Flow field studies on a micro-air-vehicle-scale cycloidal rotor in forward flight

Abstract This paper examines the flow physics and principles of force production on a cycloidal rotor (cyclorotor) in forward flight. The cyclorotor considered here consists of two blades rotating about a horizontal axis, with cyclic pitch angle variation about the blade quarter-chord. The flow field at the rotor mid-span is analyzed using smoke flow visualization and particle image velocimeV are compared with flow fields predicted using 2D CFD and time-averaged force measurements acquired in an open-jet wind tunnel at three advance ratios. It is shown that the experimental flow field is nearly two dimensional at μ = 0.73 allowing for qualitative comparisons to be made with CFD. The incoming flow velocity decreases in magnitude as the flow passes through the retreating (upper) half of the rotor and is attributed to power extraction by the blades. A significant increase in flow velocity is observed across the advancing (lower) half of the rotor. The aerodynamic analysis demonstrates that the blades accelerate the flow through the lower aft region of the rotor, where they operate in a high dynamic pressure environment. This is consistent with CFD-predicted values of instantaneous aerodynamic forces which reveal that the aft section of the rotor is the primary region of force production. Phase-averaged flow field measurements showed two blade wakes in the flow, formed by each of the two blades. Analysis of the blades at several azimuthal positions revealed two significant blade-wake interactions. The locations of these blade-wake interactions are correlated with force peaks in the CFD-predicted instantaneous blade forces and highlight their importance to the generation of lift and propulsive force of the cyclorotor.

[1]  B. V. Leer,et al.  Towards the ultimate conservative difference scheme V. A second-order sequel to Godunov's method , 1979 .

[2]  F. White.  Viscous Fluid Flow , 1974 .

[3]  Benedict Moble,et al.  FUNDAMENTAL UNDERSTANDING OF THE CYCLOIDAL-ROTOR CONCEPT FOR MICRO AIR VEHICLE APPLICATIONS , 2010 .

[4]  Inderjit Chopra,et al.  Experimental and Computational Studies to Understand the Role of Flow Curvature Effects on the Aerodynamic Performance of a MAV-Scale Cycloidal Rotor in Forward Flight , 2012 .

[5]  D. Pines,et al.  Challenges Facing Future Micro-Air-Vehicle Development , 2006 .

[6]  P. Spalart.  A One-Equation Turbulence Model for Aerodynamic Flows , 1992 .

[7]  Vinod K. Lakshminarayan,et al.  Computational investigation of micro-scale coaxial rotor aerodynamics in hover , 2010 .

[8]  E. Turkel,et al.  PRECONDITIONING TECHNIQUES IN COMPUTATIONAL FLUID DYNAMICS , 1999 .

[9]  J. Gordon Leishman,et al.  Performance of a Cycloidal Rotor Concept for Micro Air Vehicle Applications , 2010 .

[10]  Inderjit Chopra.  Hovering micro air vehicles: Challenges and opportunities , 2013 .

[11]  T. Pulliam,et al.  A diagonal form of an implicit approximate-factorization algorithm , 1981 .

[12]  P. Roe.  Approximate Riemann Solvers, Parameter Vectors, and Difference Schemes , 1997 .

[13]  B. Koren.  Multigrid and defect correction for the steady Navier-Stokes equations , 1990 .

[14]  James D. Baeder,et al.  Computational Investigation of Small Scale Coaxial Rotor Aerodynamics in Hover , 2009 .

[15]  Inderjit Chopra,et al.  Experimental Investigation of the Forward Flight Performance of a MAV-Scale Cycloidal Rotor , 2012 .

[16]  B. V. Leer,et al.  Towards the Ultimate Conservative Difference Scheme , 1997 .

[17]  P. G. Migliore,et al.  Flow Curvature Effects on Darrieus Turbine Blade Aerodynamics , 1980 .

[18]  YikLoon Lee,et al.  On Overset Grids Connectivity and Vortex Tracking in Rotorcraft CFD , 2008 .

[19]  James D. Baeder,et al.  Study of Dynamic Tip Vortex Tracking in Rotorcraft CFD , 2008 .

[20]  Karthik Duraisamy,et al.  Assessment of Transition Model and CFD Methodology for Wind Turbine Flows , 2012 .

[21]  J. Gordon Leishman,et al.  Understanding the Aerodynamic Efficiency of a Hovering Micro-Rotor , 2008 .

[22]  William H. Rae,et al.  Low-Speed Wind Tunnel Testing , 1966 .