Propagation Characteristics of Supercritical Carbon Dioxide Induced Fractures under True Tri-Axial Stresses

Supercritical carbon dioxide (SC-CO2) fracturing is a non-aqueous fracturing technology, which has attracted considerable attention on exploiting shale gas. In this study, shale specimens and artificial sandstone specimens were used to conduct SC-CO2 fracturing and water fracturing experiments to investigate the characteristics of SC-CO2 induced fractures. An acoustic emission (AE) monitoring device was employed to monitor the AE energy release rate during the experiment. The experiment results indicate that the breakdown pressure of SC-CO2 fracturing is lower than that of water fracturing under the same conditions, and the AE energy release rate of SC-CO2 fracturing is 1–2 orders of magnitude higher than that of water fracturing. In artificial sandstone, which is homogeneous, the main fracture mainly propagates along the directions perpendicular to the minimum principal stress, no matter if using SC-CO2 or water as the fracturing fluid, but in shale with weak structural planes, the propagation direction of the fracture is controlled by the combined effect of a weak structural plane and in-situ stress.

[1]  Robert G. Jeffrey,et al.  Deflection and propagation of fluid-driven fractures at frictional bedding interfaces: A numerical investigation , 2007 .

[2]  Guangqing Zhang,et al.  Experimental investigation on fracture propagation modes in supercritical carbon dioxide fracturing using acoustic emission monitoring , 2018, International Journal of Rock Mechanics and Mining Sciences.

[3]  G. Yin,et al.  Experimental investigation of fracture propagation induced by carbon dioxide and water in coal seam reservoirs , 2018, Powder Technology.

[4]  Man Huang,et al.  Experimental and theoretical analysis of a supercritical carbon dioxide jet on wellbore temperature and pressure , 2016 .

[5]  Satish Karra,et al.  Shale gas and non-aqueous fracturing fluids: Opportunities and challenges for supercritical CO2 , 2015 .

[6]  Jinliang Huang,et al.  Shale Gas in China: Reality and Dream , 2015 .

[7]  Shicheng Zhang,et al.  Experimental study on the growth behavior of supercritical CO 2 -induced fractures in a layered tight sandstone formation , 2018 .

[8]  Brandon C. Ames,et al.  Impact of Partially Cemented and Non-persistent Natural Fractures on Hydraulic Fracture Propagation , 2016, Rock Mechanics and Rock Engineering.

[9]  Yan Jin,et al.  Analysis of hydraulic fracture initiation and vertical propagation behavior in laminated shale formation , 2017 .

[10]  Yiyu Lu,et al.  Surface characteristics and permeability enhancement of shale fractures due to water and supercritical carbon dioxide fracturing , 2018, Journal of Petroleum Science and Engineering.

[11]  Takashi Akai,et al.  Evaluation of stimulated reservoir volume in laboratory hydraulic fracturing with oil, water and liquid carbon dioxide under microscopy using the fluorescence method , 2018 .

[12]  Jie Xu,et al.  Experimental investigation on the characteristics of fractures initiation and propagation for gas fracturing by using air as fracturing fluid under true triaxial stresses , 2019, Fuel.

[13]  Yan Jin,et al.  A criterion for identifying hydraulic fractures crossing natural fractures in 3D space , 2014 .

[14]  R. Reedy,et al.  Comparison of water use for hydraulic fracturing for unconventional oil and gas versus conventional oil. , 2014, Environmental science & technology.

[15]  Yu-Shu Wu,et al.  CO2 injection-induced fracturing in naturally fractured shale rocks , 2017 .

[16]  Shangxian Yin,et al.  In-situ stresses controlling hydraulic fracture propagation and fracture breakdown pressure , 2018 .

[17]  Karin Ackermann,et al.  Mechanics Of Hydraulic Fracturing , 2016 .

[18]  Shicheng Zhang,et al.  Experimental study of hydraulic fracturing for shale by stimulated reservoir volume , 2014 .

[19]  Mark D. Zoback,et al.  Adsorption of methane and carbon dioxide on gas shale and pure mineral samples , 2014 .

