A composite of polyelectrolyte-grafted multi-walled carbon nanotubes and in situ polymerized polyaniline for the detection of low concentration triethylamine vapor

Multi-walled carbon nanotubes (MWNTs) grafted with sodium polystyrenesulfonate (NaPSS) were deposited on an interdigitated gold electrode decorated with a layer of positively charged poly(diallyldimethylammonium chloride) by a self-assembly method. Then polyaniline (PANI) was in situ polymerized on the surface of the MWNTs to prepare a composite. The structure and morphology of the composite were investigated by Raman spectroscopy and scanning electron microscopy. The electrical responses of the composite to triethylamine vapor of low concentrations were measured at room temperature. It was found that the composite exhibited a linear response to the vapor in the range of 0.5-8 ppm with the highest sensitivity of ∼80%, which is much higher than that of MWNTs and PANI separately, and an obvious synergetic effect was observed. In addition, the detection limit was as low as the ppb level, and reversible and relatively fast responses (t(90%)∼200 s and ∼10 min for sensing and recovery, respectively) were observed. The sensing characteristics are highly related to the gas responses of PANI, and a sensing mechanism considering the interaction of MWNTs and PANI was proposed.

[1]  Junsheng Yu,et al.  Fabrication and gas sensitivity of polyaniline–titanium dioxide nanocomposite thin film , 2007 .

[2]  Ting Zhang,et al.  Electrochemically Functionalized Single‐Walled Carbon Nanotube Gas Sensor , 2006 .

[3]  D. Yan,et al.  Polyelectrolyte-functionalized multiwalled carbon nanotubes : preparation, characterization and layer-by-layer self-assembly , 2005 .

[4]  B. H. Weiller,et al.  Polyaniline nanofibers: facile synthesis and chemical sensors. , 2003, Journal of the American Chemical Society.

[5]  Nathan S. Lewis,et al.  Detection and Classification of Volatile Organic Amines and Carboxylic Acids Using Arrays of Carbon Black-Dendrimer Composite Vapor Detectors , 2005 .

[6]  Yang Li,et al.  Gas sensitivity of a composite of multi-walled carbon nanotubes and polypyrrole prepared by vapor phase polymerization , 2007 .

[7]  E. S. Snow,et al.  Chemical Detection with a Single-Walled Carbon Nanotube Capacitor , 2005, Science.

[8]  Yen-Wen Lin,et al.  Preparation and characterization of polyaniline/multi-walled carbon nanotube composites , 2005 .

[9]  Bingqing Wei,et al.  Miniaturized gas ionization sensors using carbon nanotubes , 2003, Nature.

[10]  Ting Zhang,et al.  Poly(m-aminobenzene sulfonic acid) functionalized single-walled carbon nanotubes based gas sensor , 2007 .

[11]  Robert C. Haddon,et al.  Chemically Functionalized Single-Walled Carbon Nanotubes as Ammonia Sensors† , 2004 .

[12]  Wojtek Wlodarski,et al.  A layered surface acoustic wave gas sensor based on a polyaniline/In2O3 nanofibre composite , 2006 .

[13]  Alan Gelperin,et al.  DNA-decorated carbon nanotubes for chemical sensing. , 2005 .

[14]  Seung Yol Jeong,et al.  Enhanced Sensitivity of a Gas Sensor Incorporating Single‐Walled Carbon Nanotube–Polypyrrole Nanocomposites , 2004 .

[15]  Fabienne Poncin-Epaillard,et al.  Polyaniline as a new sensitive layer for gas sensors , 2003 .

[16]  Jose Maria Kenny,et al.  Sensors for inorganic vapor detection based on carbon nanotubes and poly(o-anisidine) nanocomposite material , 2004 .

[17]  Manoj K. Ram,et al.  CO gas sensing from ultrathin nano-composite conducting polymer film , 2005 .

[18]  Ichiro Matsubara,et al.  The preparation of polyaniline intercalated MoO3 thin film and its sensitivity to volatile organic compounds , 2006 .

[19]  Qian Wang,et al.  Toward Large Arrays of Multiplex Functionalized Carbon Nanotube Sensors for Highly Sensitive and Selective Molecular Detection. , 2003, Nano letters.

[20]  Duk-Dong Lee,et al.  Sensing behaviors of polypyrrole sensor under humidity condition , 2005 .

[21]  Yen-Wen Lin,et al.  Doped polyaniline/multi-walled carbon nanotube composites: Preparation, characterization and properties , 2006 .

[22]  T. Someya,et al.  Alcohol Vapor Sensors Based on Single-Walled Carbon Nanotube Field Effect Transistors , 2003 .

[23]  A Wisitsoraat,et al.  The effect of carbon nanotube dispersion on CO gas sensing characteristics of polyaniline gas sensor. , 2006, Journal of nanoscience and nanotechnology.