Fabrication and characterization of fluorine-doped thin oxide thin films and nanorod arrays via spray pyrolysis

This paper reports the synthesis and characterization of fluorine-doped tin oxide (FTO) thin films via intermittent spray pyrolysis utilizing a solution mixture of tin chloride pentahydrate and ammonia fluoride. Utilizing the same solution, nanorod arrays were fabricated via template-based growth. Uniform and crack-free FTO films over 20×20 mm with a thickness up to 900 nm have been routinely achieved; such FTO films demonstrate electrical resistivity as low as 2.2×10-4 Ω cm as well as good optical transparency ranging from 75 to 85%. In addition, FTO nanorods were fabricated using template-filling methods at a temperature of 440 °C. The nanorods have a diameter of ∼160–250 nm, appear to be comprised of small nanoparticles 5–10 nm in size, and have a resistivity value of 4×10-1 Ω cm.

[1]  J. Thornton.  High Rate Thick Film Growth , 1977 .

[2]  V. Dutta,et al.  Electrical and optical properties of tin oxide films doped with F and (Sb+F) , 1982 .

[3]  S. Major,et al.  Effect of heavy doping in SnO2:F films , 1996, Journal of Materials Science.

[4]  G. C. Morris,et al.  Fluorine doped tin oxide films from spray pyrolysis of stannous fluoride solutions , 1996 .

[5]  P. Ramasamy,et al.  Effect of fluorine doping on structural, electrical and optical properties of sprayed SnO2 thin films , 1998 .

[6]  P. Ramasamy,et al.  Preparation and properties of sprayed undoped and fluorine doped tin oxide films , 1999 .

[7]  N. Ono,et al.  Electron trapping center and SnO2-doping mechanism of indium tin oxide , 2000 .

[8]  Yiying Wu,et al.  Room-Temperature Ultraviolet Nanowire Nanolasers , 2001, Science.

[9]  C. Lieber,et al.  Nanowire Nanosensors for Highly Sensitive and Selective Detection of Biological and Chemical Species , 2001, Science.

[10]  Xiangfeng Duan,et al.  Highly Polarized Photoluminescence and Photodetection from Single Indium Phosphide Nanowires , 2001, Science.

[11]  K. Choy,et al.  Electrostatic spray assisted vapour deposition of fluorine doped tin oxide , 2001 .

[12]  Guanghou Wang,et al.  Preparation of SnO2 nanorods by annealing SnO2 powder in NaCl flux , 2002 .

[13]  K. Chattopadhyay,et al.  Synthesis and Characterization of Nano-Crystalline Fluorine-Doped Tin Oxide Thin Films by Sol-Gel Method , 2003 .

[14]  T. Kawashima,et al.  New transparent conductive films: FTO coated ITO , 2003 .

[15]  S. Kashyap,et al.  Thin Fluorine-Doped Tin Oxide Films Prepared Using an Electric Field-Modified Spray Pyrolysis Deposition Technique , 2004 .

[16]  S. Limmer,et al.  Films and nanorods of transparent conducting oxide ITO by a citric acid sol route , 2004 .

[17]  J. Lee,et al.  Molten Salt Synthesis of Tin Oxide Nanorods: Morphological and Electrochemical Features , 2004 .

[18]  H. Hashizume,et al.  Ionization potentials of transparent conductive indium tin oxide films covered with a single layer of fluorine-doped tin oxide nanoparticles grown by spray pyrolysis deposition , 2005 .

[19]  Peidong Yang,et al.  Nanowire dye-sensitized solar cells , 2005, Nature materials.

[20]  Pu Chen,et al.  Gold nanotube membranes: Preparation, characterization and application for enantioseparation , 2005 .

[21]  W. Park,et al.  ZnO Nanorod Logic Circuits , 2005, Advanced materials.

[22]  E. Elangovan,et al.  A study on low cost-high conducting fluorine and antimony-doped tin oxide thin films , 2005 .

[23]  Y. C. Lee,et al.  Semiconductor gas sensor based on tin oxide nanorods prepared by plasma-enhanced chemical vapor deposition with postplasma treatment , 2005 .

[24]  S. Luo,et al.  Effective creation of oxygen vacancies as an electron carrier source in tin-doped indium oxide films by plasma sputtering , 2006 .

[25]  Susumu Yoshikawa,et al.  Doubled layered ITO/SnO2 conducting glass for substrate of dye-sensitized solar cells , 2006 .

[26]  S. Yoshikawa,et al.  High-Efficiency Dye-Sensitized Solar Cell Based on ZnO Nanorod Arrays Electrode , 2006 .

[27]  Q. Qiao,et al.  A comparison of fluorine tin oxide and indium tin oxide as the transparent electrode for P3OT/TiO2 solar cells , 2006 .

[28]  G. Cao,et al.  Fabrication and Li+-intercalation properties of V2O5-TiO2 composite nanorod arrays , 2006 .

[29]  Y. J. Kim,et al.  Growth and Characterization of [001] ZnO Nanorod Array on ITO Substrate with Electric Field Assisted Nucleation , 2006 .

[30]  Kenji Murakami,et al.  Large area dye‐sensitized solar cells: material aspects of fabrication , 2006 .