Simulation model development and verification for high voltage GaN HEMT in cascode structure

This paper presents the development of a simulation model for high-voltage gallium nitride (GaN) high-electron-mobility transistors (HEMT) in a cascode structure. A method is proposed to accurately extract the device package parasitic inductance, which is of vital importance to better predict the high-frequency switching performance of the device. The simulation model is verified by a double-pulse tester, and the results match well both in terms of device switching waveform and switching energy. Based on the simulation model, an investigation of the package influence on the cascode GaN HEMT is presented, and several critical parasitic inductances are identified and verified. Finally, a detailed loss breakdown is made for a buck converter, including a comparison between hard switching and soft switching. The results indicate that the switching loss is a dominant part of the total loss in hard-switching conditions in MHz high-frequency range and below 8~10A operation current, therefore soft switching is preferred to achieve high-frequency and high-efficiency operation of the high-voltage GaN HEMT.

[1]  Hui Li,et al.  A High-Performance Photovoltaic Module-Integrated Converter (MIC) Based on Cascaded Quasi-Z-Source Inverters (qZSI) Using eGaN FETs , 2013, IEEE Transactions on Power Electronics.

[2]  J. Glaser,et al.  GaN Transistors for Efficient Power Conversion , 2019 .

[3]  Fred C. Lee,et al.  High-Frequency Integrated Point-of-Load Converters: Overview , 2013, IEEE Transactions on Power Electronics.

[4]  S. Heikman,et al.  A 97.8% Efficient GaN HEMT Boost Converter With 300-W Output Power at 1 MHz , 2008, IEEE Electron Device Letters.

[5]  Zheng Chen.  Characterization and Modeling of High-Switching-Speed Behavior of SiC Active Devices , 2009 .

[6]  F. Lee,et al.  Gallium Nitride based 3D integrated non-isolated point of load module , 2012, 2012 Twenty-Seventh Annual IEEE Applied Power Electronics Conference and Exposition (APEC).

[7]  U. Mishra,et al.  AlGaN/GaN HEMTs-an overview of device operation and applications , 2002, Proc. IEEE.

[8]  B. Yang,et al.  Effect and utilization of common source inductance in synchronous rectification , 2005, Twentieth Annual IEEE Applied Power Electronics Conference and Exposition, 2005. APEC 2005..

[9]  S. Yoshida,et al.  High power AlGaN/GaN HFET with a high breakdown voltage of over 1.8 kV on 4 inch Si substrates and the suppression of current collapse , 2008, 2008 20th International Symposium on Power Semiconductor Devices and IC's.

[10]  F.C. Lee,et al.  Analytical loss model of power MOSFET , 2006, IEEE Transactions on Power Electronics.

[11]  R. Burgos,et al.  Characterization and modeling of 1.2 kv, 20 A SiC MOSFETs , 2009, 2009 IEEE Energy Conversion Congress and Exposition.

[12]  Paolo Antognetti,et al.  Semiconductor Device Modeling with Spice , 1988 .

[13]  E. Santi,et al.  Modeling, Simulation, and Validation of a Power SiC BJT , 2012, IEEE Transactions on Power Electronics.

[14]  Karim S. Boutros,et al.  A 95% Efficient Normally-Off GaN-on-Si HEMT Hybrid-IC Boost-Converter with 425-W Output Power at 1 MHz , 2011, 2011 IEEE Compound Semiconductor Integrated Circuit Symposium (CSICS).

[15]  Fred C. Lee,et al.  A high frequency core loss measurement method for arbitrary excitations , 2011, 2011 Twenty-Sixth Annual IEEE Applied Power Electronics Conference and Exposition (APEC).

[16]  F. C. Lee,et al.  High frequency high power density 3D integrated Gallium Nitride based point of load module , 2012, 2012 IEEE Energy Conversion Congress and Exposition (ECCE).

[17]  I. Omura,et al.  A 120-W Boost Converter Operation Using a High-Voltage GaN-HEMT , 2008, IEEE Electron Device Letters.

[18]  J. Lazar,et al.  GaN HFET switching characteristics at 350V/20A and synchronous boost converter performance at 1MHz , 2012, 2012 Twenty-Seventh Annual IEEE Applied Power Electronics Conference and Exposition (APEC).

[19]  D. Aggeler,et al.  D$v$/D$t$ -Control Methods for the SiC JFET/Si MOSFET Cascode , 2013, IEEE Transactions on Power Electronics.

[20]  Tetsu Kachi,et al.  Loss evaluation of an AC-AC direct converter with a new GaN HEMT SPICE model , 2011, 2011 IEEE Energy Conversion Congress and Exposition.