Polysulfone/silica nanoparticle mixed-matrix membranes for gas separation

Abstract Mixed-matrix membranes (MMMs) are based on polymeric membranes filled with inorganic particles as a means to improve their gas separation performance. In this study, MMMs were prepared from polysulfone (PSf) containing embedded nonporous fumed silica nanoparticles and the gas permeation properties of the resulting membranes were investigated. Physical properties such as film density, thermal degradation and glass transition temperature of PSf/silica MMMs were characterized. The distribution of the silica nanoparticles in PSf was observed by transmission electron microscopy (TEM) and scanning electron microscopy (SEM). Furthermore, the interface between the polymer and silica agglomerates was studied in relation with the gas transport properties. The gas permeabilities of hydrogen, helium, oxygen, nitrogen, methane, and carbon dioxide were measured as a function of silica volume fraction and diffusion and solubility coefficients were determined by the time-lag method. The effect of silica nanoparticles in PSf membranes on gas permeability is in contrast with predictions based on the Maxwell model. The O2 permeability is approximately four times higher and CH4 permeability is over five times greater than in a pure PSf membrane. However, the performance comprising permeability versus selectivity of PSf/silica MMMs for O2/N2 and CO2/CH4 follows a similar slope to that of the trade-off upper bound with increasing silica content.

[1]  William J. Koros,et al.  Membrane-based gas separation , 1993 .

[2]  William J. Koros,et al.  Tailoring mixed matrix composite membranes for gas separations , 1997 .

[3]  Yi Li,et al.  MIXED MATRIX MEMBRANES (MMMS) COMPRISING ORGANIC POLYMERS WITH DISPERSED INORGANIC FILLERS FOR GAS SEPARATION , 2007 .

[4]  W. Koros,et al.  Gas transport properties of polysulphones: 1. Role of symmetry of methyl group placement on bisphenol rings , 1991 .

[5]  W. Koros,et al.  Effect of structural symmetry on gas transport properties of polysulfones , 1992 .

[6]  T. M. Gür.  Permselectivity of zeolite filled polysulfone gas separation membranes , 1994 .

[7]  B. Freeman,et al.  Transport of Gases and Vapors in Glassy and Rubbery Polymers , 2006 .

[8]  William J. Koros,et al.  Mixed matrix membranes using carbon molecular sieves: I. Preparation and experimental results , 2003 .

[9]  C. Cornelius,et al.  Hybrid silica-polyimide composite membranes: Gas transport properties , 2002 .

[10]  B. Freeman,et al.  Effect of Basic Substituents on Gas Sorption and Permeation in Polysulfone , 1996 .

[11]  W. Koros,et al.  Non-ideal effects in organic-inorganic materials for gas separation membranes , 2005 .

[12]  A. Chakrabarti.  Effects of a fumed silica network on kinetics of phase separation in polymer blends , 1999 .

[13]  A. Bondi.  van der Waals Volumes and Radii , 1964 .

[14]  S. Mullens,et al.  Silica filled poly(1-trimethylsilyl-1-propyne) nanocomposite membranes : Relation between the transport of gases and structural characteristics , 2006 .

[15]  J. Maxwell.  A Treatise on Electricity and Magnetism , 1873, Nature.

[16]  L. Robeson,et al.  High performance polymers for membrane separation , 1994 .

[17]  Benny D. Freeman,et al.  Basis of Permeability/Selectivity Tradeoff Relations in Polymeric Gas Separation Membranes , 1999 .

[18]  G. G. Stokes.  "J." , 1890, The New Yale Book of Quotations.

[19]  S. A. Stern,et al.  Polymers for gas separations: the next decade , 1994 .

[20]  D. G. Pye,et al.  Measurement of gas permeability of polymers. I. Permeabilities in constant volume/variable pressure apparatus , 1976 .

[21]  J. Westwater,et al.  The Mathematics of Diffusion. , 1957 .

[22]  S. S. Sternstein,et al.  Reinforcement Mechanism of Nanofilled Polymer Melts As Elucidated by Nonlinear Viscoelastic Behavior , 2002 .

[23]  S. Takahashi,et al.  Gas permeation in poly(ether imide) nanocomposite membranes based on surface-treated silica. Part 1: Without chemical coupling to matrix , 2006 .

[24]  Anita J. Hill,et al.  Sorption and Transport in Poly(2,2-bis(trifluoromethyl)-4,5-difluoro-1,3-dioxole-co-tetrafluoroethylene) Containing Nanoscale Fumed Silica , 2003 .

[25]  W. Koros,et al.  Gas transport properties of thin polymeric membranes in the presence of silicon dioxide particles , 1997 .

[26]  Stephen J. Miller,et al.  Mixed matrix membranes using carbon molecular sieves: II. Modeling permeation behavior , 2003 .

[27]  Stephen J. Miller,et al.  Effect of condensable impurity in CO2/CH4 gas feeds on performance of mixed matrix membranes using carbon molecular sieves , 2003 .

[28]  Benny D. Freeman,et al.  Gas separation using polymer membranes: an overview , 1994 .

[29]  L. Choplin,et al.  Model development for the description of silica particles dispersion in silicone polymer , 2006 .

[30]  Anita J. Hill,et al.  Sorption, Transport, and Structural Evidence for Enhanced Free Volume in Poly(4-methyl-2-pentyne)/Fumed Silica Nanocomposite Membranes , 2003 .

[31]  L. Robeson,et al.  Correlation of separation factor versus permeability for polymeric membranes , 1991 .

[32]  Anita J. Hill,et al.  Effect of Nanoparticles on Gas Sorption and Transport in Poly(1-trimethylsilyl-1-propyne) , 2003 .

[33]  J. A. Barrie,et al.  Time lag in diffusion , 1986 .

[34]  Sangil Kim,et al.  Polysulfone and functionalized carbon nanotube mixed matrix membranes for gas separation: Theory and experiment , 2007 .

[35]  I. Pinnau,et al.  Nanostructured poly(4-methyl-2-pentyne)/silica hybrid membranes for gas separation☆ , 2002 .

[36]  R. Baker.  Membrane Technology and Applications , 1999 .

[37]  Huanting Wang,et al.  Homogeneous polymer–zeolite nanocomposite membranes by incorporating dispersible template-removed zeolite nanocrystals , 2002 .

[38]  V. Bondar,et al.  Sorption of gases and vapors in an amorphous glassy perfluorodioxole copolymer , 1999 .

[39]  W. Koros,et al.  A new technique for the measurement of multicomponent gas transport through polymeric films , 1986 .

[40]  D. G. Pye,et al.  Measurement of gas permeability of polymers. II. Apparatus for determination of permeabilities of mixed gases and vapors , 1976 .

[41]  J. G. Wijmans,et al.  The solution-diffusion model: a review , 1995 .

[42]  A. J. Hill,et al.  Ultrapermeable, Reverse-Selective Nanocomposite Membranes , 2002, Science.