The experimental research on microtube heat transfer and fluid flow of distilled water

Abstract The experimental and numerical research on microchannel heat transfer and fluid flow was presented in the paper. Diameters of the microtubes were 0.1, 0.3 and 0.5 mm and the flow regime was laminar with Re -number range up to 800. The working fluid was distilled water and the tube material was stainless steel. The experimental setup was designed in such a way that the investigation of the average friction factor and developing heat transfer was possible. Due to the large scattering in the reported experimental results, the scope of this research was to make the accurate measurements and to compare the experimental heat transfer and fluid flow characteristics with numerical and theoretical results for the conventional tubes.

[1]  G. Peterson,et al.  Experimental investigation of heat transfer in flat plates with rectangular microchannels , 1995 .

[2]  Darwin R. Reyes,et al.  Micro total analysis systems. 1. Introduction, theory, and technology. , 2002, Analytical chemistry.

[3]  J. M. Coulson,et al.  Heat Transfer , 2018, Finite Element Method for Solids and Structures.

[4]  Darwin R. Reyes,et al.  Micro Total Analysis Systems , 2002 .

[5]  Gian Piero Celata,et al.  EXPERIMENTAL INVESTIGATION OF HYDRAULIC AND SINGLE-PHASE HEAT TRANSFER IN 0.130-MM CAPILLARY TUBE , 2002, Proceeding of Heat Transfer and Transport Phenomena in Microscale.

[6]  Thomas L. Daugherty,et al.  Friction Characteristics of Water-Lubricated Stave Bearings. , 1980 .

[7]  R. Shah.  Laminar Flow Forced convection in ducts , 1978 .

[8]  Chang-Jin Kim,et al.  Addressable micro liquid handling by electric control of surface tension , 2001, Technical Digest. MEMS 2001. 14th IEEE International Conference on Micro Electro Mechanical Systems (Cat. No.01CH37090).

[9]  R. J. Moffat,et al.  Contributions to the Theory of Single-Sample Uncertainty Analysis , 1982 .

[10]  G. Peterson,et al.  Convective heat transfer and flow friction for water flow in microchannel structures , 1996 .

[11]  Dongqing Li,et al.  Flow characteristics of water through a microchannel between two parallel plates with electrokinetic effects , 1997 .

[12]  R. Moffat.  Using Uncertainty Analysis in the Planning of an Experiment , 1985 .

[13]  Dongqing Li,et al.  Heat transfer for water flow in trapezoidal silicon microchannels , 2000 .

[14]  Chia-Jung Hsu.  Numerical Heat Transfer and Fluid Flow , 1981 .

[15]  A. Berg,et al.  Micro Total Analysis Systems , 1995 .

[16]  G. Peterson,et al.  The effect of thermofluid and geometrical parameters on convection of liquids through rectangular microchannels , 1995 .

[17]  Chien-Yuh Yang,et al.  FRICTION CHARACTERISTICS OF WATER, R-134a, AND AIR IN SMALL TUBES , 2003, Proceeding of Heat Transfer and Transport Phenomena in Microscale.

[18]  X. Peng,et al.  Forced convection heat transfer of single-phase binary mixtures through microchannels☆ , 1996 .