diagram. , 1991, Physical review letters.