Flocculation of microalgae using cationic starch

Due to their small size and low concentration in the culture medium, cost-efficient harvesting of microalgae is a major challenge. We evaluated the potential of cationic starch as a flocculant for harvesting microalgae using jar test experiments. Cationic starch was an efficient flocculant for freshwater (Parachlorella, Scenedesmus) but not for marine microalgae (Phaeodactylum, Nannochloropsis). At high cationic starch doses, dispersion restabilization was observed. The required cationic starch dose to induce flocculation increased linearly with the initial algal biomass concentration. Of the two commercial cationic starch flocculants tested, Greenfloc 120 (used in wastewater treatment) was more efficient than Cargill C*Bond HR 35.849 (used in paper manufacturing). For flocculation of Parachlorella using Greenfloc 120, the cationic starch to algal biomass ratio required to flocculate 80% of algal biomass was 0.1. For Scenedesmus, a lower dose was required (ratio 0.03). Flocculation of Parachlorella using Greenfloc 120 was independent of pH in the pH range of 5 to 10. Measurements of the maximum quantum yield of PSII suggest that Greenfloc 120 cationic starch was not toxic to Parachlorella. Cationic starch may be used as an efficient, nontoxic, cost-effective, and widely available flocculant for harvesting microalgal biomass.

[1]  A. P. Black,et al.  EFFECT OF PARTICLE SIZE ON TURBIDITY REMOVAL , 1969 .

[2]  Y. Chisti.  Biodiesel from microalgae. , 2007, Biotechnology advances.

[3]  Pascal Jaouen,et al.  Membrane technology for the continuous separation microalgae/culture medium: compared performances of cross-flow microfiltration and ultrafiltration , 1999 .

[4]  E. Olguín,et al.  Phycoremediation: key issues for cost-effective nutrient removal processes. , 2003, Biotechnology advances.

[5]  N. C. Karmakar,et al.  Novel biodegradable flocculants based on polysaccharides , 2000 .

[6]  C. Gudin,et al.  Bioconversion of solar energy into organic chemicals by microalgae , 1986 .

[7]  W. Kulicke,et al.  Cationic starches as substitute for synthetic cationic flocculants in solid-liquid separation of harbor sludge. , 2007, The journal of physical chemistry. B.

[8]  B. R. Sharma,et al.  Flocculants—an Ecofriendly Approach , 2006 .

[9]  P. Spolaore,et al.  Commercial applications of microalgae. , 2006, Journal of bioscience and bioengineering.

[10]  Pascal Jaouen,et al.  Harvesting of Cyanobacterium Arthrospira Platensis Using Organic Filtration Membranes , 2004 .

[11]  M. N. R. Kumar.  A review of chitin and chitosan applications , 2000 .

[12]  D. Bilanović,et al.  Flocculation of microalgae with cationic polymers — Effects of medium salinity , 1988 .

[13]  C. Fellows,et al.  Insights into Bridging Flocculation , 2005 .

[14]  Jesse M. Cohen.  Improved Jar Test Procedure , 1957 .

[15]  R. Guillard,et al.  YELLOW‐GREEN ALGAE WITH CHLOROPHYLLIDE C 1, 2 , 1972 .

[16]  W. Kulicke,et al.  Properties and Flocculation Efficiency of Highly Cationized Starch Derivatives , 2006 .

[17]  Dan Liu,et al.  Removal of algal blooms in freshwater using magnetic polymer. , 2009, Water science and technology : a journal of the International Association on Water Pollution Research.

[18]  Bruce Jefferson,et al.  The impact of algal properties and pre-oxidation on solid-liquid separation of algae. , 2008, Water research.

[19]  R. Divakaran,et al.  Flocculation of algae using chitosan , 2002, Journal of Applied Phycology.

[20]  E. Becker.  Microalgae: Biotechnology and Microbiology , 1994 .

[21]  Olivier Bernard,et al.  Anaerobic digestion of microalgae as a necessary step to make microalgal biodiesel sustainable. , 2009, Biotechnology advances.

[22]  R. Singh,et al.  Cationic starch: an effective flocculating agent , 2005 .

[23]  H. E. Hudson,et al.  Conduct and uses of jar tests , 1981 .

[24]  L. Wågberg,et al.  Flocculation of cellulosic fibres following addition of cationic starch , 1995 .

[25]  Y. Chisti,et al.  Recovery of microalgal biomass and metabolites: process options and economics. , 2003, Biotechnology advances.

[26]  Dion Matthew Frederick Frampton,et al.  Production of microalgal concentrates by flocculation and their assessment as aquaculture feeds , 2006 .

[27]  G. Kleinheinz,et al.  Use of Chlorella vulgaris for CO2 mitigation in a photobioreactor , 2002, Journal of Industrial Microbiology and Biotechnology.

[28]  René H. Wijffels,et al.  Ultrasound, a new separation technique to harvest microalgae , 2003, Journal of Applied Phycology.

[29]  E. Torres,et al.  Copper toxicity on the marine microalga Phaeodactylum tricornutum: effects on photosynthesis and related parameters , 1995 .

[30]  N. A. Kumar,et al.  A Perspective on the Biotechnological Potential of Microalgae , 2008 .

[31]  W. O'Connor,et al.  Development of extended shelf-life microalgae concentrate diets harvested by centrifugation for bivalve molluscs - a summary. , 2000 .

[32]  John Bratby,et al.  Coagulation and Flocculation in Water and Wastewater Treatment , 2008 .

[33]  E. Becker.  Micro-algae as a source of protein. , 2007, Biotechnology advances.

[34]  Thomas Heinze,et al.  STARCH DERIVATIVES OF HIGH DEGREE OF FUNCTIONALIZATION: 10. FLOCCULATION OF KAOLIN DISPERSIONS , 2005 .