Continuous electroreduction of CO2 to formate using Sn gas diffusion electrodes

Electrochemical valorization may be a strategy for mitigating climate change, as the process allows for CO2 to be converted into industrially useful chemicals. The aim of this work is to study the influence of key variables on the performance of an experimental system for continuous electroreduction of CO2 to formate with a gas diffusion electrode (GDE) loaded with Sn. A 23 factorial design of experiments at different levels of current density (j), electrolyte flow rate/electrode area ratio (Q/A ratio) and GDE Sn load was followed. Higher rates and concentrations (i.e., 1.4·10−3 mol m−2 s−1 and 1348 mg L−1 with efficiencies of approximately 70%) were obtained with GDEs than with plate electrodes. The statistical design of experiments demonstrated that the Sn load had the most significant effect on rate and efficiency. However, despite these promising results, further research is required to optimize the process. © 2014 American Institute of Chemical Engineers AIChE J, 60: 3557–3564, 2014

[1]  P. Kenis,et al.  Prospects of CO2 Utilization via Direct Heterogeneous Electrochemical Reduction , 2010 .

[2]  Emma ter Mors,et al.  It's not only about safety: Beliefs and attitudes of 811 local residents regarding a CCS project in Barendrecht , 2012 .

[3]  D. Liaigre,et al.  Electro-reduction of carbon dioxide to formate on lead electrode in aqueous medium , 2009 .

[4]  Thomas F. Jaramillo,et al.  New insights into the electrochemical reduction of carbon dioxide on metallic copper surfaces , 2012 .

[5]  Thomas I. Valdez,et al.  Electrochemical Conversion of Carbon Dioxide to Formate in Alkaline Polymer Electrolyte Membrane Cells , 2011 .

[6]  Yumei Zhai,et al.  The electrochemical reduction of carbon dioxide to formate/formic acid: engineering and economic feasibility. , 2011, ChemSusChem.

[7]  Revocatus Lazaro Machunda,et al.  Electrocatalytic reduction of CO2 gas at Sn based gas diffusion electrode , 2011 .

[8]  K. Asokan,et al.  Electrochemical membrane reactor for the reduction of carbondioxide to formate , 2007 .

[9]  Jinyu Han,et al.  Preparation of a Pb loaded gas diffusion electrode and its application to CO2 electroreduction , 2012, Frontiers of Chemical Science and Engineering.

[10]  Xingwen Yu,et al.  Recent advances in direct formic acid fuel cells (DFAFC) , 2008 .

[11]  Paul J. A. Kenis,et al.  Electrochemical conversion of CO2 to useful chemicals: current status, remaining challenges, and future opportunities , 2013 .

[12]  Hui Li,et al.  The Electro-Reduction of Carbon Dioxide in a Continuous Reactor , 2005 .

[13]  Mikkel Jørgensen,et al.  The teraton challenge. A review of fixation and transformation of carbon dioxide , 2010 .

[14]  Jaeyoung Lee,et al.  Microstructural surface changes of electrodeposited Pb on gas diffusion electrode during electroreduction of gas‐phase CO2 , 2010 .

[15]  Jingjie Wu,et al.  Electrochemical Reduction of Carbon Dioxide II. Design, Assembly, and Performance of Low Temperature Full Electrochemical Cells , 2013 .

[16]  G. Olah,et al.  Electrochemical reduction of CO2 over Sn-Nafion® coated electrode for a fuel-cell-like device , 2013 .

[17]  G. Centi,et al.  Carbon dioxide recycling: emerging large-scale technologies with industrial potential. , 2011, ChemSusChem.

[18]  Á. Irabien,et al.  Conversion of carbon dioxide into formate using a continuous electrochemical reduction process in a lead cathode , 2012 .

[19]  G. Olah,et al.  Anthropogenic chemical carbon cycle for a sustainable future. , 2011, Journal of the American Chemical Society.

[20]  P. Edwards,et al.  Turning carbon dioxide into fuel , 2010, Philosophical Transactions of the Royal Society A: Mathematical, Physical and Engineering Sciences.

[21]  D. Lowy,et al.  Electrochemical reduction of carbon dioxide on flat metallic cathodes , 1997 .

[22]  Toshio Tsukamoto,et al.  Electrocatalytic process of CO selectivity in electrochemical reduction of CO2 at metal electrodes in aqueous media , 1994 .

[23]  Bart W. Terwel,et al.  Initial public reactions to carbon capture and storage (CCS): differentiating general and local views , 2012 .

[24]  P. Upham,et al.  Public perceptions of CCS: Emergent themes in pan-European focus groups and implications for communications , 2011 .

[25]  A. Aldaz,et al.  Electrochemical approaches to alleviation of the problem of carbon dioxide accumulation , 2001 .

[26]  Hui Li,et al.  Development of a continuous reactor for the electro-reduction of carbon dioxide to formate – Part 2: Scale-up , 2007 .

[27]  Anil Verma,et al.  Effect of solid polymer electrolyte on electrochemical reduction of CO2 , 2012 .

[28]  Y. Zenitani,et al.  Electrochemical Reduction of Carbon Dioxide Using a Copper Rubeanate Metal Organic Framework , 2012 .

[29]  Timothy E. Fout,et al.  Advances in CO2 capture technology—The U.S. Department of Energy's Carbon Sequestration Program ☆ , 2008 .

[30]  R. Compton,et al.  Sustainable energy: a review of formic acid electrochemical fuel cells , 2011 .

[31]  Pierce W.F. Riemer,et al.  Greenhouse gas mitigation technologies, an overview of the CO2 capture, storage and future activities of the IEA Greenhouse Gas R&D programme , 1996 .

[32]  C. Oloman,et al.  Development of a continuous reactor for the electro-reduction of carbon dioxide to formate – Part 1: Process variables , 2006 .

[33]  Angel Irabien,et al.  Continuous electrochemical reduction of carbon dioxide into formate using a tin cathode: Comparison with lead cathode , 2014 .

[34]  Devin T. Whipple.  Microfluidic reactor for the electrochemical reduction of carbon dioxide , 2010 .