Experimental study of filling capacity of self-compacting concrete and its influence on the properties of rock-filled concrete

Abstract Rock-filled concrete (RFC) was developed in China mainly for large-scale concrete construction. The distinctive casting procedure of RFC makes it highly dependent on the filling capacity of self-compacting concrete (SCC). This study investigated two of the most controversial issues regarding RFC—the filling performance of SCC and the large interface between SCC and rocks. These issues were examined through an experimental setup designed to stimulate SCC flow in rock skeleton. The effects of different factors (aggregate size, yield stress, etc.) on the filling capacity of SCC and the properties of RFC were investigated on the basis of filling rate, cross-section porosity, and interface microstructure. Two clogging mechanisms were summarized from literature and used to explain the experimental results. The findings indicate that the interface microstructure of RFC greatly depends on the filling performance of SCC which is significantly affected by the size and condition of the large rocks.

[1]  Jan Olek,et al.  Influence of aggregate size, water cement ratio and age on the microstructure of the interfacial transition zone , 2003 .

[2]  Philippe Coussot,et al.  Rheological interpretation of deposits of yield stress fluids , 1996 .

[3]  N. Roussel,et al.  Correlation between L-box test and rheological parameters of a homogeneous yield stress fluid , 2006 .

[4]  Nicolas Roussel,et al.  Correlation between Yield Stress and Slump: Comparison between Numerical Simulations and Concrete Rheometers Results , 2005 .

[5]  Nicolas Roussel,et al.  From mini-cone test to Abrams cone test: measurement of cement-based materials yield stress using slump tests , 2005 .

[6]  Nicolas Roussel,et al.  Passing Ability of Fresh Concrete: A Probabilistic Approach , 2009 .

[7]  Taha Sochi,et al.  Modelling the Flow of Yield-Stress Fluids in Porous Media , 2009, 0910.0619.

[8]  K. Scrivener,et al.  The Interfacial Transition Zone (ITZ) Between Cement Paste and Aggregate in Concrete , 2004 .

[9]  Mohamed Sonebi,et al.  Filling ability and plastic settlement of self-compacting concrete , 2002 .

[10]  J. Olek,et al.  Influence of lightweight aggregate on the microstructure and durability of mortar , 2005 .

[11]  Martin J Blunt,et al.  Predictive network modeling of single-phase non-Newtonian flow in porous media. , 2003, Journal of colloid and interface science.

[12]  Tahir Çelik,et al.  Effect of coarse aggregate size and matrix quality on ITZ and failure behavior of concrete under uniaxial compression , 2004 .

[13]  Nicolas Roussel,et al.  Rheology of fresh concrete: from measurements to predictions of casting processes , 2007 .

[14]  Joost C. Walraven,et al.  Parameter-study on the influence of steel fibers and coarse aggregate content on the fresh properties of self-compacting concrete , 2001 .

[15]  Jin Feng,et al.  Study on rock-fill concrete dam , 2005 .

[16]  Adrian Long,et al.  Influence of coarse aggregate on the permeation, durability and the microstructure characteristics of ordinary Portland cement concrete , 2005 .

[17]  S. Diamond.  Considerations in image analysis as applied to investigations of the ITZ in concrete , 2001 .

[18]  James J. Beaudoin,et al.  Effect of aggregate size on transition zone properties at the Portland cement paste interface , 1991 .

[19]  Angel Garcimartín,et al.  Jamming during the discharge of granular matter from a silo. , 2005, Physical review. E, Statistical, nonlinear, and soft matter physics.

[20]  N. Roussel,et al.  Flow and jamming of granular mixtures through obstacles , 2007 .

[21]  Pak,et al.  Jamming of Granular Flow in a Two-Dimensional Hopper. , 2001, Physical review letters.

[22]  Steven L. Bryant,et al.  Network model evaluation of permeability and spatial correlation in a real random sphere packing , 1993 .

[23]  Matthew D. Jackson,et al.  Detailed physics, predictive capabilities and macroscopic consequences for pore-network models of multiphase flow. , 2002 .

[24]  D. Maza,et al.  Jamming and critical outlet size in the discharge of a two-dimensional silo , 2008 .

[25]  Nicolas Roussel,et al.  From ordinary rhelogy concrete to self compacting concrete: A transition between frictional and hydrodynamic interactions , 2008 .

[26]  H. H. C. Wong,et al.  Passing ability and segregation stability of self-consolidating concrete with different aggregate proportions , 2006 .