The Development of an Open Hardware and Software System Onboard Unmanned Aerial Vehicles to Monitor Concentrated Solar Power Plants

Concentrated solar power (CSP) plants are increasingly gaining interest as a source of renewable energy. These plants face several technical problems and the inspection of components such as absorber tubes in parabolic trough concentrators (PTC), which are widely deployed, is necessary to guarantee plant efficiency. This article presents a system for real-time industrial inspection of CSP plants using low-cost, open-source components in conjunction with a thermographic sensor and an unmanned aerial vehicle (UAV). The system, available in open-source hardware and software, is designed to be employed independently of the type of device used for inspection (laptop, smartphone, tablet or smartglasses) and its operating system. Several UAV flight missions were programmed as follows: flight altitudes at 20, 40, 60, 80, 100 and 120 m above ground level; and three cruising speeds: 5, 7 and 10 m/s. These settings were chosen and analyzed in order to optimize inspection time. The results indicate that it is possible to perform inspections by an UAV in real time at CSP plants as a means of detecting anomalous absorber tubes and improving the effectiveness of methodologies currently being utilized. Moreover, aside from thermographic sensors, this contribution can be applied to other sensors and can be used in a broad range of applications where real-time georeferenced data visualization is necessary.

[1]  Mohammadreza Aghaei,et al.  Planning for PV plant performance monitoring by means of unmanned aerial systems (UAS) , 2015 .

[2]  Julien Beaudry,et al.  On the application of VTOL UAVs to the inspection of power utility assets , 2010, 2010 1st International Conference on Applied Robotics for the Power Industry.

[3]  Chunhua Zhang,et al.  The application of small unmanned aerial systems for precision agriculture: a review , 2012, Precision Agriculture.

[4]  Robert T Kennedy,et al.  An Inexpensive, Open-Source USB Arduino Data Acquisition Device for Chemical Instrumentation. , 2016, Journal of chemical education.

[5]  Andrea Adami,et al.  Gas-Drone: Portable gas sensing system on UAVs for gas leakage localization , 2014, IEEE SENSORS 2014 Proceedings.

[6]  Lucian Busoniu,et al.  Vision and Control for UAVs: A Survey of General Methods and of Inexpensive Platforms for Infrastructure Inspection , 2015, Sensors.

[7]  Iñaki Maurtua,et al.  Thermal Tracking in Mobile Robots for Leak Inspection Activities , 2013, Sensors.

[8]  A. Lentz,et al.  Receiver behavior in direct steam generation with parabolic troughs , 1997 .

[9]  John Paulin Hansen,et al.  Low Cost and Flexible UAV Deployment of Sensors , 2016, Sensors.

[10]  Sterling Udell.  Beginning Google Maps Mashups with Mapplets, KML, and GeoRSS: From Novice to Professional , 2008 .

[11]  J. Meguro,et al.  Real-time hazard map generation using small unmanned aerial vehicle , 2008, 2008 SICE Annual Conference.

[12]  Peter Strobl,et al.  Monitoring of gas pipelines - a civil UAV application , 2005 .

[13]  Eckhard Lüpfert,et al.  Ensuring performance by geometric quality control and specifications for parabolic trough solar fields , 2014 .

[14]  Giovanni Bitella,et al.  A Novel Low-Cost Open-Hardware Platform for Monitoring Soil Water Content and Multiple Soil-Air-Vegetation Parameters , 2014, Sensors.

[15]  Alessandro Matese,et al.  An Open-Source and Low-Cost Monitoring System for Precision Enology , 2014, Sensors.

[16]  Peter van Blyenburgh,et al.  UAVs: an overview , 1999 .

[17]  José Emilio Meroño de Larriva,et al.  Monitoring Heritage Buildings with Open Source Hardware Sensors: A Case Study of the Mosque-Cathedral of Córdoba , 2016, Sensors.

[18]  N. Lewis,et al.  Powering the planet: Chemical challenges in solar energy utilization , 2006, Proceedings of the National Academy of Sciences.

[19]  Jian Chen,et al.  The Design of Data Link for Multi-UAVs , 2012, 2012 4th International Conference on Intelligent Human-Machine Systems and Cybernetics.

[20]  Clifford K. Ho,et al.  A review of high-temperature particle receivers for concentrating solar power , 2016 .

[21]  José Manuel Peñá-Barragán,et al.  Assessing Optimal Flight Parameters for Generating Accurate Multispectral Orthomosaicks by UAV to Support Site-Specific Crop Management , 2015, Remote. Sens..

