A novel type of dynamic controlled atmosphere storage based on the respiratory quotient (RQ-DCA)

Abstract A novel type of dynamic controlled atmosphere storage (RQ-DCA) was developed to control O 2 and CO 2 partial pressures in storage containers for apple fruit automatically, based on measurements of the stored fruit respiratory quotient (RQ). ‘Granny Smith’ apples were stored under RQ-DCA and the effect on fruit quality immediately after storage as well as during subsequent shelf life was investigated and compared to the effect of regular CA and regular CA storage with 1-MCP (SmartFresh SM ) treatment. The RQ-DCA system managed to control O 2 and CO 2 partial pressures in the storage container in an autonomous way. During RQ-DCA storage, the RQ breakpoint was found to vary between 0.25 kPa and 0.4 kPa O 2 . However, difficulties to obtain a reliable RQ measurement were observed at very low oxygen levels due to reduced fruit respiration and when the pressure of the storage container increases due to increased atmosphere pressure due to leakiness of the storage container. Superficial scald was found to be controlled almost completely during storage with RQ-DCA and the effect remained visible during up to 14 days of shelf life. Magness-Taylor firmness and skin color (hue angle) were found to be significantly higher after RQ-DCA storage compared to conventional CA storage and were comparable to these of fruit stored with regular CA after 1-MCP treatment up to 7 days of shelf life at 18 °C. In-fruit ethanol concentrations were found to be very low ( −1 ), indicating the RQ-DCA system managed to store the fruit close to the anaerobic compensation point but the fruit metabolism did not shift from aerobic respiration to fermentation.

[1]  P. Harrison,et al.  A New Technology That Determines Low-oxygen Thresholds in Controlled-atmosphere-stored Apples , 2004 .

[2]  Angelo Zanella,et al.  Fruit fluorescence response to low oxygen stress : Modern storage technologies compared to 1-MCP treatment of apple , 2005 .

[3]  D. Dilley,et al.  Initial low oxygen stress controls superficial scald of apples , 2000 .

[4]  P. Verboven,et al.  Controlled atmosphere storage may lead to local ATP deficiency in apple , 2013 .

[5]  R. Beaudry,et al.  Determination of the low oxygen limit for several commercial apple cultivars by respiratory quotient breakpoint , 1993 .

[6]  Donald J. Cleland,et al.  Determination of lower oxygen limits for apple fruit , 1996 .

[7]  Edna Pesis,et al.  The role of the anaerobic metabolites, acetaldehyde and ethanol, in fruit ripening, enhancement of fruit quality and fruit deterioration , 2005 .

[8]  Christopher B. Watkins,et al.  Superficial scald, its etiology and control , 2012 .

[9]  O. Feygenberg,et al.  Low oxygen and 1-MCP pretreatments delay superficial scald development by reducing reactive oxygen species (ROS) accumulation in stored ‘Granny Smith’ apples , 2011 .

[10]  Christopher B. Watkins,et al.  Superficial Scald of `Granny Smith' Apples is Expressed as a Typical Chilling Injury , 1995 .

[11]  C. Wang,et al.  Modified atmosphere packaging of fruits and vegetables. , 1989, Critical reviews in food science and nutrition.

[12]  C. Watkins.  POSTHARVEST RIPENING REGULATION AND INNOVATION IN STORAGE TECHNOLOGY , 2008 .

[13]  P. Harrison,et al.  The effect of temperature and other factors on chlorophyll a fluorescence and the lower oxygen limit in apples (Malus domestica) , 2010 .

[14]  P. Harrison,et al.  Innovation in controlled atmosphere technology , 2005 .

[15]  D. Dilley.  Controlled atmosphere storage - chronology and technology. , 2010 .

[16]  Bart Nicolai,et al.  Kinetic modeling of firmness breakdown in ‘Braeburn’ apples stored under different controlled atmosphere conditions , 2012 .

[17]  Bart Nicolai,et al.  Browning disorders in pear fruit , 2007 .

[18]  Susana C. Fonseca,et al.  Modelling respiration rate of fresh fruits and vegetables for modified atmosphere packages: a review , 2002 .

[19]  M. Knee,et al.  A comparison of methods for measuring the volatile components of apple fruits , 1976 .

[20]  Robert K. Prange,et al.  Chlorophyll fluorescence of Delicious apples at harvest as a potential predictor of superficial scald development during storage , 1996 .

[21]  M. E. Patterson,et al.  Ethanol Accumulation and Poststorage Quality of ‘Delicious’ Apples During Short-term, Low-O2, CA Storage , 1987, HortScience.

