A new technique for characterizing floating‐junction‐passivated solar cells from their dark IV curves

The incorporation of a floating junction (FJ) at the surface of a solar cell is a proven means of attaining excellent surface passivation. The development of FJ passivation for commercial use, however, has been hindered by an inherent difficulty in characterizing the FJ itself; to measure FJ parameters directly requires that electrical contact be made to the floating (i.e. uncontacted) layer that forms the FJ, and this is an irreversible process that can alter the properties of the FJ. This paper presents a new, simple technique to characterize an FJ that does not require electrical contact to the floating layer. The Ebers–Moll equivalent circuit is used to derive relationships between the cell parameters of an FJ-passivated solar cell and the shape of its dark IV curve. With these relationships, lumped, one-dimensional values can be determined for the current gains and the dark saturation currents of both the contacted and the floating junction, and the shunt resistance across the FJ. The technique is verified with device simulation and then demonstrated on two experimental FJ-passivated solar cells. Copyright © 1999 John Wiley & Sons, Ltd.

[1]  S. Glunz,et al.  The range of high-efficiency silicon solar cells fabricated at Fraunhofer ISE , 1997, Conference Record of the Twenty Sixth IEEE Photovoltaic Specialists Conference - 1997.

[2]  Joseph Mandelkorn,et al.  A new electric field effect in silicon solar cells , 1973 .

[3]  S. Wenham,et al.  Elimination of parasitic effects in floating junction rear surface passivation for solar cells , 1996, Conference Record of the Twenty Fifth IEEE Photovoltaic Specialists Conference - 1996.

[4]  M. Green,et al.  Spatially resolved analysis and minimization of resistive losses in high-efficiency Si solar cells , 1996 .

[5]  K. McIntosh,et al.  Characterisation and measurement of silicon solar cells with floating junction passivation , 1997, Conference Record of the Twenty Sixth IEEE Photovoltaic Specialists Conference - 1997.

[6]  Martin A. Green,et al.  Collection probability equals dark minority carrier concentration and other surprising solar cell relations , 1997, Conference Record of the Twenty Sixth IEEE Photovoltaic Specialists Conference - 1997.

[7]  Martin A. Green,et al.  685 mV open-circuit voltage laser grooved silicon solar cell , 1994 .

[8]  Martin S. Roden.  The Student Edition of Micro-Cap IV , 1993 .

[9]  Richard M. Swanson,et al.  Doped surfaces in one sun, point-contact solar cells , 1989 .

[10]  J. Ebers,et al.  Large-Signal Behavior of Junction Transistors , 1954, Proceedings of the IRE.

[11]  Martin A. Green,et al.  A new method for accurate measurements of the lumped series resistance of solar cells , 1993, Conference Record of the Twenty Third IEEE Photovoltaic Specialists Conference - 1993 (Cat. No.93CH3283-9).

[12]  Abasifreke Ebong,et al.  High Efficiency Double Sided Buried Contact Silicon Solar Cells , 1996 .

[13]  M. Green,et al.  Rear surface passivation of high‐efficiency silicon solar cells by a floating junction , 1996 .

[14]  B. G. Carbajal,et al.  Improved performance thin solar cells , 1978, IEEE Transactions on Electron Devices.