Identifying the Real Minority Carrier Lifetime in Nonideal Semiconductors: A Case Study of Kesterite Materials

Time-resolved photoluminescence (TRPL) is a powerful characterization technique to study carrier dynamics and quantify absorber quality in semiconductors. The minority carrier lifetime, which is critically important for high-performance solar cells, is often derived from TRPL analysis. However, here it is shown that various nonideal absorber properties can dominate the TRPL signal making reliable extraction of the minority carrier lifetime not possible. Through high-resolution intensity-, temperature-, voltage-dependent, and spectrally resolved TRPL measurements on absorbers and devices it is shown that photoluminescence (PL) decay times for kesterite materials are dominated by minority carrier detrapping. Therefore, PL decay times do not correspond to the minority carrier lifetime for these materials. The lifetimes measured here are on the order of hundreds of picoseconds in contrast to the nanosecond lifetimes suggested by the decay curves. These results are supported with additional measurements, device simulation, and comparison with recombination limited PL decays measured on Cu(In,Ga)Se2. The kesterite material system is used as a case study to demonstrate the general analysis of TRPL data in the limit of various measurement conditions and nonideal absorber properties. The data indicate that the current bottleneck for kesterite solar cells is the minority carrier lifetime.

[1]  R. Agrawal,et al.  Optoelectronic and material properties of nanocrystal-based CZTSe absorbers with Ag-alloying , 2016 .

[2]  X. Wen,et al.  Improving Efficiency of Evaporated Cu2ZnSnS4 Thin Film Solar Cells by a Thin Ag Intermediate Layer between Absorber and Back Contact , 2015 .

[3]  T. Unold,et al.  Effect of sodium on material and device quality in low temperature deposited Cu In,Ga Se2 , 2013 .

[4]  J. Pankow,et al.  Charge-carrier dynamics in polycrystalline thin-film CuIn1−xGaxSe2 photovoltaic devices after pulsed laser excitation: Interface and space-charge region analysis , 2015 .

[5]  C. Kaufmann,et al.  Time resolved photoluminescence on Cu(In, Ga)Se-2 absorbers: Distinguishing degradation and trap states , 2017 .

[6]  R. Scheer,et al.  Theoretical study of time-resolved luminescence in semiconductors. I. Decay from the steady state , 2014 .

[7]  W. Shafarman,et al.  Bulk and metastable defects in CuIn1−xGaxSe2 thin films using drive-level capacitance profiling , 2004 .

[8]  G. G. Stokes.  "J." , 1890, The New Yale Book of Quotations.

[9]  Richard K. Ahrenkiel,et al.  Chapter 2 Minority-Carrier Lifetime in III–V Semiconductors , 1993 .

[10]  G. Dennler,et al.  Intragrain charge transport in kesterite thin films—Limits arising from carrier localization , 2016 .

[11]  W. Metzger,et al.  Comparison of techniques for measuring carrier lifetime in thin-film and multicrystalline photovoltaic materials , 2010 .

[12]  R. Scheer,et al.  Electrical characterization of Cu(In,Ga)Se2-solar cells by voltage dependent time-resolved photoluminescence , 2015 .

[13]  I. Repins,et al.  Correlation Between Measured Minority-Carrier Lifetime and $\hbox{Cu}( \hbox{In}, \hbox{Ga})\hbox{Se}_{2}$ Device Performance , 2010, IEEE Transactions on Electron Devices.

[14]  Rakesh Agrawal,et al.  Controlled Grain Growth for High Performance Nanoparticle-Based Kesterite Solar Cells , 2016 .

[15]  P. Zabierowski,et al.  Capacitance Spectroscopy of Thin‐Film Solar Cells , 2011 .

[16]  D. Mitzi,et al.  Minority carrier diffusion length extraction in Cu2ZnSn(Se,S)4 solar cells , 2013 .

[17]  Darius Kuciauskas,et al.  The role of drift, diffusion, and recombination in time‐resolved photoluminescence of CdTe solar cells determined through numerical simulation , 2014 .

[18]  Tayfun Gokmen,et al.  Band tailing and efficiency limitation in kesterite solar cells , 2013 .

[19]  Marc Meuris,et al.  Characterization of defects in 9.7% efficient Cu2ZnSnSe4-CdS-ZnO solar cells , 2013 .

[20]  R. Herberholz,et al.  Determination of defect distributions from admittance measurements and application to Cu(In,Ga)Se2 based heterojunctions , 1996 .

[21]  Tayfun Gokmen,et al.  Low band gap liquid-processed CZTSe solar cell with 10.1% efficiency , 2012 .

[22]  Rakesh Agrawal,et al.  9.0% efficient Cu2ZnSn(S,Se)4 solar cells from selenized nanoparticle inks , 2015 .

[23]  Rakesh Agrawal,et al.  Generalized quantum efficiency analysis for non-ideal solar cells: Case of Cu2ZnSnSe4 , 2016 .

[24]  A. Tiwari,et al.  11.2% Efficient Solution Processed Kesterite Solar Cell with a Low Voltage Deficit , 2015 .

[25]  D. Abou‐Ras,et al.  Improved performance of Ge‐alloyed CZTGeSSe thin‐film solar cells through control of elemental losses , 2015 .

