Sliding Mode and Neural Network Control of Sensorless PMSM Controlled System for Power Consumption and Performance Improvement

This paper deals with the design of sliding mode control and neural network compensation for a sensorless permanent magnet synchronous motor (PMSM) controlled system that is able to improve both power consumption and speed response performance. The position sensor of PMSM is unreliable in harsh environments. Therefore, the sensorless control technique is widely proposed in industry. A sliding mode observer can estimate the rotor angle and has the robustness to load disturbance and parameter variations. However, the sliding mode observer is not conducive to standstill and low speed conditions because the amplitude of the back EMF is almost zero. As a result, this paper combines an iterative sliding mode observer (ISMO) and neural networks (NNs) as an angle compensator to improve the above problems. A dsPIC30F6010A-based PMSM sensorless drive system is implemented to validate the proposed algorithm. The simulation and experimental results prove its effectiveness.

[1]  Han Ho Choi,et al.  Online Parameter Identification for Model-Based Sensorless Control of Interior Permanent Magnet Synchronous Machine , 2017, IEEE Transactions on Power Electronics.

[2]  Antonella Ferrara,et al.  Switched/time-based adaptation for second-order sliding mode control , 2016, Autom..

[3]  Jangmyung Lee,et al.  A High-Speed Sliding-Mode Observer for the Sensorless Speed Control of a PMSM , 2011, IEEE Transactions on Industrial Electronics.

[4]  Liu Sheng,et al.  Robust Adaptive Backstepping Sliding Mode Control for Six-Phase Permanent Magnet Synchronous Motor Using Recurrent Wavelet Fuzzy Neural Network , 2017, IEEE Access.

[5]  Z. Q. Zhu,et al.  Novel Sensorless Control Strategy With Injection of High-Frequency Pulsating Carrier Signal Into Stationary Reference Frame , 2014, IEEE Transactions on Industry Applications.

[6]  Syuan-Yi Chen,et al.  Intelligent tracking control of a PMLSM using self-evolving probabilistic fuzzy neural network , 2017 .

[7]  P. Tomei,et al.  Observer-based speed tracking control for sensorless permanent magnet synchronous motors with unknown load torque , 2010, The XIX International Conference on Electrical Machines - ICEM 2010.

[8]  Hasan Komurcugil,et al.  Optimized Sliding Mode Control to Maximize Existence Region for Single-Phase Dynamic Voltage Restorers , 2016, IEEE Transactions on Industrial Informatics.

[9]  Paolo Mercorelli,et al.  An Antisaturating Adaptive Preaction and a Slide Surface to Achieve Soft Landing Control for Electromagnetic Actuators , 2012, IEEE/ASME Transactions on Mechatronics.

[10]  Z. Q. Zhu,et al.  Investigation of Effectiveness of Sensorless Operation in Carrier-Signal-Injection-Based Sensorless-Control Methods , 2011, IEEE Transactions on Industrial Electronics.

[11]  Paolo Mercorelli,et al.  A Two-Stage Sliding-Mode High-Gain Observer to Reduce Uncertainties and Disturbances Effects for Sensorless Control in Automotive Applications , 2015, IEEE Transactions on Industrial Electronics.

[12]  Zebin Yang,et al.  High-Performance Control for a Bearingless Permanent-Magnet Synchronous Motor Using Neural Network Inverse Scheme Plus Internal Model Controllers , 2016, IEEE Transactions on Industrial Electronics.

[13]  Kai-Jie Yang,et al.  Recurrent Fuzzy Neural Cerebellar Model Articulation Network Fault-Tolerant Control of Six-Phase Permanent Magnet Synchronous Motor Position Servo Drive , 2016, IEEE Transactions on Fuzzy Systems.

[14]  P. D. Shendge,et al.  Sliding Mode Control for Mismatched Uncertain Systems Using an Extended Disturbance Observer , 2014, IEEE Transactions on Industrial Electronics.

[15]  Paolo Mercorelli,et al.  Global Finite-Time Stabilization of Planar Linear Systems With Actuator Saturation , 2017, IEEE Transactions on Circuits and Systems II: Express Briefs.

[16]  Yeng Chai Soh,et al.  High-Gain Observers With Sliding Mode for State and Unknown Input Estimations , 2009, IEEE Transactions on Industrial Electronics.

[17]  Hyun Lee,et al.  Design of Iterative Sliding Mode Observer for Sensorless PMSM Control , 2013, IEEE Transactions on Control Systems Technology.

[18]  A. Piippo,et al.  Sensorless control of PMSM drives using a combination of voltage model and HF signal injection , 2004, Conference Record of the 2004 IEEE Industry Applications Conference, 2004. 39th IAS Annual Meeting..

[19]  Vivek Sharma,et al.  Disturbance observer based sliding mode control for anti-lock braking system , 2016, 2016 IEEE 1st International Conference on Power Electronics, Intelligent Control and Energy Systems (ICPEICES).

[20]  Paolo Mercorelli,et al.  A Robust Adaptive Self-tuning Sliding Mode Control for a Hybrid Actuator in Camless Internal Combustion Engines , 2015, Advances and Applications in Sliding Mode Control Systems.

[21]  Xiangning He,et al.  New Sliding-Mode Observer for Position Sensorless Control of Permanent-Magnet Synchronous Motor , 2013, IEEE Transactions on Industrial Electronics.

[22]  Radu-Emil Precup,et al.  Model-free sliding mode control of nonlinear systems: Algorithms and experiments , 2017, Inf. Sci..

[23]  Luis Martinez-Salamero,et al.  Sliding-Mode-Control-Based Boost Converter for High-Voltage–Low-Power Applications , 2015, IEEE Transactions on Industrial Electronics.

[24]  Young Ahn Kwon,et al.  Sensorless Speed Control of Permanent Magnet Synchronous Motor by Unscented Kalman Filter using Various Scaling Parameters , 2016 .

[25]  Bernhard Piepenbreier,et al.  HF Test Current Injection-Based Self-Sensing Control of PMSM for Low- and Zero-Speed Range Using Two-Degree-of-Freedom Current Control , 2015, IEEE Transactions on Industry Applications.

[26]  R. Wu,et al.  A permanent magnet motor drive without a shaft sensor , 1990, Conference Record of the 1990 IEEE Industry Applications Society Annual Meeting.

[27]  Paul Waide,et al.  Energy-Efficiency Policy Opportunities for Electric Motor-Driven Systems , 2011 .

[28]  Ming-Shyan Wang,et al.  Sensorless Speed Control of Permanent Magnet Synchronous Motors by Neural Network Algorithm , 2014 .

[29]  Paolo Mercorelli,et al.  Hysteresis Analysis and Control of a Metal-Polymer Hybrid Soft Actuator , 2017 .