Evaluation of the transport parameters and physiochemical properties of forward osmosis membranes after treatment of produced water

Abstract The application of semipermeable membranes for dewatering of complex oil and gas wastewaters continues to be a topic of increasing interest. Several studies have explored the fouling propensity and contaminant rejection of osmotically driven membranes during forward osmosis (FO) treatment of produced waters; however, none have investigated changes in membrane transport and physiochemical properties after exposure to these feed streams. In this study we discuss the impacts of produced water exposure on the transport and active layer surface properties of cellulose triacetate (CTA) and polyamide thin-film composite (TFC) FO membranes. While produced water exposure yields some, albeit minor changes to the membrane performance and surface characteristics of the CTA and the traditional TFC membranes, close to 50% reduction in reverse salt flux and contaminant transport was observed for a surface-modified TFC FO membrane; only minimal changes in water permeability were recorded. Results of this study demonstrate the chemical and physical robustness of FO membranes for treatment of oil and gas wastewaters, and they highlight a knowledge gap that exists in membrane polymer selection and contaminant interactions with the membrane polymer matrix that should be further addressed in future membrane fouling studies.

[1]  Tzahi Y Cath,et al.  Effects of transmembrane hydraulic pressure on performance of forward osmosis membranes. , 2013, Environmental science & technology.

[2]  W. T. Hanbury,et al.  Effect of hydrocarbon contaminants on the performance of RO membranes , 2001 .

[3]  J. Hoblitzell,et al.  Desalination of Oilfield-Produced Water at the San Ardo Water Reclamation Facility, CA , 2009 .

[4]  S. Loeb,et al.  Performance of permasep B-9 and B-10 membranes in various osmotic regions and at high osmotic pressures , 1978 .

[5]  J. Neff,et al.  Aromatic Hydrocarbons in Produced Water , 1996 .

[6]  A. Mohammad,et al.  Potential tertiary treatment of produced water using highly hydrophilic nanofiltration and reverse osmosis membranes , 2013 .

[7]  Tao He,et al.  Water reclamation from shale gas drilling flow-back fluid using a novel forward osmosis-vacuum membrane distillation hybrid system. , 2014, Water science and technology : a journal of the International Association on Water Pollution Research.

[8]  Zhongyi Jiang,et al.  Tuning the molecular structure, separation performance and interfacial properties of poly(vinyl alco , 2011 .

[9]  H. A. Massaldi,et al.  Non-ideal phenomena in osmotic flow through selective membranes , 1982 .

[10]  X. Ramis,et al.  Photocuring of cycloaliphatic epoxy formulations using polyesters with multiarm star topology as additives , 2014 .

[11]  B. Bolto,et al.  Crosslinked poly(vinyl alcohol) membranes , 2009 .

[12]  A. Neville,et al.  An experimental evaluation of reverse osmosis membrane performance in oily water , 2008 .

[13]  J. Drewes,et al.  Viability of nanofiltration and ultra-low pressure reverse osmosis membranes for multi-beneficial use of methane produced water , 2006 .

[14]  Nathan R. Hutchings,et al.  Making High Quality Frac Water out of Oilfield Waste , 2010 .

[15]  A. Fakhru’l-Razi,et al.  Review of technologies for oil and gas produced water treatment. , 2009, Journal of hazardous materials.

[16]  Nidal Hilal,et al.  Comparative study of NF and RO membranes in the treatment of produced water II: Toxicity removal efficiency , 2013 .

[17]  Bryan D. Coday,et al.  Forward osmosis desalination of oil and gas wastewater: Impacts of membrane selection and operating conditions on process performance , 2015 .

[18]  T. Urase,et al.  Retention of a wide variety of organic pollutants by different nanofiltration/reverse osmosis membranes: controlling parameters of process , 2003 .

[19]  N A T H A N,et al.  Solute Coupled Diffusion in Osmotically Driven Membrane Processes , 2009 .

[20]  L. Nghiem,et al.  Impact of chemical cleaning on the nanofiltration of pharmaceutically active compounds (PhACs): The role of cleaning temperature , 2013 .

[21]  Menachem Elimelech,et al.  A method for the simultaneous determination of transport and structural parameters of forward osmosis membranes , 2013 .