[22]  J. Abbott.  Quality measurement of fruits and vegetables , 1999 .

[23]  A. Zanella.  Control of apple superficial scald and ripening: a comparison between 1-methylcyclopropene and diphenylamine postharvest treatments, initial low oxygen stress and ultra low oxygen storage , 2003 .

[24]  Mikal E. Saltveit,et al.  Is it possible to find an optimal controlled atmosphere , 2003 .

[25]  P. Geigenberger,et al.  Response of plant metabolism to too little oxygen. , 2003, Current opinion in plant biology.

[26]  Denis Flick,et al.  Modelling transport phenomena in refrigerated food bulks, packages and stacks: basics and advances , 2006 .

[27]  J. Dole,et al.  1-Methylcyclopropene: a review , 2003 .

[28]  J. Delong,et al.  Dynamic controlled atmosphere (DCA): Does fluorescence reflect physiology in storage? , 2012 .

[29]  R. Wagner,et al.  Effect of storage under extremely low oxygen on the volatile composition of 'Royal Gala' apples. , 2014, Food chemistry.

[30]  P. Harrison,et al.  Oxygen concentration affects chlorophyll fluorescence in chlorophyll-containing fruit , 2002 .

[31]  L.M.M. Tijskens,et al.  Determination of O2 and CO2 permeance, internal respiration and fermentation for a batch of pears (cv. Conference) , 2004 .

[32]  F. Gasser,et al.  Fruit quality as affected by 1-MCP treatment and DCA storage - a comparison of the two methods , 2015 .

[33]  S. Blankenship,et al.  Development of apple superficial scald, soft scald, core flush, and greasiness is reduced by MCP. , 1999, Journal of agricultural and food chemistry.

[34]  Maarten Hertog,et al.  The effect of modified atmospheres on the rate of firmness change in ‘Braeburn’ apples , 2001 .

[35]  N. Banks,et al.  Effect of carbon dioxide on the internal lower oxygen limits of apple fruit , 1997 .

[36]  R. F. Testin,et al.  The Anaerobic Compensation Point for Fresh-cut Watermelon and Implications for Postprocess Handling , 2004 .

[37]  C. Watkins,et al.  Controlled-atmosphere Storage of ‘Honeycrisp’ Apples , 2012 .

[38]  X. Chai,et al.  Henry's constants of n-alkanols (methanol through n-hexanol) in water at temperatures between 40°C and 90°C , 2000 .

[39]  J. Verschoor,et al.  Improvement of quality of Elstar apples by dynamic control of ULO conditions , 1998 .

[40]  Anne White,et al.  An apple a day: the influence of memory on consumer judgment of quality , 2002 .

[41]  A. Zanella,et al.  Post-harvest retention of apple fruit firmness by 1-methylcyclopropene (1-MCP) treatment or dynamic CA storage with chlorophyll fluorescence (DCA-CF) , 2015 .

[42]  J. Verschoor,et al.  Dynamic control system (DCS) for apples (Malus domestica Borkh. cv 'Elstar'): optimal quality through storage based on product response , 2003 .

[43]  Andreas Winkler,et al.  Structural and physiological changes associated with the skin spot disorder in apple , 2012 .

[44]  E. Mitcham,et al.  Superficial scald susceptibility and α-farnesene metabolism in ‘Bartlett’ pears grown in California and Washington , 2009 .

[45]  A. Brackmann,et al.  Dynamic controlled atmosphere and ultralow oxygen storage on 'Gala' mutants quality maintenance. , 2015, Food chemistry.

[46]  M. Hertog,et al.  Metabolomic change precedes apple superficial scald symptoms. , 2009, Journal of agricultural and food chemistry.

[47]  A. Güneyli,et al.  Effects of controlled atmosphere, dynamic controlled atmosphere and 1-MCP on quality of 'Granny Smith' apples. , 2015 .

[48]  P. Verboven,et al.  Genotype effects on internal gas gradients in apple fruit. , 2010, Journal of experimental botany.

[49]  Franz Gasser,et al.  CONTROL OF THE CRITICAL OXYGEN LEVEL DURING DYNAMIC CA STORAGE OF APPLES BY MONITORING RESPIRATION AS WELL AS CHLOROPHYLL FLUORESCENCE , 2008 .

[50]  E. Ögren.  Evaluation of chlorophyll fluorescence as a probe for drought stress in willow leaves. , 1990 .

[51]  L. Rodríguez-Sinobas,et al.  Physiology and Prediction of Fruit Tolerance to Low-oxygen Atmospheres , 1991 .