[22]  K. Ravi Kumar,et al.  Numerical Investigation of Energy-Efficient Receiver for Solar Parabolic Trough Concentrator , 2008 .

[23]  Jan T. Bialasiewicz,et al.  Renewable Energy Systems With Photovoltaic Power Generators: Operation and Modeling , 2008, IEEE Transactions on Industrial Electronics.

[24]  Mahmood Yaghoubi,et al.  Thermal Stress Analysis of Absorber Tube for a Parabolic Collector under Quasi-Steady State Condition , 2015 .

[25]  Alfonso García-Ferrer,et al.  Open source hardware to monitor environmental parameters in precision agriculture , 2015 .

[26]  Celestino Ordóñez,et al.  Estimating intercept factor of a parabolic solar trough collector with new supporting structure using off-the-shelf photogrammetric equipment , 2012 .

[27]  Konstantinos Kanistras,et al.  A survey of unmanned aerial vehicles (UAVs) for traffic monitoring , 2013, 2013 International Conference on Unmanned Aircraft Systems (ICUAS).

[28]  Timothy A. Moss,et al.  Field Survey of Parabolic Trough Receiver Thermal Performance , 2006 .

[29]  Martin Fera,et al.  Automated Archiving of Archaeological Aerial Images , 2016, Remote. Sens..

[30]  Tansel Halic,et al.  Portable malignant lesion detection with low cost mobile infrared thermography , 2014, 2014 IEEE Innovations in Technology Conference.

[31]  Paul Crickard.  Leaflet.Js Essentials , 2014 .

[32]  G. Morin,et al.  Comparison of Linear Fresnel and Parabolic Trough Collector power plants , 2012 .

[33]  Tor Arne Johansen,et al.  A ligth-weight thermal camera payload with georeferencing capabilities for small fixed-wing UAVs , 2015, 2015 International Conference on Unmanned Aircraft Systems (ICUAS).

[34]  Juan A. Martín Ramos,et al.  Dynamic Modeling of the Solar Field in Parabolic Trough Solar Power Plants , 2015 .

[35]  D. A. Hoch,et al.  Infra-red and ultra-violet imaging techniques applied to the inspection of outdoor transmission voltage insulators , 2002, IEEE AFRICON. 6th Africon Conference in Africa,.

[36]  Mahmood Yaghoubi,et al.  Analysis of Heat Losses of Absorber Tubes of Parabolic through Collector of Shiraz (Iran) Solar Power Plant , 2013 .

[37]  Liang Cheng,et al.  Inspection and Structural Health Monitoring techniques for Concentrated Solar Power plants , 2016 .

[38]  D. Jones.  Power line inspection - a UAV concept , 2005 .

[39]  Vijay Devabhaktuni,et al.  Solar energy: Trends and enabling technologies , 2013 .

[40]  Imad Jawhar,et al.  UAVs for smart cities: Opportunities and challenges , 2014, 2014 International Conference on Unmanned Aircraft Systems (ICUAS).

[41]  K.P. Valavanis,et al.  Statistical profile generation for traffic monitoring using real-time UAV based video data , 2007, 2007 Mediterranean Conference on Control & Automation.

[42]  Jingxuan Sun,et al.  A Camera-Based Target Detection and Positioning UAV System for Search and Rescue (SAR) Purposes , 2016, Sensors.

[43]  Liang Dong,et al.  Real-Time Video Relay for UAV Traffic Surveillance Systems Through Available Communication Networks , 2007, 2007 IEEE Wireless Communications and Networking Conference.

[44]  Huili Zhang,et al.  Concentrated solar power plants: Review and design methodology , 2013 .

[45]  H. Faugel,et al.  Open source hard- and software: Using Arduino boards to keep old hardware running , 2013 .

[46]  Iñaki Maurtua,et al.  MAINBOT - mobile robots for inspection and maintenance in extensive industrial plants , 2014 .

[47]  Eduardo Zarza,et al.  Parabolic-trough solar collectors and their applications , 2010 .

[48]  Ran Wang,et al.  Tridimensional Reconstruction Applied to Cultural Heritage with the Use of Camera-Equipped UAV and Terrestrial Laser Scanner , 2014, Remote. Sens..

[49]  José Emilio Meroño de Larriva,et al.  An Analysis of the Influence of Flight Parameters in the Generation of Unmanned Aerial Vehicle (UAV) Orthomosaicks to Survey Archaeological Areas , 2016, Sensors.