Dynamic modeling and optimization in membrane distillation system

Abstract This paper considers a dynamic model for a direct-contact membrane distillation process based on a 2D advection-diffusion equation. Thorough analysis has been carried on the equation including descritization using an unconditionally stable algorithm with the aid of Alternating Direction Implicit method (ADI). Simulations have showed a consistency between the proposed model results and the expected behavior from the experiments. Temperature profile distribution along each membrane side, in addition to flux and flow rate variations are depicted. Distribution of temperature of all the points in feed and permeate containers has been obtained with their evolution with time. The proposed model has been validated with a data set obtained from experimental works. The comparison between the proposed model and experiments showed a matching with an error percentage less than 5%. An optimization technique was employed to find optimum values for some key parameters in the process to get certain amount of mass flux above desired values.

[1]  M. Khayet.  Membranes and theoretical modeling of membrane distillation: a review. , 2011, Advances in colloid and interface science.

[2]  Mohamed Khayet,et al.  Study of Asymmetric Polarization in Direct Contact Membrane Distillation , 2005 .

[3]  Ludovic F. Dumée,et al.  Advances in Membrane Distillation for Water Desalination and Purification Applications , 2013 .

[4]  M. Gryta.  Effectiveness of Water Desalination by Membrane Distillation Process , 2012, Membranes.

[5]  Marek Gryta,et al.  Heat transport in the membrane distillation process , 1998 .

[6]  B. J. Noye,et al.  Finite difference methods for solving the two‐dimensional advection–diffusion equation , 1989 .

[7]  E. Drioli,et al.  MEMBRANE DISTILLATION , 2012 .

[8]  Jun-de Li,et al.  Membrane distillation of brine wastes , 2008 .

[9]  Jianhua Zhang,et al.  Theoretical and experimental investigation of membrane distillation , 2011 .

[10]  Eva Sorensen,et al.  Modelling of Direct Contact Membrane Distillation for Desalination , 2010 .

[11]  L. Martinez-diez,et al.  Study of evaporation efficiency in membrane distillation , 1999 .

[12]  M. Gryta.  Water Desalination by Membrane Distillation , 2011 .

[13]  Anthony G. Fane,et al.  Heat and mass transfer in membrane distillation , 1987 .

[14]  Noreddine Ghaffour,et al.  Performance investigation of a solar-assisted direct contact membrane distillation system , 2013 .

[15]  Minh H. Nguyen,et al.  The energy challenge of direct contact membrane distillation in low temperature concentration , 2007 .

[16]  M. Dehghan.  On the numerical solution of the one-dimensional convection-diffusion equation , 2005 .

[17]  L. Martinez-diez,et al.  Temperature and concentration polarization in membrane distillation of aqueous salt solutions , 1999 .

[18]  Wolfgang Marquardt,et al.  Dynamic modeling of direct contact membrane distillation processes , 2012 .

[19]  Stephen R Gray,et al.  Direct contact membrane distillation (DCMD): Experimental study on the commercial PTFE membrane and , 2011 .