Classification and characterisation of SRF produced from different flows of processed MSW in the Navarra region and its co-combustion performance with olive tree pruning residues.

Abstract The scope of this work is to study the co-combustion of a solid recovered fuel (SRF) produced from household wastes and packaging wastes recovered from selective collection (SC) in the autonomous community of Navarra, located in the northeast of Spain. The municipal solid waste (MSW) is subjected to a mechanical biological treatment (MBT) in order to stabilize the organic matter and recover the recyclable materials as it is done for packaging wastes. Afterwards, rejects from this treatment plant were preconditioned and compressed by a pelletizing process to produce a secondary fuel according to quality and classification criteria of EN 15359, producing the so-called SRF. A fuel characterisation was carried out according to CEN standards and the SRF was classified as follows: NCV 2; Cl 3; Hg 1. SRF pellets were cofired with residual biomass pellets from olive tree pruning (OTP) in a bubbling fluidised bed combustor, as an option of energy recovery. The mixture of fuels, with a mixing ratio close to 50% by weight, showed a significant calorific value of 18.25 MJ/kg at 8% of moisture content. In addition, elemental composition of the mixture based on nitrogen (N), sulphur (S) and chlorine (Cl) (1% N, 0.2% S and 0.4% Cl) was not far from some herbaceous biomasses. The co-combustion showed good results as an energy recovery technology because of the synergies of both fuels, improving notably the combustion conditions and reducing significantly CO concentration, regarding to the combustion of OTP, though other contaminants such as NO x and HCl increased. During eight hours of stable operation, the concentration of dioxins and furans was measured obtaining a value of 7.68 ng/Nm 3 (toxic equivalence: i-TEQ of 0.33 ng/Nm 3 ). Proportions of SRF lower than 50% in the mixtures should be tested in order to cut down the emissions of these pollutants, or an abatement system for organochloride compounds may be required.

[1]  Bo Leckner,et al.  Process aspects in combustion and gasification Waste-to-Energy (WtE) units. , 2015, Waste management.

[2]  Rainer Rehn,et al.  Solid Recovered Fuel , 2008 .

[3]  Sanjeev Maken,et al.  Gasification of municipal solid waste in a pilot plant and its impact on environment , 2006 .

[4]  Elena Cristina Rada,et al.  RDF/SRF: which perspective for its future in the EU. , 2012, Waste management.

[5]  Elena Cristina Rada,et al.  Selective collection as a pretreatment for indirect solid recovered fuel generation. , 2014, Waste management.

[6]  Elena Cristina Rada,et al.  ECONOMIC VIABILITY OF SRF CO-COMBUSTION IN CEMENT FACTORY , 2014 .

[7]  P. Lehtikangas.  Quality properties of pelletised sawdust, logging residues and bark , 2001 .

[8]  F. Pinto,et al.  Gasification improvement of a poor quality solid recovered fuel (SRF). Effect of using natural minerals and biomass wastes blends , 2014 .

[9]  V. Sharifi,et al.  Combustion of refuse-derived fuel in a fluidised bed , 2007 .

[10]  M. Llorente,et al.  Comparing methods for predicting the sintering of biomass ash in combustion , 2005 .

[11]  Simon J T Pollard,et al.  The biogenic content of process streams from mechanical-biological treatment plants producing solid recovered fuel. Do the manual sorting and selective dissolution determination methods correlate? , 2010, Waste management.

[12]  Sònia Abelló,et al.  Volatilization characteristics of solid recovered fuels (SRFs) , 2013 .

[13]  Chettiyappan Visvanathan,et al.  Recovery of plastic wastes from dumpsite as refuse-derived fuel and its utilization in small gasification system. , 2010, Bioresource technology.

[14]  Qunwu Huang,et al.  Thermogravimetric analysis and kinetics of coal/plastic blends during co-pyrolysis in nitrogen atmosphere , 2008 .

[15]  J. F. González,et al.  Thermogravimetric study of the pyrolysis of biomass residues from tomato processing industry , 2006 .

[16]  Günter Scheffknecht,et al.  Ash fusibility and compositional data of solid recovered fuels , 2010 .

[17]  Umberto Arena,et al.  Energy generation by air gasification of two industrial plastic wastes in a pilot scale fluidized bed reactor , 2014 .

[18]  Simonetta Tunesi,et al.  LCA of local strategies for energy recovery from waste in England, applied to a large municipal flow. , 2011, Waste management.

[19]  Umberto Arena,et al.  Process and technological aspects of municipal solid waste gasification. A review. , 2012, Waste management.

[20]  P J Longhurst,et al.  Comparison of coal/solid recovered fuel (SRF) with coal/refuse derived fuel (RDF) in a fluidized bed reactor. , 2011, Waste management.

[21]  R. Newman.  Promotion of the use of energy from renewable sources , 2014 .

[22]  George Tchobanoglous,et al.  Municipal Solid Waste and the Environment: A Global Perspective , 2012 .

[23]  Andrea Corti,et al.  A review of technologies and performances of thermal treatment systems for energy recovery from waste. , 2015, Waste management.

[24]  A. Bahillo,et al.  Trace metals removal through a catalytic hybrid filter during cofiring of different biomass waste materials , 2015 .

[25]  M Morris,et al.  Energy recovery from solid waste fuels using advanced gasification technology , 1998 .

[26]  S. Karellas,et al.  The solid recovered fuel Stabilat®: Characteristics and fluidised bed gasification tests , 2012 .

[27]  Michalis Agraniotis,et al.  Refuse-derived fuel classification in a mechanical–biological treatment plant and its valorization with techno-economic criteria , 2014, International Journal of Environmental Science and Technology.

[28]  L. Helsen,et al.  The crucial role of Waste-to-Energy technologies in enhanced landfill mining: a technology review , 2013 .

[29]  Frank Schultmann,et al.  Municipal solid waste and production of substitute natural gas and electricity as energy alternatives , 2013 .

[30]  Vincenzo Torretta,et al.  The mass and energy balance of an integrated solution for municipal solid waste treatment , 2014 .

[31]  Nor Asiah Muhamad,et al.  Solid waste as a renewable feedstock: A review , 2014 .

[32]  P. Basu.  Combustion and gasification in fluidized beds , 2006 .

[33]  F. Sepúlveda,et al.  Characterization and combustion behaviour of commercial and experimental wood pellets in South West Europe , 2015 .

[34]  Elena Cristina Rada.  Biodegradability of Landfilled MSW in EU: Past, Present and Future , 2012 .

[35]  R. Sarc,et al.  Production, quality and quality assurance of Refuse Derived Fuels (RDFs). , 2013, Waste management.

[36]  E. C. Rada,et al.  Energy from municipal solid waste , 2014 .

[37]  Jin-Won Park,et al.  Surface emission of landfill gas from solid waste landfill , 2001 .

[38]  N. Stanley Harding,et al.  Characteristics of Alternative Fuels , 2008 .

[39]  Harvey Alter.  The history of refuse-derived fuels , 1987 .