An experimental study on defrosting performance for an air source heat pump unit with a horizontally installed multi-circuit outdoor coil

When frost forms and accumulates over the outdoor coil’s surface in an air source heat pump (ASHP) unit, system operating performance will be dramatically deteriorated. Reverse cycle defrosting is the most widely used standard defrosting method. A previous related study reported that downwards flowing of melted frost due to gravity over a vertical multi-circuit outdoor coil would decrease the reverse cycle defrosting performance. If the outdoor coil can be changed to horizontally installed, the flow path of melted frost over coil surface can be shortened, and the flow directions of refrigerant and melted frost changed from opposite to orthogonal. Consequently, a better defrosting performance is expected. In this paper, therefore, an experimental study on defrosting performance for an ASHP unit with a horizontally installed multi-circuit outdoor coil was conducted. Experimental results show that, when a vertical outdoor coil was changed to horizontally installed, the defrosting efficiency increased 9.8%, however, with the same defrosting duration at 186s. Furthermore, when the outdoor air fan was reversed to blowing the melted frost during defrosting, the total mass of the retained water collected decreased 222g. However, the defrosting efficiency was not increased, but decreased 6.6% because of the heat transfer enhanced between hot coil and cold ambient air.

[1]  J.E.R. Coney,et al.  Experimental study of warm-air defrosting of heat-pump evaporators , 1993 .

[2]  Dennis L. O'Neal,et al.  Defrost cycle performance for an air-source heat pump with a scroll and a reciprocating compressor , 1995 .

[3]  James E. Braun,et al.  A hybrid method for refrigerant flow balancing in multi-circuit evaporators: Upstream versus downstream flow control , 2009 .

[4]  Wang Zhiyi,et al.  Defrost improvement by heat pump refrigerant charge compensating , 2008 .

[5]  K. Hambraeus.  Heat transfer of oil-contaminated HFC134a in a horizontal evaporator , 1995 .

[6]  Michele Bottarelli,et al.  Uncertainty-based analysis of variations in subsurface thermal field due to horizontal flat-panel heat exchangers , 2015 .

[7]  S. A. Sherif,et al.  Hot water defrosting of a horizontal flat plate cooling surface , 1983 .

[8]  Katsuyoshi Fukiba,et al.  Method for defrosting heat exchangers using an air-particle jet , 2015 .

[9]  Shiming Deng,et al.  An experimental study on defrosting heat supplies and energy consumptions during a reverse cycle defrost operation for an air source heat pump , 2012 .

[10]  Xiaosong Zhang,et al.  Experimental study of the effects of fin surface characteristics on defrosting behavior , 2015 .

[11]  Fernando Testoni Knabben,et al.  An experimental study on defrost heaters applied to frost-free household refrigerators , 2013 .

[12]  James R. Craig,et al.  Impact of soil heterogeneity on the functioning of horizontal ground heat exchangers , 2014 .

[13]  F. Jiang,et al.  Numerical investigation on prevention of fouling in the horizontal tube heat exchanger: Particle distribution and pressure drop , 2015 .

[14]  Sylvain Quoilin.  Experimental study and modeling of a low temperature Rankine Cycle for small scale cogeneration , 2007 .

[15]  Guanghua Xu,et al.  Experimental investigation on the defrosting performance of a finned-tube evaporator using intermittent ultrasonic vibration , 2015 .

[16]  Dongmei Pan,et al.  An experimental study on the effects of downwards flowing of melted frost over a vertical multi-circuit outdoor coil in an air source heat pump on defrosting performance during reverse cycle defrosting , 2014 .

[17]  Ning Li,et al.  An experimental study on the negative effects of downwards flow of the melted frost over a multi-circuit outdoor coil in an air source heat pump during reverse cycle defrosting , 2015 .

[18]  S. Suresh,et al.  Comparison of heat transfer and pressure drop in horizontal and vertical helically coiled heat exchanger with CuO/water based nano fluids , 2012 .

[19]  Xuedan Zhang,et al.  A review of heat pump systems for heating and cooling of buildings in China in the last decade , 2015 .

[20]  Zuiliang Ma,et al.  Field test investigation of a double-stage coupled heat pumps heating system for cold regions , 2005 .

[21]  Liang Xia,et al.  A semi-empirical modeling study on the defrosting performance for an air source heat pump unit with local drainage of melted frost from its three-circuit outdoor coil , 2014 .

[22]  Wenjin Wang,et al.  Investigation of defrosting water retention on the surface of evaporator impacting the performance of air source heat pump during periodic frosting–defrosting cycles , 2014 .

[23]  A. Adamson.  Physical chemistry of surfaces , 1960 .

[24]  Jaehong Kim,et al.  A combined Dual Hot-Gas Bypass Defrosting method with accumulator heater for an air-to-air heat pump in cold region , 2015 .

[25]  Zhao Li,et al.  An experimental study on the uneven refrigerant distribution over a vertically installed multi-circuit outdoor coil in an air source heat pump unit during reverse cycle defrosting , 2015 .

[26]  Minglu Qu,et al.  A study of the reverse cycle defrosting performance on a multi-circuit outdoor coil unit in an air source heat pump – Part I: Experiments , 2012 .

[27]  Shiming Deng,et al.  A study on the performance of the airside heat exchanger under frosting in an air source heat pump water heater/chiller unit , 2004 .

[28]  Xiaosong Zhang,et al.  Preliminary study of a novel defrosting method for air source heat pumps based on superhydrophobic fin , 2015 .

[29]  Takahisa Yamamoto,et al.  Design and testing of the Organic Rankine Cycle , 2001 .

[30]  Seung-Rae Lee,et al.  Evaluation of thermal efficiency in different types of horizontal ground heat exchangers , 2015 .

[31]  Deng Shiming,et al.  Experimental performance evaluation of a novel dry-expansion evaporator with defouling function in a wastewater source heat pump , 2012 .

[32]  M. J. Moran,et al.  Fundamentals of Engineering Thermodynamics , 2014 .

[33]  Xiaohua Xia,et al.  Optimal sampling plan for clean development mechanism energy efficiency lighting projects , 2013 .