[22]  Toyoichi Tanaka,et al.  Swelling of Ionic Gels : Quantitative Performance of the Donnan Theory , 1984 .

[23]  Peng Wang,et al.  Sustainable water recovery from oily wastewater via forward osmosis-membrane distillation (FO-MD). , 2014, Water research.

[24]  Nidal Hilal,et al.  Comparative study of NF and RO membranes in the treatment of produced water—Part I: Assessing water quality , 2013 .

[25]  Kerri L. Hickenbottom,et al.  Forward osmosis treatment of drilling mud and fracturing wastewater from oil and gas operations , 2013 .

[26]  E. Hoek,et al.  Impacts of Operating Conditions and Solution Chemistry on Osmotic Membrane Structure and Performance. , 2012, Desalination.

[27]  Tzahi Y Cath,et al.  Comprehensive bench- and pilot-scale investigation of trace organic compounds rejection by forward osmosis. , 2011, Environmental science & technology.

[28]  Jinsik Sohn,et al.  Pressure assisted forward osmosis for shale gas wastewater treatment , 2015 .

[29]  Tzahi Y. Cath,et al.  Life cycle and economic assessments of engineered osmosis and osmotic dilution for desalination of Haynesville shale pit water , 2015 .

[30]  Nathan T. Hancock,et al.  Pilot demonstration of the NH3/CO2 forward osmosis desalination process on high salinity brines , 2013 .

[31]  Menachem Elimelech,et al.  Desalination and reuse of high-salinity shale gas produced water: drivers, technologies, and future directions. , 2013, Environmental science & technology.

[32]  K. Huth.  Transport , 2015, Canadian Medical Association Journal.

[33]  Reza Barati,et al.  A review of fracturing fluid systems used for hydraulic fracturing of oil and gas wells , 2014 .

[34]  Amy E. Childress,et al.  Assessing short-range membrane–colloid interactions using surface energetics , 2002 .

[35]  Tzahi Y. Cath,et al.  Indirect determination of zeta potential at high ionic strength: Specific application to semipermeable polymeric membranes , 2015 .

[36]  Andrea Achilli,et al.  Standard methodology for evaluating membrane performance in osmotically driven membrane processes , 2013 .

[37]  Tzahi Y Cath,et al.  Bidirectional permeation of electrolytes in osmotically driven membrane processes. , 2011, Environmental science & technology.

[38]  Tzahi Y. Cath,et al.  The sweet spot of forward osmosis: Treatment of produced water, drilling wastewater, and other complex and difficult liquid streams , 2014 .

[39]  Fubing Peng,et al.  Transport, structural, and interfacial properties of poly (vinyl alcohol)-polysulfone composite nanofiltration membranes , 2010 .

[40]  Tzahi Y Cath,et al.  Rejection of trace organic compounds by forward osmosis membranes: a literature review. , 2014, Environmental science & technology.

[41]  Menachem Elimelech,et al.  Influence of membrane support layer hydrophobicity on water flux in osmotically driven membrane processes , 2008 .

[42]  J. McCutcheon,et al.  A new commercial thin film composite membrane for forward osmosis , 2014 .

[43]  Tzahi Y. Cath,et al.  Forward osmosis: Novel desalination of produced water and fracturing flowback , 2014 .

[44]  S. Snyder,et al.  Application of surrogates, indicators, and high-resolution mass spectrometry to evaluate the efficacy of UV processes for attenuation of emerging contaminants in water. , 2015, Journal of hazardous materials.

[45]  Menachem Elimelech,et al.  Effect of solution chemistry on the surface charge of polymeric reverse osmosis and nanofiltration membranes , 1996 .

[46]  M. Stenstrom,et al.  Effects of water chemistry on NF/RO membrane structure and performance , 2013 .

[47]  E. Hoek,et al.  Probing polyamide membrane surface charge, zeta potential, wettability, and hydrophilicity with contact angle measurements , 2010 .

[48]  Viatcheslav Freger,et al.  Separation of concentrated organic/inorganic salt mixtures by nanofiltration , 2000 .

[49]  Menachem Elimelech,et al.  Polyamide formation on a cellulose triacetate support for osmotic membranes: Effect of linking molecules on membrane performance , 2013 .