Simulation and experiments of droplet deformation and orientation in simple shear flow with surfactants

Abstract The deformation and orientation behavior of three-dimensional (3D) viscous droplets with and without surfactants is studied in simple shear flow using simulations and experiments. Two added amounts of surfactants are considered, along with a range of viscosity ratios and capillary numbers. The numerical method couples the boundary integral method for interfacial velocity, a second-order Runge–Kutta method for interface evolution, and a finite element method for surfactant concentration. The algorithm assumes a bulk-insoluble, nonionic surfactant, and uses a linear equation of state to model the relationship between the interfacial tension and the surfactant concentration on the drop surface. The algorithm was validated by comparison with other numerical results and good agreement was found. The experiments are performed in a parallel-band apparatus with full optical analysis of the droplet. The simulated and measured 3D steady-state shape of the ellipsoidal drops and their orientation are in reasonably good agreement. It was found that the surfactants have a greater effect on drop geometry for smaller viscosity ratios and that the deformation increases as the transport of surfactant becomes more convection dominated. It was also found that surfactants cause the drops to align more in the flow direction and that, for both clean and surfactant-covered drops, this alignment increases with viscosity ratio. Finally, simulations showed a wider distribution of surfactant on the interface for smaller viscosity ratios.

[1]  F. Greco,et al.  Effects of matrix viscoelasticity on drop deformation in dilute polymer blends under slow shear flow , 2003 .

[2]  Eggleton,et al.  An Adsorption-Desorption-Controlled Surfactant on a Deforming Droplet. , 1998, Journal of colloid and interface science.

[3]  S. Hartland,et al.  Surface tension of wastewater samples measured by the drop volume method , 1992 .

[4]  V. Cristini,et al.  Scalings for fragments produced from drop breakup in shear flow with inertia , 2001 .

[5]  B. Edwards,et al.  Rheology of polymer blends with matrix-phase viscoelasticity and a narrow droplet size distribution , 2004 .

[6]  V. Cristini,et al.  Drop breakup and fragment size distribution in shear flow , 2003 .

[7]  Xiaofan Li,et al.  The effect of surfactants on drop deformation and on the rheology of dilute emulsions in Stokes flow , 1997, Journal of Fluid Mechanics.

[8]  K. Stebe,et al.  Marangoni effects on drop deformation in an extensional flow: The role of surfactant physical chemistry. I. Insoluble surfactants , 1996 .

[9]  Vittorio Cristini,et al.  Effect of inertia on drop breakup under shear , 2001 .

[10]  V. Cristini,et al.  Scalings for Droplet Sizes in Shear-Driven Breakup: Non-Microfluidic Ways to Monodisperse Emulsions , 2006 .

[11]  A. Adamson.  Physical chemistry of surfaces , 1960 .

[12]  Petia M. Vlahovska,et al.  Deformation of a surfactant-covered drop in a linear flow , 2005 .

[13]  Vittorio Cristini,et al.  A new volume-of-fluid formulation for surfactants and simulations of drop deformation under shear at a low viscosity ratio , 2002 .

[14]  E. Windhab,et al.  A numerical procedure for calculating droplet deformation in dispersing flows and experimental verification , 2003 .

[15]  D. Bigio,et al.  Predicting Drop Breakup in Complex Flows from Model Flow Experiments , 1998 .

[16]  Stefano Guido,et al.  Deformation of a Newtonian drop in a viscoelastic matrix under steady shear flow: Experimental validation of slow flow theory , 2003 .

[17]  R. A. Silverman,et al.  The Mathematical Theory of Viscous Incompressible Flow , 1972 .

[18]  Charles D. Eggleton,et al.  Insoluble surfactants on a drop in an extensional flow: a generalization of the stagnated surface limit to deforming interfaces , 1999, Journal of Fluid Mechanics.

[19]  R. Aris.  Vectors, Tensors and the Basic Equations of Fluid Mechanics , 1962 .

[20]  E. Windhab,et al.  Computer-Controlled Flow Cell for the Study of Particle and Drop Dynamics in Shear Flow Fields , 2005 .

[21]  L. Gary Leal,et al.  The Influence of Surfactant on the Deformation and Breakup of a Viscous Drop: The Effect of Surfactant Solubility , 1994 .

[22]  J. J. M. Janssen,et al.  Influence of dynamic interfacial properties on droplet breakup in plane hyperbolic flow , 1997 .

[23]  C. Pozrikidis.  Effects of surface viscosity on the finite deformation of a liquid drop and the rheology of dilute emulsions in simple shearing flow , 1994 .

[24]  Villone,et al.  Experimental Determination of Drop Shape in Slow Steady Shear Flow. , 1999, Journal of colloid and interface science.

[25]  Vittorio Cristini,et al.  Drop deformation in microconfined shear flow. , 2006, Physical review letters.

[26]  A. Acrivos,et al.  A numerical study of the deformation and burst of a viscous drop in an extensional flow , 1978, Journal of Fluid Mechanics.

