Flight Control with Optimal Control Allocation Incorporating Structural Load Feedback

Advances in sensors and avionics computation power suggest real-time structural load measurements could be used in flight control systems for improved safety and performance. A conventional transport flight control system determines the moments necessary to meet the pilot’s command while rejecting disturbances and maintaining stability of the aircraft. Control allocation is the problem of converting these desired moments into control effector commands. In this paper, a framework is proposed to incorporate real-time structural load feedback and structural load constraints in the control allocator. Constrained optimal control allocation can be used to achieve desired moments without exceeding specified limits on monitored load points. Furthermore, certain criteria can be minimized, such as loads on certain parts of the aircraft. Flight safety issues can be addressed by using system health monitoring information to change control allocation constraints during flight. The framework to incorporate structural l...

[1]  Liang Tang,et al.  Prognostics-enhanced Automated Contingency Management for advanced autonomous systems , 2008, 2008 International Conference on Prognostics and Health Management.

[2]  Ping Lu,et al.  Two Reconfigurable Flight-Control Design Methods: Robust Servomechanism and Control Allocation , 2001 .

[3]  Charles R. Farrar,et al.  Damage identification and health monitoring of structural and mechanical systems from changes in their vibration characteristics: A literature review , 1996 .

[4]  Charles R Farrar,et al.  Damage prognosis: the future of structural health monitoring , 2007, Philosophical Transactions of the Royal Society A: Mathematical, Physical and Engineering Sciences.

[5]  E. Polak.  Introduction to linear and nonlinear programming , 1973 .

[6]  James F Buffington.  Modular Control Law Design for the Innovative Control Effectors (ICE) Tailless Fighter Aircraft Configuration 101-3 , 1999 .

[7]  Youmin Zhang,et al.  Bibliographical review on reconfigurable fault-tolerant control systems , 2003, Annu. Rev. Control..

[8]  Jonathan S. Litt,et al.  Adaptive Gas Turbine Engine Control for Deterioration Compensation Due to Aging , 2003 .

[9]  Marc Bodson,et al.  Evaluation of optimization methods for control allocation , 2001 .

[10]  John J. Burken,et al.  A Framework for Optimal Control Allocation with Structural Load Constraints , 2010 .

[11]  M. Bodson,et al.  Load Balancing in Control Allocation , 2011 .

[12]  M. Bodson,et al.  Flight testing of a reconfigurable control system on an unmanned aircraft , 2004, Proceedings of the 2004 American Control Conference.

[13]  Jeffrey S. Hill,et al.  Airborne Subscale Transport Aircraft Research Testbed: Aircraft Model Development , 2005 .

[14]  Wayne C. Durham.  Constrained Control Allocation , 1992 .

[15]  John A. M. Petersen,et al.  Interior-Point Algorithms for Control Allocation , 2003 .

[16]  Christine M. Belcastro,et al.  AirSTAR: A UAV Platform for Flight Dynamics and Control System Testing , 2006 .

[17]  David B. Doman,et al.  A Method for Including Control Effector Interactions in the Control Allocation Problem (Preprint) , 2007 .

[18]  D. Enns.  CONTROL ALLOCATION APPROACHES , 1998 .

[19]  John A. M. Petersen,et al.  Constrained quadratic programming techniques for control allocation , 2003, 42nd IEEE International Conference on Decision and Control (IEEE Cat. No.03CH37475).

[20]  Susan A. Frost,et al.  Investigation of Optimal Control Allocation for Gust Load Alleviation in Flight Control , 2012 .

[21]  O. Harkegard.  Efficient active set algorithms for solving constrained least squares problems in aircraft control allocation , 2002, Proceedings of the 41st IEEE Conference on Decision and Control, 2002..