Microstructure of ion irradiated ceramic insulators

Abstract Cross-section transmission electron microscopy was utilized to examine the radiation-induced microstructural changes in Al2O3, MgO, Si3N4 and MgAl2O4 after irradiation with a wide variety of energetic ion beams. The relative influence of ionizing and displacive radiation was studied by systematically varying the mass and energy of the bombarding ions between 1 MeV H+ and 4 MeV Zr3+ ions. The measured ion ranges were between 1 and 15% greater than the ranges calculated by the TRIM code, with the largest discrepancies occurring for intermediate mass ions. The implanted ions exerted a strong influence on the overall microstructural evolution of the irradiated ceramics. Numerous microstructural features (e.g., amorphization, colloids) were produced in the implanted ion regions which could not be produced in irradiated regions that were well separated from the implanted ions. The microstructural evolution in regions well separated from the implanted ions was found to depend strongly on the mass and energy of the bombarding ion. Light ion irradiation produced a significant enhancement in point defect diffusion (evidenced by defect-free zones at the surface and adjacent to internal defect sinks) compared to heavy ion irradiation at the same damage rate. Similarly, irradiation with a given ion at a higher flux generally produced an increased amount of observable diffusion. In some cases such as 1 MeV proton irradiation, observable defect clusters did not form. This suppression in defect cluster formation may be due to the high amount of point defect recombination associated with ionization enhanced diffusion that occurs during energetic light ion irradiation.

[1]  L. Hobbs,et al.  Damage structures in fast neutron irradiated magnesium aluminate and electron irradiated aluminum oxynitride spinels , 1985 .

[2]  D. G. Walker.  Electron irradiation of beryllium oxide , 1964 .

[3]  C. Kinoshita,et al.  Accumulation process of cascades in ceramics under ion and/or electron irradiation , 1991 .

[4]  T. Page,et al.  Criteria for mechanical property modifications of ceramic surfaces by ion implantation , 1986 .

[5]  S. N. Buckley,et al.  The variable resistance of magnesium aluminate spinel to point-defect aggregation during irradiation , 1987 .

[6]  M. Yoo,et al.  Advances in the theory of swelling in irradiated metals and alloys , 1979 .

[7]  P. Agnew.  Displacement thresholds in sapphire , 1992 .

[8]  C. Kinoshita,et al.  Kinetic study of defect clusters in the MgO-Al2O3 system under electron- and/or ion-irradiation , 1991 .

[9]  G. P. Mueller,et al.  Depth distribution of energy deposition by ion bombardment , 1984 .

[10]  S. Zinkle.  Hardness and Depth-Dependent Microstructure of Ion-Irradiated Magnesium Aluminate Spinel , 1989 .

[11]  Defect formation in ion-irradiated Al2O3 and MgAl2O4: effects of grain boundaries and fusion transmutation products , 1992 .

[12]  C. Dubose,et al.  Technique for preparing cross-section transmission electron microscope specimens from ion-irradiated ceramics. , 1991, Journal of electron microscopy technique.

[13]  J. Ziegler,et al.  stopping and range of ions in solids , 1985 .

[14]  J. Bentley.  A review of the application of analytical electron microscopy to ion-implanted materials , 1986 .

[15]  E. P. EerNisse,et al.  Compaction of ion‐implanted fused silica , 1974 .

[16]  F. W. Clinard,et al.  Neutron irradiation damage in MgO, Al2O3 and MgAl2O4 ceramics☆ , 1982 .

[17]  N. H. Packan,et al.  Triple ion beam irradiation facility , 1989 .

[18]  J. Bourgoin,et al.  Enhanced diffusion mechanisms , 1978 .

[19]  G. W. Arnold,et al.  Atomic displacement and ionization effects on the optical absorption and structural properties of ion‐implanted Al2O3 , 1974 .

[20]  E. P. Eernisse,et al.  Volume expansion and annealing compaction of ion‐bombarded single‐crystal and polycrystalline α‐Al2O3 , 1978 .

[21]  M. Robinson,et al.  A proposed method of calculating displacement dose rates , 1975 .

[22]  R. Fournelle,et al.  Heavy ion bombardment of silicates and nitrides , 1981 .

[23]  S. J. Rothman,et al.  Steady-state point-defect diffusion profiles in solids during irradiation , 1974 .

[24]  C. Kinoshita.  Characteristics of microstructural evolution of radiation damage in ceramics under fusion environment , 1991 .

[25]  A. Stathopoulos,et al.  Radiation damage in the cation sublattice of alpha-Al2O3 , 1983 .

[26]  C. White,et al.  Ion implantation and annealing of crystalline oxides , 1989 .

[27]  S. Zinkle,et al.  Helium-assisted cavity formation in ion-irradiated ceramics , 1991 .

[28]  D. Fink,et al.  Range parameters of Au and Cs implanted into BN and SiC films , 1993 .