[27]  H. Stone.  A simple derivation of the time‐dependent convective‐diffusion equation for surfactant transport along a deforming interface , 1990 .

[28]  Howard A. Stone,et al.  The effect of surfactant on the transient motion of Newtonian drops , 1993 .

[29]  L. G. Leal,et al.  An experimental investigation of drop deformation and breakup in steady, two-dimensional linear flows , 1986, Journal of Fluid Mechanics.

[30]  J. M. Rallison.  A numerical study of the deformation and burst of a viscous drop in general shear flows , 1981, Journal of Fluid Mechanics.

[31]  B. Edwards,et al.  The influence of matrix viscoelasticity on the rheology of polymer blends , 2004 .

[32]  F. Greco.  Drop deformation for non-Newtonian fluids in slow flows , 2002 .

[33]  J. Li,et al.  Numerical simulation of breakup of a viscous drop in simple shear flow through a volume-of-fluid method , 2000 .

[34]  V. Cristini,et al.  Theory and numerical simulation of droplet dynamics in complex flows--a review. , 2004, Lab on a chip.

[35]  Stefano Guido,et al.  Three-dimensional shape of a drop under simple shear flow , 1998 .

[36]  Han E. H. Meijer,et al.  Droplet behavior in the presence of insoluble surfactants , 2004 .

[37]  L. G. Leal,et al.  The effects of surfactants on drop deformation and breakup , 1990, Journal of Fluid Mechanics.

[38]  Vittorio Cristini,et al.  Drop breakup in three-dimensional viscous flows , 1998 .

[39]  Yuriko Renardy,et al.  The effect of insoluble surfactant at dilute concentration on drop breakup under shear with inertia , 2004 .

[40]  Howard A. Stone,et al.  An experimental study of transient effects in the breakup of viscous drops , 1986, Journal of Fluid Mechanics.

[41]  Pier Luca Maffettone,et al.  Ellipsoidal drop model for single drop dynamics with non-Newtonian fluids , 2004 .

[42]  Howard A. Stone,et al.  A note concerning drop deformation and breakup in biaxial extensional flows at low reynolds numbers , 1989 .

[43]  Vittorio Cristini,et al.  Drop fragment distributions under shear with inertia , 2002 .

[44]  R. Graves,et al.  Experimental studies of drop dynamics in shear fields: Role of dynamic interfacial effects , 1980 .

[45]  Howard A. Stone,et al.  The influence of initial deformation on drop breakup in subcritical time-dependent flows at low Reynolds numbers , 1989, Journal of Fluid Mechanics.

[46]  E. J. Hinch,et al.  Numerical simulation of a concentrated emulsion in shear flow , 1996, Journal of Fluid Mechanics.

[47]  Julio M. Ottino,et al.  Stretching and breakup of droplets in chaotic flows , 1991, Journal of Fluid Mechanics.

[48]  Francesco Greco,et al.  Drop shape under slow steady shear flow and during relaxation. Experimental results and comparison with theory , 2001 .

[49]  Xiaoming Zheng,et al.  Adaptive unstructured volume remeshing - I: The method , 2005 .

[50]  E. Windhab,et al.  Droplet deformation under simple shear investigated by experiment, numerical simulation and modeling , 2005 .

[51]  J. Picot,et al.  Drop breakup in combined shear and extensional flow conditions , 2000 .

[52]  P. Maffettone,et al.  Drop shape dynamics under shear-flow reversal , 2000 .

[53]  V. Cristini,et al.  Adaptive unstructured volume remeshing - II: Application to two- and three-dimensional level-set simulations of multiphase flow , 2005 .

[54]  H. P. Grace.  DISPERSION PHENOMENA IN HIGH VISCOSITY IMMISCIBLE FLUID SYSTEMS AND APPLICATION OF STATIC MIXERS AS DISPERSION DEVICES IN SUCH SYSTEMS , 1982 .

[55]  Kathleen Feigl,et al.  Emulsion processing—from single-drop deformation to design of complex processes and products , 2005 .

[56]  Allen M. Waxman,et al.  Dynamics of a couple-stress fluid membrane , 1984 .

[57]  T. M. Tsai,et al.  Tip streaming from a drop in the presence of surfactants. , 2001, Physical review letters.

[58]  Francesco Greco,et al.  DYNAMICS OF A LIQUID DROP IN A FLOWING IMMISCIBLE LIQUID , 2004 .

[59]  Geoffrey Ingram Taylor,et al.  The formation of emulsions in definable fields of flow , 1934 .

[60]  J. M. Rallison.  Note on the time-dependent deformation of a viscous drop which is almost spherical , 1980, Journal of Fluid Mechanics.

[61]  C. Pozrikidis.  Boundary Integral and Singularity Methods for Linearized Viscous Flow: Index , 1992 .

[62]  E. Windhab,et al.  Determination of the interfacial tension of low density difference liquid-liquid systems containing surfactants by droplet deformation methods , 2006 .

[63]  Vittorio Cristini,et al.  An adaptive mesh algorithm for evolving surfaces: simulation of drop breakup and coalescence , 2001 .