[20]  R. Bell,et al.  The measurement and significance of energy in acoustic-emission testing , 1977 .

[21]  Natalie Lyon,et al.  Hydraulic Fracturing , 2018 .

[22]  R. Jackson,et al.  The effects of shale gas exploration and hydraulic fracturing on the quality of water resources in the United States , 2013 .

[23]  Yiwei Liu,et al.  Fracture Initiation of an Inhomogeneous Shale Rock under a Pressurized Supercritical CO2 Jet , 2017 .

[24]  J. P. Langlinais,et al.  Feasibility of supercritical carbon dioxide as a drilling fluid for deep underbalanced drilling operations , 2005 .

[25]  Xiuli Wang,et al.  The Shale Gas Potential of China , 2011 .

[26]  Xiao Li,et al.  A laboratory investigation of fracture propagation induced by supercritical carbon dioxide fracturing in continental shale with interbeds , 2018, Journal of Petroleum Science and Engineering.

[27]  Wang Yuanyuan,et al.  Effects of post-instability induced by supercritical CO2 phase change on fracture dynamic propagation , 2018 .

[28]  Yong Kang,et al.  Fracture initiation and propagation under different perforation orientation angles in supercritical CO2 fracturing , 2019 .

[29]  Norman R. Warpinski,et al.  Hydraulic-Fracture-Height Growth: Real Data , 2012 .

[30]  Andreas Busch,et al.  High-pressure methane and carbon dioxide sorption on coal and shale samples from the Paraná Basin, Brazil , 2010 .

[31]  Qiang Wang,et al.  Natural gas from shale formation – The evolution, evidences and challenges of shale gas revolution in United States , 2014 .

[32]  X. Long,et al.  A review of shale swelling by water adsorption , 2015 .

[33]  D. Pollard,et al.  Progress in understanding jointing over the past century , 1988 .

[34]  Z. Shicheng,et al.  Experimental Analysis of Hydraulic Fracture Growth and Acoustic Emission Response in a Layered Formation , 2018, Rock Mechanics and Rock Engineering.

[35]  T. Urbancic,et al.  Microseismic Imaging of Fracture Behavior in Naturally Fractured Reservoirs , 2002 .

[36]  C. Pearson,et al.  The relationship between microseismicity and high pore pressures during hydraulic stimulation experiments in low permeability granitic rocks , 1981 .

[37]  J. Ciezobka,et al.  Using microseismic frequency-magnitude distributions from hydraulic fracturing as an incremental tool for fracture completion diagnostics , 2019, Journal of Petroleum Science and Engineering.

[38]  Hari S. Viswanathan,et al.  CO2 as a fracturing fluid: Potential for commercial-scale shale gas production and CO2 sequestration☆ , 2014 .

[39]  Yiyu Lu,et al.  Experimental study on fracture initiation and propagation in shale using supercritical carbon dioxide fracturing , 2017 .

[40]  S. Laubach,et al.  Hydraulic Fractures in Core From Stimulated Reservoirs: Core Fracture Description of HFTS Slant Core, Midland Basin, West Texas , 2018 .

[41]  B. Mayer,et al.  Groundwater Protection and Unconventional Gas Extraction: The Critical Need for Field‐Based Hydrogeological Research , 2013, Ground water.

[42]  Tsuyoshi Ishida,et al.  Observations of Fractures Induced by Hydraulic Fracturing in Anisotropic Granite , 2015, Rock Mechanics and Rock Engineering.

[43]  Y. Pei,et al.  Flow in multi-scale discrete fracture networks with stress sensitivity , 2016 .

[44]  Xiaodong Zhang,et al.  Experimental and numerical study on the non-planar propagation of hydraulic fractures in shale , 2019, Journal of Petroleum Science and Engineering.

[45]  Michele L. Cooke,et al.  Fracture termination and step-over at bedding interfaces due to frictional slip and interface opening , 2001 .

[46]  Tomoya Niwa,et al.  Acoustic emission monitoring of hydraulic fracturing laboratory experiment with supercritical and liquid CO2 , 2012 .

[47]  D. Elsworth,et al.  Understanding induced seismicity , 2016, Science.