[26]  Wei Wang,et al.  Device Characteristics of CZTSSe Thin‐Film Solar Cells with 12.6% Efficiency , 2014 .

[27]  R. V. Overstraeten,et al.  Minority carrier recombination in heavily-doped silicon , 1983 .

[28]  R. Scheer,et al.  Theoretical study of time-resolved luminescence in semiconductors. III. Trap states in the band gap , 2015 .

[29]  D. Lang,et al.  Nonradiative capture and recombination by multiphonon emission in GaAs and GaP , 1977 .

[30]  I. Repins,et al.  Effects of sodium incorporation in Co-evaporated Cu2ZnSnSe4 thin-film solar cells , 2013 .

[31]  Richard K. Ahrenkiel,et al.  Measurement of minority-carrier lifetime by time-resolved photoluminescence , 1992 .

[32]  T. Tiedje,et al.  Band tail recombination limit to the output voltage of amorphous silicon solar cells , 1982 .

[33]  G. Ascarelli,et al.  Recombination of Electrons and Donors in n-Type Germanium , 1960 .

[34]  D. Mitzi,et al.  Loss mechanisms in hydrazine-processed Cu2ZnSn(Se,S)4 solar cells , 2010 .

[35]  G. Dennler,et al.  Deep Defects in Cu2ZnSnðS;SeÞ4 Solar Cells with Varying Se Content , 2016 .

[36]  D. Lang.  Deep‐level transient spectroscopy: A new method to characterize traps in semiconductors , 1974 .

[37]  Thomas Kirchartz,et al.  Beyond Bulk Lifetimes: Insights into Lead Halide Perovskite Films from Time-Resolved Photoluminescence , 2016 .

[38]  D. Friedman,et al.  Analysis of charge separation dynamics in a semiconductor junction , 2005 .

[39]  D. Mitzi,et al.  Hydrazine-Processed Ge-Substituted CZTSe Solar Cells , 2012 .

[40]  M. Burgelman,et al.  Advanced electrical simulation of thin film solar cells , 2013 .

[41]  Hans-Werner Schock,et al.  Chalcogenide Photovoltaics: Physics, Technologies, and Thin Film Devices , 2011 .

[42]  Rommel Noufi,et al.  Co-Evaporated Cu2ZnSnSe4 Films and Devices , 2012 .

[43]  Yun Sun,et al.  Growth of Cu2ZnSnSe4 Film under Controllable Se Vapor Composition and Impact of Low Cu Content on Solar Cell Efficiency. , 2016, ACS applied materials & interfaces.

[44]  Suhuai Wei,et al.  Indications of short minority-carrier lifetime in kesterite solar cells , 2013 .

[45]  O. Gunawan,et al.  Cu2ZnSnSe4 Thin‐Film Solar Cells by Thermal Co‐evaporation with 11.6% Efficiency and Improved Minority Carrier Diffusion Length , 2015 .

[46]  T. Unold,et al.  Photoluminescence Analysis of Thin‐Film Solar Cells , 2011 .

[47]  Tayfun Gokmen,et al.  Device characteristics of a 10.1% hydrazine‐processed Cu2ZnSn(Se,S)4 solar cell , 2012 .

[48]  Rommel Noufi,et al.  Recombination kinetics and stability in polycrystalline Cu(In,Ga)Se2 solar cells , 2009 .

[49]  R. Scheer,et al.  Theoretical study of time-resolved luminescence in semiconductors. II. Pulsed excitation , 2014 .

[50]  D. Mitzi,et al.  Electronic properties of the Cu2ZnSn(Se,S)4 absorber layer in solar cells as revealed by admittance spectroscopy and related methods , 2012 .

[51]  L. Mansfield,et al.  Fiber-fed time-resolved photoluminescence for reduced process feedback time on thin-film photovoltaics. , 2015, The Review of scientific instruments.

[52]  Rakesh Agrawal,et al.  Generalized current-voltage analysis and efficiency limitations in non-ideal solar cells: Case of Cu2ZnSn(SxSe1−x)4 and Cu2Zn(SnyGe1−y)(SxSe1−x)4 , 2014 .

[53]  R. Ahrenkiel.  Influence of junctions on photoluminescence decay in thin-film devices , 1987 .

[54]  A. El Mel,et al.  Recombination stability in polycrystalline Cu2ZnSnSe4 thin films , 2013, 2013 IEEE 39th Photovoltaic Specialists Conference (PVSC).

[55]  Tayfun Gokmen,et al.  Beyond 11% Efficiency: Characteristics of State‐of‐the‐Art Cu2ZnSn(S,Se)4 Solar Cells , 2013 .

[56]  Rakesh Agrawal,et al.  The importance of band tail recombination on current collection and open-circuit voltage in CZTSSe solar cells , 2016 .

[57]  L. Mansfield,et al.  Wild band edges: The role of bandgap grading and band-edge fluctuations in high-efficiency chalcogenide devices , 2016, 2016 IEEE 43rd Photovoltaic Specialists Conference (PVSC).

[58]  Hongen Shen,et al.  Direct minority carrier lifetime measurements and recombination mechanisms in long-wave infrared type II superlattices using time-resolved photoluminescence , 2010 .

[59]  T. Unold,et al.  Free-to-bound recombination in near stoichiometric Cu 2 ZnSnS 4 single crystals , 2012 .