Recent studies on photoconductive thin films of binary compounds

Abstract In this paper a review of recent progress achieved in the domain of MX 2 films (M=Mo, W; X=Se, S) is presented. The MoS 2 is essentially discussed. It is shown that the emerging interest in the use of MX 2 thin films as absorbing layer in photovoltaic cells has induced significant improvements of the crystalline and optoelectrical properties of these films. Some years ago the films obtained were crystallized in the 2H-MoS 2 structure but the size of their crystallites was small and the samples were poorly photoconductive. Recently many works have shown that, whatever the deposition technique used, textured films with large grains and good photoconductive properties could be obtained when a thin nickel layer is used. During the post annealing treatment, this thin nickel layer diffuses all over the thickness of the films. It is proposed that systematically the crystallization process of MX 2 films is a two-step process. The primary crystallization corresponds to small crystallites formation and the secondary crystallization corresponds to large ordered domains growth by coalescence of the small crystallized domains. This secondary crystallization process is facilitated by the presence of Van der Waals surfaces parallel to the plane of the substrate. Moreover, this effect is strongly improved in the presence of nickel which allows the obtention of high quality films. The electrical properties of these films are interpreted with the help of grain boundary theories.

[1]  J. Bernède,et al.  MoS2 thin film synthesis by soft sulfurization of a molybdenum layer. , 1995 .

[2]  MoSe2 thin films synthesized by solid state reactions between Mo and Se thin films , 1990 .

[3]  Experimental obviousness of the necessity for a thin Ni interfacial layer to obtain highly ordered photoconductive MoS2 films , 1997 .

[4]  Giorgio Baccarani,et al.  Transport properties of polycrystalline silicon films , 1978 .

[5]  A. Ennaoui,et al.  Preparation of textured and photoactive 2H-WS2 thin films by sulfurization of WO3 , 1995 .

[6]  Primary and secondary crystallization processes of WSe2 films , 1994, Journal of Materials Science.

[7]  R. Tenne,et al.  Highly Oriented WSe2 Thin-Films Prepared by Selenization of Evaporated WO3 , 1994 .

[8]  P. Bertrand.  Orientation of rf-sputter-deposited MoS_2 films , 1989 .

[9]  F. Lévy,et al.  The low-energy absorption edge in 2H-MoS2 and 2H-MoSe2 , 1975 .

[10]  Richard K. Steinberg.  Hot‐Cathode Arcs in Cesium Vapor , 1950 .

[11]  J. Bernède,et al.  High quality crystalline MoS2 thin films obtained on Ni coated substrates: optimization of the post-annealing treatment , 1997 .

[12]  Gary Hodes,et al.  Electrochemical deposition of MoS2 thin films by reduction of tetrathiomolybdate , 1996 .

[13]  Chemically Deposited Semiconducting Molybdenum Sulfide Thin Films , 1990 .

[14]  N. F. Mott,et al.  Conduction in non-Crystalline systems: IV. Anderson localization in a disordered lattice , 1970 .

[15]  F. Lévy,et al.  Texture characterisation of sputtered MoS2 thin films by cross-sectional TEM analysis , 1990 .

[16]  F. Stirpe,et al.  Electrochemical solar cells with layer-type semiconductor anodes. Performance of n-MoS2 cells , 1981 .

[17]  MoTe2 Thin Films Synthesized by Solid State Reactions between Mo and Te Thin Films , 1992 .

[18]  C. H. Seager,et al.  The dc voltage dependence of semiconductor grain‐boundary resistance , 1979 .

[19]  A. Ruoff,et al.  Diamond: An efficient source of soft x rays for high‐resolution x‐ray lithography , 1978 .

[20]  J. Seto.  The electrical properties of polycrystalline silicon films , 1975 .

[21]  C. Roxlo,et al.  Bulk and surface optical absorption in molybdenum disulfide , 1987 .

[22]  G. Couturier,et al.  Transport properties of Ni–WS2 photoconductive thin films , 1997 .

[23]  F. Lévy,et al.  Morphological and compositional properties of MoSe2 films prepared by r.f. magnetron sputtering , 1984 .

[24]  F. Lévy,et al.  Electrical and optical properties of MoSe2 films prepared by r.f. magnetron sputtering , 1985 .

[25]  C. Thompson.  Secondary grain growth in thin films of semiconductors: Theoretical aspects , 1985 .

[26]  J. Werner.  Origin of Curved Arrhenius Plots for the Conductivity of Polycrystalline Semiconductors , 1994 .

[27]  R. Fonville,et al.  On the nature of the top of the valence band in layered Mo and W dichalcogenides , 1978 .

[28]  B. Parkinson,et al.  Further studies of the photoelectrochemical properties of the group VI transition metal dichalcogenides , 1982 .

[29]  P. Pramanik,et al.  Deposition of molybdenum chalcogenide thin films by the chemical deposition technique and the effect of bath parameters on these thin films , 1990 .